RoadVitals

1999 Thomas Built Buses Transit Liner Er

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest Jul 22, 2005
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Latest Jul 16, 2001
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 1 NHTSA owner-reported complaint for the 1999 Thomas Built Buses Transit Liner Er, most frequently naming the steering category. 2 safety recalls have been issued covering this model year.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Steering1100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

2 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
01V111004

SERVICE BRAKES, AIR:SUPPLY:COMPRESSOR

Jul 16, 2001
194 units potentially affected
The defect: VEHICLE DESCRIPTION: TRANSIT AND SHUTTLE BUSES EQUIPPED WITH CUMMINS ISC AND ISL DIESEL ENGINES. THE INTERNAL FRONT BUSHING CAN SPIN, CAUSING DAMAGE TO THE AIR COMPRESSOR, AND POSSIBLY TO THE SPINDLE DRIVE AT THE REAR FACE OF THE AIR COMPRESSOR WHICH IS USED TO PROVIDE POWER TO THE VEHICLE HYDRAULIC PUMP. FAILURE OF THE AIR COMPRESSOR'S SPINDLE DRIVE COULD LEAD TO LOSS OF POWER ASSIST IF THE HYDRAULIC PUMP CEASES TO OPERATE.
The risk: WITHOUT POWER ASSIST, THE VEHICLE BECOMES VERY DIFFICULT TO TURN AND COULD POSSIBLY RESULT IN A VEHICLE CRASH.
The remedy: CUMMINS IS HANDLING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL REPLACE THE AIR COMPRESSOR. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT COMMINS AT 1-800-343-7357 OR THOMAS BUILT AT 1-336-841-5924.
FREIGHTLINER CORPORATIONView on NHTSA.gov
01V044002

STEERING:LINKAGES:TIE ROD ASSEMBLY

Feb 21, 2001
16,000 units potentially affected
The defect: VEHICLE DESCRIPTION: TRUCKS, SCHOOL BUS AND MOTOR HOME CHASSIS, AND TRANSIT BUSES EQUIPPED WITH TIE ROD ASSEMBLIES MANUFACTURED BY TRW. THE SUSPECT TIE RODS CONTAIN 24-DL MODEL BALL SOCKETS. CERTAIN OF THE TIE ROD BALL-SOCKET BEARINGS HAVE A BELOW-SPECIFICATION CASE DEPTH AND/OR HARDNESS, WHICH CAN LEAD TO PREMATURE WEAR OF THE SOCKET.
The risk: IF THIS CONDITION OCCURS, THE DRIVER CAN LOSE PARTIAL CONTROL OF THE RIGHT FRONT WHEEL, POSSIBLY RESULTING IN A CRASH.
The remedy: DEALERS WILL REPLACE THE DEFECTIVE BALL SOCKETS AND/OR DRAG LINKS. OWNER NOTIFICATION BEGAN MAY 22, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FREIGHTLINER AT 1-800-547-0712 OR TRW CUSTOMER SERVICE AT 1-866-280-3287.
FREIGHTLINER CORPORATIONManufacturer number FL-284View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Steering
Filed Jul 22, 2005

ON OUR 1999, FREIGHTLINER/THOMAS FS65 SCHOOL BUSES THE "STEERING WHEEL COVER" IS COMING LOOSE FROM METAL PORTION OF THE STEERING WHEEL. FREIGHTLINER TELLS ME THE STEERING WHEEL IS ONLY COVERED BY THE ORIGINAL 12 MONTH WARRANTY. THIS IS A ''SAFETY DEFECT'', BECAUSE IT GIVES THE DRIVER A FALSE FEEL OF THE ROAD AND STEERING.

NHTSA ID
10129731
Incident
Jul 19, 2005
Mileage
104,296 mi

Compare model years

Complaint and recall counts across every year of this model

Thomas Built Buses Transit Liner Er by model year
YearComplaintsRecallsInvestigationsIssue Index
2002010—
1999Viewing120—

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers. Older model years have had longer for reports to accumulate.