2013 Thor Motor Coach Hurricane Problems

MY WIPER BLADES MOTOR WHEN OFF THE WINDSHIELD SEVERAL TIMES AS WE DRIVING DOWN INTERSTATE 71, WHICH I HAD TO GET OUT AND RESET THEM. THIS WAS DURING THE A HUGE DOWNPOUR THIS WEEKEND IN THE KENTUCKY OFF OF INTERSTATE 71. A SEVERE ALERT WAS TEXT OUT LATER THAT NIGHT, SATURDAY MARCH 30, 2019. I WORK MYSELF TO AN EXIT WHERE AS I WAS PULLING INTO A GAS STATION TO LOOK AT THE ISSUE, I DAMAGE THE RIGHT SIDE OF MY UNIT, HITTING A BLACK POLE AT THE PUMP I WAS PULLING IN, BECAUSE I WAS UNABLE TO SEE OUT THE FRONT OF THE RV. I HAVE ATTACHED TWO PICTURES TO THE FILE SHOW HOW THE WIPERS END UP AS WE TURN AROUND AND DROVE BACK HOME. I CONTACTED ROAD SIDE SERVICE (COST $300.00) BUT THEY COULD NOT FIX THE PROBLEM DUE TO THE LACK OF PARTS FOR THE WIPER MOTOR. WE HAVE OWNED THIS UNIT FOR SIX YEARS, IF THIS WAS SUCH AN ISSUE THEY SHOULD HAVE ISSUE A NO DRIVE RECALL AND HAD THE DEALER CONTACT US DIRECTLY TO SCHEDULE THE REPAIR. I EVEN TOOK MY UNIT IN TO DEALER FOR A MINOR SERVICE ISSUE BUT NO ONE CHECK TO SEE IF THERE WERE ANY OPEN ISSUES WITH MY UNIT. *TR

WHILE DRIVING CROSS COUNTRY WE EXPERIENCED A COMPLETE FAILURE OF THE WIPERS DURING A HARD RAIN. THE WIPERS DROPPED OFF THE WINDSHIELD BUT WE WERE ABLE TO PULL OVER AND RESET THEM. ONCE WE STARTED BACK ONTO THE ROAD, THEY FAILED AGAIN. WE ENDED UP DRIVING TO THE CAMPSITE WITH NO WIPERS. WE HAD A MECHANIC COME TO LOOK AT THE PROBLEM AND WAS TOLD IT NEEDED A COMPLETE ASSEMBLY. WE DECIDED TO WAIT TILL WE GOT HOME BEFORE HAVING THE WIPERS REPAIRED. WHEN HOME, WE WENT TO A THOR DEALER WHO INFORMED US THERE WAS NO RECALL ON THIS PROBLEM ON OUR MODEL AND WE PAID $300.00 TO HAVE THE WIPERS FIXED. THAT REPAIR WORKED FOR A SHORT PERIOD OF TIME BEFORE IT FAILED AGAIN JUST LIKE THE FIRST TIME. WE NOW HAVE IT AT AN INDEPENDENT SHOP TO HAVE THE WIPERS REPAIRED. THE MECHANIC THERE ALSO INFORMED US THE WIPERS WILL NOT SHUT OFF WHEN TURNING THE SWITCH OFF. HE HAS CONTACTED THOR BUT THEY WILL NOT ASSIST IN PROVIDING PARTS OR TECHNICAL SUPPORT. *TT *TR *BF THE CONSUMER SUBMITTED PHOTOS. *TR

I HAVE A 2013 THOR HURRICANE CLASS A MOTOR HOME. THE DOOR HANDLE AND LOCK WERE MADE BY TRIMARK; PART NUMBER 060-0650. I RECENTLY DISCOVERED THAT I COULD NOT OPEN THE ENTRANCE DOOR FROM THE OUTSIDE. THIS IS THE ONLY DOOR ON THE MOTOR HOME, WHICH IS VERY COMMON WITH CLASS A'S. I THEN HAD TO CRAWL THROUGH A WINDOW TO GAIN ACCESS AND DISCOVERED I COULDN'T OPEN THE DOOR FROM THE INSIDE EITHER. THE MOTOR HOME WAS PARKED IN MY DRIVEWAY. AFTER TAKING OFF THE INSIDE DOOR TRIM, I COULD SEE THAT OPERATING THE HANDLE WAS NOT MOVING THE PLUNGER OUT OF THE STRIKE PLATE, THUS MAKING THE DOOR IMPOSSIBLE TO OPEN. AFTER USING A SMALL TOOL AND A PIECE OF STIFF WIRE I WAS ABLE TO PUSH THE PLUNGER AWAY FROM THE STRIKE PLATE AND THEN OPENED THE DOOR. WHEN THE DOOR OPENED THE BROKEN PLUNGER FLEW OUT FROM THE LOCK (THERE IS A SPRING BEHIND IT). IT WAS OBVIOUS THAT THE PLUNGER ASSEMBLY HAD BROKEN INTERNALLY. IT TOOK ME A HALF AN HOUR TO OPEN THE DOOR. AFTER DOING RESEARCH ON THE INTERNET, I FOUND A NUMBER OF RV OWNERS HAVE HAD THE SAME PROBLEM WITH THIS LOCK. THIS SITUATION IS EXTREMELY DANGEROUS IF INSIDE THE MOTOR HOME AND NEED TO ESCAPE IN AN EMERGENCY. WINNEBAGO INDUSTRIES EVEN ISSUED A RECALL ON THIS ISSUE (NHTSA SAFETY RECALL 15V-510) AND TRIMARK HAS DISCONTINUED THIS MODEL LOCK. I AM URGING YOUR AGENCY TO LOOK INTO THIS MATTER AND ISSUE A RECALL FROM ALL MOTOR HOME MANUFACTURERS USING THIS LOCK. I HAVE INCLUDED PICTURES OF THE LOCK WHERE THE PLUNGER SHOULD BE AND THE BROKEN PLUNGER ITSELF. ALSO INCLUDED IS A WEB PAGE FROM TRIMARK SHOWING THIS LOCK HAS BEEN REPLACED WITH A DIFFERENT MODEL.

TL* THE CONTACT OWNS A 2013 THOR HURRICANE. THE CONTACT STATED THAT THE SHEER PIN FELL OUT AND ONE OF THE STEPS WAS LOOSE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SHEER PIN DETACHED AND NEEDED TO BE REPLACED, WHICH CAUSED THE STEP TO BECOME LOOSE. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE CONTACT'S DAUGHTER SUFFERED A TWISTED ANKLE AND WRIST. MEDICAL ATTENTION WAS REQUIRED. IN ADDITION, THE VEHICLE EXPERIENCED EXCESSIVE LEAKING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIRMED THAT THE VEHICLE WAS LEAKING AND THE FITTINGS NEEDED TO BE TIGHTENED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. ALSO, THE REAR LADDER WAS LOOSE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIRMED THAT THE LADDER WAS NOT PROPERLY MOUNTED. THE VEHICLE WAS REPAIRED; HOWEVER, THE LADDER FAILURE CAUSED THE CONTACT TO TEAR HIS ROTATOR CUFF AND SUFFER BROKEN TEETH. MEDICAL ATTENTION WAS REQUIRED. THE VEHICLE VEERED TO THE LEFT AND RIGHT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE REAR END WAS OUT OF ALIGNMENT. THE VEHICLE WAS REPAIRED. THE VEHICLE'S OVERHEAD BUNK COULD NOT BE PROPERLY LATCHED IN THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SCHWINTEK SYSTEM MALFUNCTIONED. THE VEHICLE WAS REPAIRED ON FOUR SEPARATE OCCASIONS, BUT THE FAILURE RECURRED. THE MAIN SLIDE MADE AN ABNORMAL SOUND INTERMITTENTLY AND FAILED TO WORK PROPERLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE MAIN SLIDE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 800.

TL* THE CONTACT OWNS A 2013 THOR HURRICANE. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. UPON INSPECTION, THE CONTACT DISCOVERED THAT THE BATTERY POWER HAD DRAINED. THE CONTACT INDICATED THAT THE VEHICLE WAS REPAIRED IN JULY OF 2017 PER NHTSA CAMPAIGN NUMBER: 13V265000 (ELECTRICAL SYSTEM) TO REWIRE THE BATTERY CONTROL CENTER. THE CONTACT INDICATED THAT THE FAILURE WAS CAUSED BY THE INFORMATION LISTED IN THE RECALL. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE FAILURE MILEAGE WAS 13,000. THE VIN WAS INVALID. *TT*JB

I HAVE A 2013 THOR HURRICANE CLASS A MOTOR HOME. THE DOOR HANDLE AND LOCK WERE MADE BY TRIMARK; PART NUMBER 060-0650. I RECENTLY DISCOVERED THAT I COULD NOT OPEN THE ENTRANCE DOOR FROM THE OUTSIDE. THIS IS THE ONLY DOOR ON THE MOTOR HOME, WHICH IS VERY COMMON WITH CLASS A'S. I THEN HAD TO CRAWL THROUGH A WINDOW TO GAIN ACCESS AND DISCOVERED I COULDN'T OPEN THE DOOR FROM THE INSIDE EITHER. THE MOTOR HOME WAS PARKED IN MY DRIVEWAY. AFTER TAKING OFF THE INSIDE DOOR TRIM, I COULD SEE THAT OPERATING THE HANDLE WAS NOT MOVING THE PLUNGER OUT OF THE STRIKE PLATE, THUS MAKING THE DOOR IMPOSSIBLE TO OPEN. AFTER USING A SMALL TOOL AND A PIECE OF STIFF WIRE I WAS ABLE TO PUSH THE PLUNGER AWAY FROM THE STRIKE PLATE AND THEN OPENED THE DOOR. WHEN THE DOOR OPENED THE BROKEN PLUNGER FLEW OUT FROM THE LOCK (THERE IS A SPRING BEHIND IT). IT WAS OBVIOUS THAT THE PLUNGER ASSEMBLY HAD BROKEN INTERNALLY. IT TOOK ME A HALF AN HOUR TO OPEN THE DOOR. AFTER DOING RESEARCH ON THE INTERNET, I FOUND A NUMBER OF RV OWNERS HAVE HAD THE SAME PROBLEM WITH THIS LOCK. THIS SITUATION IS EXTREMELY DANGEROUS IF INSIDE THE MOTOR HOME AND NEED TO ESCAPE IN AN EMERGENCY. WINNEBAGO INDUSTRIES EVEN ISSUED A RECALL ON THIS ISSUE (NHTSA SAFETY RECALL 15V-510) AND TRIMARK HAS DISCONTINUED THIS MODEL LOCK. I AM URGING YOUR AGENCY TO LOOK INTO THIS MATTER AND ISSUE A RECALL FROM ALL MOTOR HOME MANUFACTURERS USING THIS LOCK. I HAVE INCLUDED PICTURES OF THE LOCK WHERE THE PLUNGER SHOULD BE AND THE BROKEN PLUNGER ITSELF. ALSO INCLUDED IS A WEB PAGE FROM TRIMARK SHOWING THIS LOCK HAS BEEN REPLACED WITH A DIFFERENT MODEL.

TL* THE CONTACT OWNS A 2013 THOR HURRICANE. THE CONTACT STATED THAT THE SHEER PIN FELL OUT AND ONE OF THE STEPS WAS LOOSE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SHEER PIN DETACHED AND NEEDED TO BE REPLACED, WHICH CAUSED THE STEP TO BECOME LOOSE. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE CONTACT'S DAUGHTER SUFFERED A TWISTED ANKLE AND WRIST. MEDICAL ATTENTION WAS REQUIRED. IN ADDITION, THE VEHICLE EXPERIENCED EXCESSIVE LEAKING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIRMED THAT THE VEHICLE WAS LEAKING AND THE FITTINGS NEEDED TO BE TIGHTENED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. ALSO, THE REAR LADDER WAS LOOSE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS CONFIRMED THAT THE LADDER WAS NOT PROPERLY MOUNTED. THE VEHICLE WAS REPAIRED; HOWEVER, THE LADDER FAILURE CAUSED THE CONTACT TO TEAR HIS ROTATOR CUFF AND SUFFER BROKEN TEETH. MEDICAL ATTENTION WAS REQUIRED. THE VEHICLE VEERED TO THE LEFT AND RIGHT. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE REAR END WAS OUT OF ALIGNMENT. THE VEHICLE WAS REPAIRED. THE VEHICLE'S OVERHEAD BUNK COULD NOT BE PROPERLY LATCHED IN THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE SCHWINTEK SYSTEM MALFUNCTIONED. THE VEHICLE WAS REPAIRED ON FOUR SEPARATE OCCASIONS, BUT THE FAILURE RECURRED. THE MAIN SLIDE MADE AN ABNORMAL SOUND INTERMITTENTLY AND FAILED TO WORK PROPERLY. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE MAIN SLIDE NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURES. THE FAILURE MILEAGE WAS 800.