2015 Thor Motor Coach Miramar Owner Complaints

FIRST INCIDENT OCCURRED WHEN DRIVING IN A HEAVY RAIN STORM, THE PASSENGER SIDE WIPER ARM DISAPPEARED FROM THE WINDSHIELD AND EVENTUALLY BECAME ENTAGLED WITH THE DRIVERS SIDE RENDERING THE WIPERS FROM WORKING. WENT TO THE DEALER AND WAS TOLD THEY WOULD BE UNABLE TO LOOK AT IT. ANOTHER MECHANIC WAS ABLE TO INSPECT THE WIPERS AND REPOSITIONED THE WIPER ARMS TO THE SPLINES AND TESTED OK. HE TOLD ME THE PROBLEM APPEARS TO BE WITH THE SPLINES ON THE PIVOT SHAFT THAT IS NOT STRONG ENOUGH TO KEEP THE ARM IN PROPER ALIGNMENT EVEN THOUGH THE NUT HOLDING THE ARM WAS TIGHT. IT WAS FINE TILL SEPTEMBER WHEN THE WIPERS FAILED AGAIN IN THE SAME MANNER DURING A HEAVY RAINSTORM OUTSIDE ANNAPOLIS, MD. TOOK IT TO A DEALER IN DELAWARE WHICH, AFTER 5 DAYS THEY WERE ABLE TO REPAIR IT REPLACING ORDERED PARTS. I WAS NOT GIVE ANY INVOICE AS TO WHAT THE REPAIRS WERE.

NHTSA ID

10971388

Incident

Aug 1, 2015

I HAVE HAD SEVERAL WIPER FAILURES ON MY MOTORHOME THAT THOR HAS NOT BEEN ABLE TO CORRECT. THE FIRST HAPPENED IN JANUARY 2015 WHEN DRIVING DOWN THE ROAD AT 55MPH DURING A NORMAL RAIN, THE DRIVERS SIDE WIPER ARM OVER EXTENDED CAUSING THE WIPERS TO BE OUT OF ALIGNMENT. THIS CAUSED THE PASSENGER SIDE TO INTERFERE WITH THE DRIVERS SIDE AND THE WIPERS CEASED TO FUNCTION. IT WAS TAKEN TO A DEALER WHERE THEY INSTALLED A NEW WIPER MOTOR. EVERYTHING WAS FINE TILL THE 2ND TIME IN JULY 2015, THE DRIVERS SIDE OVER EXTENDED AGAIN CAUSING THE SAME CONDITION. I STOPPED SINCE I WAS UNABLE TO SEE AND TRIED TO ADJUST THE ARM WHERE IT ATTACHED TO THE PIVOT, BUT THE PIVOT ASSEMBLY BROKE. I AGAIN TOOK IT TO THE DEALER WHERE THEY INSTALLED NEW WIPER ARMS. OVER THE LABOR DAY WEEKEND 2015, THE PASSENGER SIDE WIPER ARM WENT BELOW THE WINDSHIELD CAUSING THE ARMS TO BIND RESULTING IN NO WIPERS. I WILL BE TAKING IT BACK TO THE DEALER FOR REPAIRS. THERE SEEMS TO BE A PROBLEM WITH THE WIPER ARMS STAYING ON THE WINDSHIELD WHEN DRIVING HIGHWAY SPEEDS. ITS ALMOST AS THEY "LIFT" OFF THE WINDSHIELD AND THEN CAN'T REALIGN THEMSELVES.

NHTSA ID

10971294

Incident

Jan 6, 2015

WE HAD AN ISSUE WITH THE OUTSIDE KITCHEN ON OUR 2015 MIRIMAR. ON OUR LAST OUTING, ONE OF THE STRUTS THAT HOLD THE DOOR OPEN BROKE OFF. NOBODY WAS HURT, BUT IT WAS SCARY. I TOOK A LOOK AT THE STRUT AND IT LOOKED FINE. HOWEVER, THE BRACKET ON THE DOOR WAS BADLY BENT. UPON CLOSER INSPECTION, I FOUND THE THREE REMAINING BRACKETS WERE ALSO BENT. PLEASE UNDERSTAND, WE NEVER DID ANY THING WITH THIS DOOR OTHER THAN OPEN AND CLOSE IT. IN ORDER TO BE ABLE TO KEEP USING THE KITCHEN, I THOUGHT ABOUT USING THE BRACKET OFF THE DOOR STRUT ON THE BATTERY COMPARTMENT. I REALIZED IT MIGHT NOT FIT SINCE THE APPLICATION WAS DIFFERENT (HORIZONTAL VS VERTICAL). I WAS SURPRISED TO FIND THE EXACT SAME BRACKET USED THERE.

NHTSA ID

10918145

Incident

Sep 6, 2016

Mileage

5,600 mi

FOUND REAR SWAY BAR BRACKET UPPER BOLT MISSING, BRACKET LOOSE AND BUSHING OUT OF PLACE. NO MODIFICATIONS HAVE BEEN MADE TO SWAY BAR, AXLE OR CHASSIS. THIS CONDITION WAS FOUND WHILE PREPARING THE VEHICLE FOR WINTER STORAGE. IT WAS NOT NOTICED DURING ANY INSPECTION DURING THE SUMMER. VEHICLE HAS APPROXIMATELY 5690 MILES ON IT. UNKNOWN MILEAGE WHEN CONDITION OCCURRED.

NHTSA ID

10789700

Incident

Nov 10, 2015

Mileage

5,690 mi

TL* THE CONTACT OWNS A 2015 THOR MIRAMAR. WHILE MAKING A RIGHT TURN, THE CONTACT HEARD AN ABNORMAL NOISE NEAR THE FRONT END ON THE DRIVER SIDE. THE CONTACT OBSERVED THAT THE FRONT DRIVER SIDE WHEEL WAS TILTED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE NUT THAT HOLDS THE WHEEL TO THE AXLE DETACHED FROM THE VEHICLE. IN ADDITION, THE OUTER BEARING WAS FRACTURED. AS A RESULT, THE SPINDLE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 3,500.

NHTSA ID

10735305

Incident

Jul 19, 2015

Mileage

3,500 mi