2016 Thor Motor Coach Outlaw Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2016 Thor Motor Coach Outlaw, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure150.0%
- Other / unspecified150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
WE WERE TRAVELING ON THE ROAD PULLING A JEEP WRANGLER. THE RV HAS A FACTORY INSTALLED TOWING PACKAGE WITH A MAXIMUM GROSS TRAILER WEIGHT OF 8,000LBS. THE JEEP WE WERE PULLING, 5500 GVWR, WAS WELL BELOW THE REQUIRED CAPACITY. WE HEARD A NOISE AND PULLED OVER ONLY TO FIND THE HTICH IN TACK BUT THE FRAME RAIL ITSELF TORE ALLOWING THE HITCH ASSEBMLY TO HANG DOWN. HAD IT COMPLETELY BROKEN AWAY FROM THE RAME RAIL, THE JEEP WOULD HAVE BEEN UNRESTRAINED AS ALL CONNECTIONS TO OUR RV ARE MADE TO THE HITCH. THIS IS A HUGE SAFETY PROBLEM AND A PROBLEM NOT WITH THE HITCH BUT HOW IT IS SECURED TO THE FRAME. IT IS CURRENTLY BEING REPAIRED AND WILL SUPPLY PHOTOS. *DT*JB *DT CONSUMER STATED DOOR HANDLES BROKE FROM THE RV. CONSUMER STATED WELDING COST $360, PICTURES ATTACHED.*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
WE WERE TRAVELING ON THE ROAD PULLING A JEEP WRANGLER. THE RV HAS A FACTORY INSTALLED TOWING PACKAGE WITH A MAXIMUM GROSS TRAILER WEIGHT OF 8,000LBS. THE JEEP WE WERE PULLING, 5500 GVWR, WAS WELL BELOW THE REQUIRED CAPACITY. WE HEARD A NOISE AND PULLED OVER ONLY TO FIND THE HTICH IN TACK BUT THE FRAME RAIL ITSELF TORE ALLOWING THE HITCH ASSEBMLY TO HANG DOWN. HAD IT COMPLETELY BROKEN AWAY FROM THE RAME RAIL, THE JEEP WOULD HAVE BEEN UNRESTRAINED AS ALL CONNECTIONS TO OUR RV ARE MADE TO THE HITCH. THIS IS A HUGE SAFETY PROBLEM AND A PROBLEM NOT WITH THE HITCH BUT HOW IT IS SECURED TO THE FRAME. IT IS CURRENTLY BEING REPAIRED AND WILL SUPPLY PHOTOS. *DT*JB *DT CONSUMER STATED DOOR HANDLES BROKE FROM THE RV. CONSUMER STATED WELDING COST $360, PICTURES ATTACHED.*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .