2020 Thor Motor Coach Palazzo Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2020 Thor Motor Coach Palazzo, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure125.0%
- Brakes125.0%
- Electrical125.0%
- Exterior lighting125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
The lower passenger side bracket between the fiberglass front of the body and the freightliner frame has released from the frame and is in danger of falling off. If this thing did come off and go bouncing down the road it could do some real damage. Noticed after other owners warned about the problem online.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
The contact owns a 2020 Thor Palazzo built on a 2020 Freightliner X line chassis. The contact stated that while driving approximately 55 MPH during a storm, the air brakes system alarm illuminated. The contact immediately pulled over to the side of the roadway and turned off the RV. The RV was towed to the dealer who informed the contact that the air brake system had a pig tail that led into the transducer that had caused the chord to fracture. The dealer dried the moisture from the area and sprayed the area with silicon. The failure reoccurred approximately a year later when the contact had driven the RV during inclement weather. The vehicle was taken to another dealer who replaced the pig tail and transducer. The contact was informed by the dealer that due to the pig tail being attached so tightly and having no flexibility, the failure might recur. The manufacturer had been made aware of the failure. The failure mileage was approximately 15,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
The EATON Power Distribution Modual P\N A66-05172-00 (S\N 18108065) in my motorhome was in a recall associated with the failed rear tail lights, rear turn signals, brack lights, running lights and failure of towed vehicle lights plug. The modual was repaired as a result of the recall and was working properly. The repaired Modual failed again in less than 1000 miles driven resulting in no passenger tail light, no brake lights, no running lights, and no function of the towed vehicle lights plug. The recall on my PDM P\N A66-05172-00 was not successful as the PDM is not working and is a safety concern.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
The EATON Power Distribution Modual P\N A66-05172-00 (S\N 18108065) in my motorhome was in a recall associated with the failed rear tail lights, rear turn signals, brack lights, running lights and failure of towed vehicle lights plug. The modual was repaired as a result of the recall and was working properly. The repaired Modual failed again in less than 1000 miles driven resulting in no passenger tail light, no brake lights, no running lights, and no function of the towed vehicle lights plug. The recall on my PDM P\N A66-05172-00 was not successful as the PDM is not working and is a safety concern.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .