2017 Tiffin Allegro Breeze Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2017 Tiffin Allegro Breeze, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine457.1%
- Brakes114.3%
- Fuel system114.3%
- Powertrain (other)114.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
See attached document for complaint.
Two issues, both resulting in derating to 5 mph on a busy freeway. The DEF sensor has had repeated failures, resulting in 7 generations of DEF sensors, all of which have had repeated failures. Without reprogramming by Cummins, a DEF simulator, or DEF sensor replacement, the engine derates to 5mph upon 2 restarts. This results in a dangerous driving situation unless the vehicle is towed. The second issue is a faulty wiring harness in all Cummins ISV 5.0 engines, used in Nissan Pickups, buses, and Tiffin Breeze motorhomes from 2017-2019. The wiring harness was designed with injector wires that were too short, which caused injectors to intermittently fail, causing the engine to derate on the fly, causing a dangerous driving situation. In June of 2022, Cummins issued a TSB regarding this but no recall was initiated. This issue with the wiring harness and injectors is now linked to the premature engine failure of hundreds of these engines, which results in an immediate stopping of the vehicle in potentially high traffic situations. Neither Cummins nor Tiffin are acknowledging this, or replacing engines unless in warranty. For Tiffin Breeze motorhomes, 3 of the 2017 engines have failed just after warranty expiration that I personally know of. This has occurred in as little as 20,000+ miles. Tiffin and Cummins should inspect all engines that have had documented harness/injector errors for potentially damaged/overheated crankshafts, as broken crankshafts have caused the engine failures.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
See attached document for complaint.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
Two issues, both resulting in derating to 5 mph on a busy freeway. The DEF sensor has had repeated failures, resulting in 7 generations of DEF sensors, all of which have had repeated failures. Without reprogramming by Cummins, a DEF simulator, or DEF sensor replacement, the engine derates to 5mph upon 2 restarts. This results in a dangerous driving situation unless the vehicle is towed. The second issue is a faulty wiring harness in all Cummins ISV 5.0 engines, used in Nissan Pickups, buses, and Tiffin Breeze motorhomes from 2017-2019. The wiring harness was designed with injector wires that were too short, which caused injectors to intermittently fail, causing the engine to derate on the fly, causing a dangerous driving situation. In June of 2022, Cummins issued a TSB regarding this but no recall was initiated. This issue with the wiring harness and injectors is now linked to the premature engine failure of hundreds of these engines, which results in an immediate stopping of the vehicle in potentially high traffic situations. Neither Cummins nor Tiffin are acknowledging this, or replacing engines unless in warranty. For Tiffin Breeze motorhomes, 3 of the 2017 engines have failed just after warranty expiration that I personally know of. This has occurred in as little as 20,000+ miles. Tiffin and Cummins should inspect all engines that have had documented harness/injector errors for potentially damaged/overheated crankshafts, as broken crankshafts have caused the engine failures.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
Two issues, both resulting in derating to 5 mph on a busy freeway. The DEF sensor has had repeated failures, resulting in 7 generations of DEF sensors, all of which have had repeated failures. Without reprogramming by Cummins, a DEF simulator, or DEF sensor replacement, the engine derates to 5mph upon 2 restarts. This results in a dangerous driving situation unless the vehicle is towed. The second issue is a faulty wiring harness in all Cummins ISV 5.0 engines, used in Nissan Pickups, buses, and Tiffin Breeze motorhomes from 2017-2019. The wiring harness was designed with injector wires that were too short, which caused injectors to intermittently fail, causing the engine to derate on the fly, causing a dangerous driving situation. In June of 2022, Cummins issued a TSB regarding this but no recall was initiated. This issue with the wiring harness and injectors is now linked to the premature engine failure of hundreds of these engines, which results in an immediate stopping of the vehicle in potentially high traffic situations. Neither Cummins nor Tiffin are acknowledging this, or replacing engines unless in warranty. For Tiffin Breeze motorhomes, 3 of the 2017 engines have failed just after warranty expiration that I personally know of. This has occurred in as little as 20,000+ miles. Tiffin and Cummins should inspect all engines that have had documented harness/injector errors for potentially damaged/overheated crankshafts, as broken crankshafts have caused the engine failures.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .