2003 Toyota 4Runner Transmission Problems

TL* THE CONTACT OWNS A 2003 TOYOTA 4RUNNER. THE CONTACT STATED THAT THE SUBFRAME WAS RUSTED, CAUSING THE TRANSMISSION TO HANG VERY LOW. AS A RESULT, THE VEHICLE WAS INOPERABLE. THE VEHICLE WAS TOWED TO THE DEALER WHERE THE TRANSMISSION WAS RE-ATTACHED. THE MANUFACTURER WAS AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGES WERE 129,000. ..UPDATED 09/19/11 *BF ALSO, THE STEERING INTERMEDIATE SHAFT NEEDED TO BE REPLACED. UPDATED 10/28/11

NHTSA ID

10412344

Incident

Jun 1, 2011

Mileage

129,000 mi

WHEN COMING TO A STOP AND/OR ACCELERATING FROM A STOP THE CAR WILL JERK FORWARD WITH A THUD. SOMETIMES TWO OR THREE THUDS ARE FELT AND HEARD. THE DEALER WITNESSED THIS PROBLEM AND OURISMAN TOYOTA IN CHANTILLY, VA REPLACED THE TRANSMISSION AT 14,500 MILES. THE PROBLEM SEEMED TO GO AWAY FOR A WHILE. I RETURNED TO THE SAME DEALER WITH THE SAME COMPLAINT AT 32,000 MILES AND THEY REPLACED THE DRIVE SHAFT. I RETURNED AGAIN ON 11/30/04 AND THE SERVICE MANAGER WITNESSED THE SAME PROBLEM WITHIN 200 FEET OF DRIVING. THE SERVICE MANAGER INDICATED HE BELIEVES THIS IS NORMAL (EVEN THOUGH THIS WAS NOT A PROBLEM TILL ABOUT 12,000 MILES). HE IS GOING TO DISCUSS THIS WITH THE TOYOTA REP WHO IS IN TOWN THIS WEEK.*AK I

NHTSA ID

10100838

Incident

Jan 15, 2004

WHEN COMING TO A STOP OR EVEN WHEN STOPPED, A LOUD THUD IS HEARD AND FELT AS IF TORQUE CONVERTER IS STILL DOWN SHIFTING. WHEN BRAKES RELEASED, THUD IS HEARD AND FELT AGAIN AS CAR ACCELERATES. DEALER SAYS BRAKES ARE FINE! I'M CONCERNED AS THIS IS NOT A NORMAL SOUND AND RECENTLY CAR ACTUALLY FELT LIKE IT WANTED TO MOVE FORWARD AS THUD WAS FELT AND HEARD. (THIS IS UNRELATED TO THE CAR WANTED TO LURCH FORWARD AT STOP WHEN A/C IS ON!)*JB

NHTSA ID

10098033

Incident

Oct 8, 2003

Mileage

3,500 mi

THIS CONDITION COULD BE RELATED TO ITEM 2. THIS CONDITION STARTED LAST WINTER AND IS GETTING WORSE.) AFTER BEING AT A STOP AND RELEASING THE BRAKES, I GET A HARD SHAKE/THUD FROM THE DRIVELINE/BRAKES. THIS OCCURS IN 90% OF STOPS/STARTS. (E.G., IF IT WAS NORMAL, IT WOULD DO IT ALL THE TIME TO SOME DEGREE.) THERE IS NO METAL ON METAL NOISE, JUST THE SHAKE/THUD LIKE THE BRAKES ARE RELEASING TOO HARD OR THE DRIVELINE HAS TOO MUCH LASH IN IT. (CONDITION IS WORSE IF YOU COME TO A HARD STOP, BEFORE STARTING AGAIN.) 2) SOMETIMES (ABOUT 20% OF THE TIME) AFTER COMING TO A COMPLETE STOP AT A STOP SIGN OR RED LIGHT, THE TRANSMISSION GOES INTO FIRST GEAR HARD AND/OR THE CONVERTER/TORSEN DIFFERENTIAL IS UNLOCKING/LOCKING INCORRECTLY. IT WILL ACTUALLY ROCK THE VEHICLE FORWARD. SOMETIMES IT GIVES THE SAME SENSATION AS IN ITEM 3. (ACTUALLY, ON A FEW OCCASIONS I GET ITEM 2 PROBLEM FOLLOWED BY AN ITEM 1 PROBLEM. *AK

NHTSA ID

10096235

Incident

Oct 5, 2004

Mileage

13,000 mi

GATED SHIFTER, ON 2003 TOYOTA 4 RUNNER, ALLOWS YOU TO SHIFT THE VEHICLE PAST NEUTRAL (INTO REVERSE OR EVEN PARK) WHILE DRIVING, WITH OUT DEPRESSING THE BRAKE PEDAL. IF YOU PUSH STRAIGHT UP ON THE SHIFTER IT LOCKS IT OUT (AGAINST THE STAGGERED PLASTIC OF THE GATED SHIFTER). BUT IF YOU ACCIDENTALLY HIT THE SHIFTER ON AN ANGLE, IT CAN SLIDE PAST NEUTRAL AND INTO REVERSE OR EVEN PARK!*AK

NHTSA ID

10064349

Incident

Sep 5, 2003

VIBRATION IN DRIVETRAIN OF 2003 4RUNNER (AWD-V8). I DO NOT SEE MY ORIGINAL COMPLAINT LISTED IN THE NHTSA COMPLAINTS,SUBMITTED OCTOBER 2003. I AM WRITING TO LET ALL CONSUMERS KNOW THAT TOYOTA USA WAS FORCED TO BUY BACK MY 4RUNNER ON NOV 4TH 2003 THRU THE NEW VEHICLE LEMON LAW IN FLORIDA,(DUE TO THIS DRIVETRIAN VIBRATION).*AK

NHTSA ID

10052587

Incident

Nov 4, 2003

WHILE DRIVING CAN SHIFT INTO REVERSE WITHOUT APPLYING PRESSURE TO THE BRAKE PEDAL. VEHICLE WAS TAKEN TO THE DEALER. DEALER STATED THA VEHICLE HAS A GATED SHIFTER, AND IT WAS NORMAL FOR THAT TO HAPPEN. CONSUMER CONCERNED THAT THERE WAS NO LOCKING FEATURE ON THE SHIFTER. *AK

NHTSA ID

10024593

MY WIFE WAS DRIVING HER 2003 TOYOTA 4RUNNER LIMITED,V8 WHEN THE TRANSMISSION POPPED OUT OF GEAR.SHE HAD IT IN 4D GEAR FOR NORMAL DRIVING.SHE PULLED OVER AND PUT IT IN 4D GEAR AGAIN AND IT POPPED OUT A SECOND TIME.THE CHECK ENGINE LIGHT ALSO APPEARED. SHE PULLED OVER AGAIN AND TURNED OFF THE AIR CONDITIONER AND SHE PROCEEDED TO DRIVE TO HER DESTINATION WITHOUT THE GEAR POPPING OUT.SHE CALLED OUR SON TO PICK UP THE CAR TO TAKE IT TO THE DEALER FOR SERVICE.THEY FOUND NOTHING WRONG WITH THE VEHICLE. THEY SAID IT HAD TO HAPPEN WHILE THEY WERE TESTING THE CAR TO FIX THE PROBLEM BUT THEY COULDN'T REPEAT THE SAME THING THAT HAPPENED WHEN MY WIFE WAS DRIVING IT. THIS SITUATION COULD BE POTENTIALLY DANGEROUS.WHERE DO WE GO FROM HERE,WHO DO WE CONTACT? MY WIFE'S WORK NUMBER IS 412-875-1481

NHTSA ID

10016866

Incident

May 1, 2003

Mileage

5,455 mi

THE GEAR SHIFTER WAS ABLE TO GO FROM NEUTRAL TO REVERSE. PH WHILE DRIVING FROM 0-45 MPH, THE SHIFTER WAS IN THE FOURTH GEAR, AND HAD SHIFTED TO DRIVE. THE CONSUMER ACCIDENT'S PUSHED THE SHIFTER TO PARK WHILE THE VEHICLE WAS IN MOTION. THE CONSUMER FELT THAT MOST VEHICLE'S HAVE A SHIFT LOCK BETWEEN NEUTRAL AND REVERSE WHEN THE VEHICLE IS MOTION. SCC

NHTSA ID

10006770

Incident

Feb 6, 2003

Mileage

444 mi