2024 Toyota Corolla Problems

On 6/7 while driving 65 mph I hit a deer on the driver front. My car detected the crash and deployed every airbag inside the car. I received an injury to my legs from the driver's airbag under my steering wheel. If this airbag were not there, I would have had no injuries from this accident. I have missed work and was seen at the local ED for treatment.

I was driving my 2024 Toyota Corolla SE gas model (with the convenience package) on the interstate in [XXX] during stop-and-go traffic. Traffic had been moving slowly for about 15 minutes, and I had Brake Hold turned on, cruise control was off, Proactive Driving Assist was on. I was behind a semi truck and was moving very slowly, getting ready to stop. I had maybe 3 or 4 car lengths between me and the semi so they could see me in their mirrors. As I was about to stop, the brake pedal suddenly went all the way to the floor, the car jerked to a stop, and the electronic/emergency parking brake applied on its own. I put the car into Park and then back into Drive, and the problem did not happen again during that drive. There were no warning lights, dash lights, or warning messages before this happened, and there were also no warning lights or dash lights afterward. The issue happened suddenly with no prior symptoms that I noticed. I believe the brake system, Brake Hold system, electronic parking brake system, or a related brake/vehicle control system malfunctioned. This put my safety and the safety of others at risk because the car unexpectedly stopped abruptly in interstate traffic. Since I was in heavy stop-and-go traffic and other vehicles, there was a risk of being rear-ended, causing a crash, or becoming disabled in traffic. I took the vehicle to a Toyota dealership after the incident. They were not able to reproduce the problem, but they did find stored code C14FE14. They told me they checked the brake system, cleared the code, tested the steering angle sensor connector, and said everything tested within specification. They also performed a multipoint inspection and said the battery, brake pads, and other inspected items tested well. To my knowledge, the vehicle has only been inspected by the Toyota dealership/service center. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

DEFECT: Steering wheel fails to fully return to center after turns, consistently stopping 1/2-1 inch off-center. Minor steering adjustments stick and don't self-correct. Pronounced binding zone near center prevents smooth return. SYMPTOMS: After curves, wheel returns 80% but stops visibly off-center requiring manual correction. Minor lane adjustments stick and require counter-correction. Constant manual steering correction causes driver fatigue. Progressive worsening since purchase. SAFETY: Incomplete return at highway speeds causes drift. Sticking divides attention from hazards. Emergency maneuvers require manual straightening during critical response time. SERVICE: February 2026 - McGovern Toyota technician documented "VEHICLE DID NOT RETURN OR SELF CENTER" but Toyota corporate refused repair claiming "normal characteristic." Had 6+ alignments with no improvement. Recent alignment caused binding to flip sides, proving internal mechanical binding not alignment issue. RELATED: Toyota issued CSP 22TE02/TSB T-SB-0028-22 (2022) for 2018 Camry with identical "reduced return to center" caused by intermediate shaft binding. My 2024 Corolla has same defect Toyota acknowledged in 2018 models but refuses to repair. INDUSTRY PATTERN: Honda HR-V TSB 24-094 (2024), Mazda CX-90 Recall 24V-022 (26+ failed fix complaints, 2 crashes), GM Bolt TSB 17-NA-148, Ford Explorer ST owner reports - all for steering not returning to center. REQUEST: Investigate if Toyota intermediate shaft defect extends to 2024 Corolla and whether industry-wide EPS binding represents systemic safety issue. Toyota confirmed defect in writing but denies repair.

while I am driving on a highway the steering tries to turn right while i am driving. there a ditches on the right on the highway my car is not safe to drive it is putting me and my family in danger. I took my car to the dealership twice they said my car is fine.

I was driving my 2024 Toyota Corolla SE gas model (with the convenience package) on the interstate in [XXX] during stop-and-go traffic. Traffic had been moving slowly for about 15 minutes, and I had Brake Hold turned on, cruise control was off, Proactive Driving Assist was on. I was behind a semi truck and was moving very slowly, getting ready to stop. I had maybe 3 or 4 car lengths between me and the semi so they could see me in their mirrors. As I was about to stop, the brake pedal suddenly went all the way to the floor, the car jerked to a stop, and the electronic/emergency parking brake applied on its own. I put the car into Park and then back into Drive, and the problem did not happen again during that drive. There were no warning lights, dash lights, or warning messages before this happened, and there were also no warning lights or dash lights afterward. The issue happened suddenly with no prior symptoms that I noticed. I believe the brake system, Brake Hold system, electronic parking brake system, or a related brake/vehicle control system malfunctioned. This put my safety and the safety of others at risk because the car unexpectedly stopped abruptly in interstate traffic. Since I was in heavy stop-and-go traffic and other vehicles, there was a risk of being rear-ended, causing a crash, or becoming disabled in traffic. I took the vehicle to a Toyota dealership after the incident. They were not able to reproduce the problem, but they did find stored code C14FE14. They told me they checked the brake system, cleared the code, tested the steering angle sensor connector, and said everything tested within specification. They also performed a multipoint inspection and said the battery, brake pads, and other inspected items tested well. To my knowledge, the vehicle has only been inspected by the Toyota dealership/service center. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am reporting an ongoing safety issue involving the Skid Control ECU and loss of power break recall on my 2024 Toyota corolla hybrid. The first time, my vehicle experienced loss of power brake assist and displayed a “Hybrid System Malfunction” message on screen. I towed my car to Toyota, confirmed it was related to the Skid Control ECU recall and repaired it under the recall at no cost, they did a software update. The second time, the exact same problem reoccurred. I had the vehicle towed again to a Toyota dealership, but this time, they refused to perform diagnostics unless I paid out of pocket for a 12-volt battery replacement. The dealership stated they cannot confirm if the issue is recall-related until diagnostics are complete, but they also refuse to complete diagnostics without me paying first. My vehicle is currently undrivable and unsafe, and I rely on it for daily transportation and work. So they made my pay for this 12v battery to do the diagnostics and now they tell me it is not recall related but one of the relays not working, the repair will be cover under warrant but i had to pay for battery and rental cars . I believe Toyota is in violation of its obligations under 49 U.S.C. §30120, which requires manufacturers to correct recall-related safety defects free of charge. This issue leaves me without a vehicle and unable to verify that the recall has been properly resolved. I have opened a case with toyota brand engagement. I am requesting that NHTSA review this case and ensure that Toyota complies with recall repair requirements so my vehicle can be safely diagnosed and repaired without charge.

I am filing a safety complaint for my 2024 Toyota Corolla because the infotainment screen intermittently goes black while driving. This is most dangerous when I am using GPS/navigation while driving. The screen has gone black while driving on busy highways at 60+ mph, leaving me without functional navigation. This creates a distraction and safety concern because I suddenly lose directions and may need to look at my phone or troubleshoot the screen while driving. The car has also had recurring phone connectivity issues. Sometimes my phone does not connect through Bluetooth or even when plugged in directly. However, the black screen while driving is the bigger safety issue. I contacted Toyota multiple times. Toyota reference number: #[XXX]. Toyota told me to take the car to the dealership, which I did many times while the vehicle was still under warranty. I took it to two different Toyota dealerships multiple times. They repeatedly said there was no issue because they could not duplicate it. They also blamed Fitbit devices connected to my phone, which did not explain the screen going black while driving. I sent Toyota and the dealerships videos of the issue. However, it is difficult and unsafe to record the screen failure while actively driving. I also contacted Toyota about lemon law concerns, case [XXX]. Toyota denied the claim. The vehicle is now out of warranty, but the screen still occasionally goes black while driving. This issue was reported multiple times during the warranty period and was never resolved. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

"I am reporting a fatal crash involving a 2024 Toyota Corolla (VIN [XXX] I do not know the exact mechanical cause, but the following symptoms occurred: 1) The driver reported dashboard lights (red and blue) flickering on and off, windows and locks going on or off. 2) There was hesitation in acceleration after taking off, 3) The vehicle failed to stop and went airborne causing a FATAL accident. Insurance Co. failed to investigate porperly and sold the car To Co-part without waiting for Probate forms to be complete for this vehicle and the Estate. We have discovered this car was an Avis fleet vehicle sold as 'new' at Beaver Toyota. I am requesting a federal investigation to determine if a mechanical or electronic defect caused this loss of control." INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The 2024 Toyota Corolla needs to be added to the list of vehicles currently being investigated for transmission/engine issues. The vehicle in question is currently exhibiting transmission anomalies consistent with those observed in several other vehicles under review, specifically: slipping, jerking, surging forward, hesitation to accelerate from a complete stop, loss of power, droning sound at low speed, odd knocking noise/vibration during idle, unresponsive gear changes, shuddering upon vehicle shutdown, and decreased fuel efficiency. The owner has incurred expenses exceeding $2,000 for rental vehicles and diagnostic services in an effort to resolve these persistent issues. However, as of January 21, 2026, Toyota has not acknowledged the existence of a problem, asserting that these conditions are within normal operating parameters and that the vehicle is performing as intended. A local mechanic has advised the owner that Toyota will not diagnose the issue, but they are likely to offer a post-warranty adjustment should the transmission ultimately fail. It has become increasingly apparent that Toyota is not conducting a thorough investigation into these matters and expects the customer to bear the expense beyond the scope of the standard warranty. Beyond the immediate safety concerns for the owner, there is a significant risk of collision should the vehicle experience a loss of control or erratic behavior. Thank you for your time and assistance in investigating this matter.

During a routine transmission fluid service on a 2024 Toyota Corolla Hybrid, I discovered that the transmission model (PA10) is completely unlabeled and cannot be identified anywhere under the hood, in the owner’s manual, or on any visible tag. The only label is buried behind the firewall and not reasonably accessible to consumers or technicians. As a result, I initially attempted to service the wrong fluid port because Toyota provides no visible or clear identification of the transmission model or fill/drain points. Additionally, the factory-installed transmission drain and fill bolts were tightened with extreme torque well beyond normal service specifications, requiring application of high heat and excessive force to loosen. This resulted in personal injury and risk of property damage. The combination of (1) inaccessible transmission identification, (2) inadequate service guidance, and (3) extreme bolt torque creates a foreseeable safety hazard to vehicle owners or technicians attempting basic maintenance. Toyota’s official service documentation (Toyota Technical Information System, “TIS”) that clarifies the correct fill ports is paywalled and not included with the vehicle or manual, making it impossible for consumers to safely perform essential maintenance without paying daily access fees. This lack of accessible labeling and over-torqued components presents an avoidable risk of physical injury, vehicle damage, and mis-servicing. I believe Toyota should be required to provide visible transmission identification and safe torque specifications for consumer maintenance.

The contact owns a 2024 Toyota Corolla. The contact stated that while idling at a stop, the vehicle was rear-ended. During the crash, the driver's seat unexpectedly reclined backwards, and the air bags failed to deploy. The contact received an on-site assessment by the paramedics but declined to be transported from the scene. The contact later sought medical attention for whiplash, a concussion, and neck and back pain. The other driver involved in the crash had not been injured. No Police report was filed. The manufacturer was notified of the issue and provided a reference number. The vehicle was not diagnosed or repaired. The failure mileage was approximately 45,500.

I was involved in a vehicle accident Mar. 31, 2026. And only the side curtain air bags deployed. Neither driverside steering wheel airbag (which caused me to fracture my sternum) nor the passanger side airbag deployed.

Car has broke down a total of 4 times since I have gotten it from Toyota back in December of 2023. I have a dash-cam now that has footage of the car breaking down. Toyota fails to acknowledge my concerns and comes up with excuses and tells me to wait until it happens more frequently. I would love to have this car inspected, but as Toyota has stated they cannot get the issue to repeat. My safety for others and myself feel uneasy with the whole ordeal as it happens at the most random times. The first few times my car has broke down, the steering wheel locked up and forced itself all the way to the left on its own causing me to hit a curb and median. Manual control over the steering wheel was not possible. Luckily with this occurring both times I was going a slow speed. The other two times I had full control of the wheel but my engine would stop and the engine stopped message would appear on my dash screen. Vehicle has been inspected by the dealership 4 times with no luck on repeating the issue. Breaking down presented a dash message of engine stopped, abs system stopped, power steering stopped and would quickly cycle through warnings and shutdown.

Upon startup in cold weather conditions, a brief but loud grinding/rattling sound will occur. The noise is related to an inadequate spring inside of the intake camshaft gear which will not push a small cylinder in place to lock the intake camshaft gear in place. When not in its proper place, the gear will rattle in its housing, causing the brief noise. If the gear rattles against its housing too hard overtime, it can break and cause catastrophic engine failure by sending metal pieces into the engine, including pistons and rods.

The contact owns a 2024 Toyota Corolla. The contact stated while driving 60 MPH, the headlights failed to respond. There was a warning light illuminated that there was a failure with the front headlights. The vehicle was taken to the dealer and the contact was informed that the failure was with the headlight; however, the dealer was not able to repair the headlights. The contact was then informed to take the vehicle to a friend of the dealer. The friend of the dealer confirmed the failure and was unable to repair the headlights. The friend suggested that the vehicle be taken to a Toyota dealer. The vehicle was taken to the dealer and the contact was informed that the headlights were not the OEM headlights. The vehicle was diagnosed with connector failure and that the headlights needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The failure mileage was approximately 15,311.

My 2024 Carola Hybrid Headlights create blind spot in front of the car at night at 50meters to 100m by Toyota engineer design (there is a corner designed into the line of sight of the headlight). Toyota customer care and the dealer maintenance manager is saying the design is safety tested and approved. It needs to be retested at night!!! This is a clear design defect. It is especially dangerous curving left & making left turns on two way back roads and highways. Have to turn on brights to see but that creates risk to other drivers.

Subject / Issue: Child car seat caused vehicle seat belt to become permanently jammed Complaint: I am reporting a safety-related issue involving an Evenflo Revolve 360 child car seat. During normal use, the vehicle seat belt became slightly twisted inside the car seat base, and the seat stopped rotating properly. We were then unable to remove the child car seat from the base following the standard removal instructions. While attempting to safely remove the seat, the vehicle seat belt became completely jammed inside the base. The seat belt is now fully immobilized and cannot move in either direction. As a result, the child car seat is permanently stuck in the vehicle, and the seat belt system in the left rear seat is unusable. We had the vehicle inspected at a Toyota service center, and they confirmed that the only way to remove the child seat is to cut and replace the left rear seat belt. The estimated repair cost is approximately $680. This situation has rendered a vehicle safety restraint system inoperable and requires cutting the seat belt to resolve the issue. I am concerned about the safety design and potential risk if this occurs during normal consumer use. Photos of the issue are available and can be provided if needed.

One part of the strap is 3/4 of the way frayed

Subject: Vehicle safety complaint — dashboard/windshield reflection severely impairing visibility on 2014 Toyota Corolla (VIN: [XXX] ) To Whom It May Concern, I am writing to report a serious safety issue with my 2014 Toyota Corolla, VIN [XXX] . Under certain daylight conditions, the dashboard (or a component of it) reflects sharply on the windshield, producing a glare so intense that it significantly impairs my ability to see the road ahead. Vehicle details: Make: Toyota Model: Corolla Year: 2014 VIN: [XXX] Approx. current mileage: [insert mileage] Problem description: - At specific times of day — when sun angle, interior lighting, and windshield geometry combine — the dashboard reflection becomes very pronounced. - The reflected dashboard elements (vents, panels, interior contours) appear on the windshield glass and overlap the driver’s forward view. - This glare regularly blocks or obscures pedestrians, other vehicles, road signs, or hazards ahead. - The issue is not cosmetic; it directly reduces visibility and increases risk while driving. - The vehicle remains stock — no aftermarket modifications have been made to dashboard or windshield that could cause this reflection. Impact on safety: - I frequently struggle to see clearly under these lighting conditions, compromising my ability to react properly to traffic, obstacles, or sudden changes — especially when approaching intersections or dealing with glare. - This defect endangers not only me and my passengers, but also other road users: drivers, cyclists, and pedestrians. Request: I request that National Highway Traffic Safety Administration (NHTSA) review this issue for the 2014 Toyota Corolla (and possibly other model years) to assess whether dashboard materials, interior design, or windshield geometry create a widespread visibility defect. I am willing to provide additional documentation — such as photographs or videos showing the reflection INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C.

Windshield brittle / easily fractured. Small pebble fractured windshield, needs to be replaced.

The contact owns a 2024 Toyota Corolla. The contact stated that while idling at a stop, the vehicle was rear-ended. During the crash, the driver's seat unexpectedly reclined backwards, and the air bags failed to deploy. The contact received an on-site assessment by the paramedics but declined to be transported from the scene. The contact later sought medical attention for whiplash, a concussion, and neck and back pain. The other driver involved in the crash had not been injured. No Police report was filed. The manufacturer was notified of the issue and provided a reference number. The vehicle was not diagnosed or repaired. The failure mileage was approximately 45,500.

Component/system failed: The SRS Airbag System malfunctioned. After a rear-end collision on October 3, 2025, in Gwinnett County, GA, the airbags did not deploy. The vehicle displayed an alert: “SRS Airbag System – Malfunction detected” at 16:02. Safety risk: My safety was put at risk because the airbags did not function during a significant impact. This failure could have resulted in severe injury if the collision had been more forceful or from another angle. Inspection/reproduction: On October 6, 2025, I brought the vehicle to Atlanta Toyota. Instead of documenting the diagnostic trouble code (DTC) and providing a report, the dealer cleared the fault code and recalibrated the system without my authorization, effectively erasing critical evidence of the malfunction. The invoice confirms this. Inspections by others: The vehicle was inspected only by the Toyota dealer. It has not yet been inspected by the manufacturer, police, or insurance representatives, but I have legal counsel and am preserving the evidence for further independent inspection. Warning lamps/messages: Yes. The SRS Airbag System Malfunction message appeared immediately after the collision on October 3, 2025. I have photographic evidence of this alert.

This is my fourth service visit for the same unresolved safety issue on my 2024 Toyota Corolla Hybrid. The problem involves a cracked fuel line and fuel vapor leak in the same area as recall 24TC08 (Fuel Tank Filler Clamp and Vapor Leak Detection). The dealership initially failed to detect this during recall work and later claimed “rodent damage” after two prior visits. I have since used a professional-grade MultiRAE Lite gas detector and documented VOC (volatile organic compounds) levels up to 123 ppm inside the vehicle cabin with the windows up. These readings indicate hazardous fuel vapor and exhaust gas intrusion, which pose serious health and fire risks. I have driven over 200 miles in these conditions), exposing myself to harmful fumes. The dealership has failed to properly repair the issue, and Toyota has not resolved the safety hazard despite repeated service attempts.

he asked to change in a few weeks