2016 Toyota Highlander Hybrid Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2016 Toyota Highlander Hybrid, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes337.5%
- Body & structure112.5%
- Driver assistance112.5%
- Fuel system112.5%
- Other / unspecified112.5%
- Steering112.5%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
WE WERE DRIVING ON THE HIGHWAY ON 5/16/20. WE WERE DRIVING AROUND 65 MPH STRAIGHT. WE WERE DRIVING ON BLACK ASPHALT AND THEN WHEN WE DROVE OVER A BRIDGE WITH WHITE/GRAYISH CONCRETE, THE CAR'S EMERGENCY BRAKING SYSTEM ACTIVATED AND APPLIED SUDDEN BRAKING EVEN THOUGH WE WERE NORMALLY DRIVING. THE CAR JOLTED AND SLOWED DOWN AND ALL PASSENGERS WERE STOPPED BY AUTO-LOCKING SEATBELTS. *TR
BRAKE BOOSTER IS BAD. BRAKE IS SPONGY. REPEATED ATTEMPTS TO TAKE TO DEALER LEAD TO NO ACTION AFTER COMPLAINING LOUDLY AND THE DEALER SAID MY WIFE JUST HAS HIGH BLOOD PRESSURE. BUT THAT IS NOT THE CASE, MY HIGHLANDER HAS LOW BRAKE PRESSURE NOT "HIGH BLOOD PRESSURE. TOYOTA DOES NOT SHARE INFORMATION ABOUT THIS DEFECT BY PRETENDING DEFECT DOESN'T EXIST AND NOT NOTIFYING DEALERS. CHECK PRIUS BOOSTER RECALL. SIMILAR TECHNOLOGY THAT DOESN'T SEEM TO CHANGE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
THE DOOR ON THE DRIVERS SIDE TOP CORNER STRUCK ME IN THE TEMPLE AND CAUSED BLEEDING AND A HEADACHE. THE DOOR HAS A SHARP ANGLE. IT WAS STATIONARY I CLOSED THE DOOR AND WAS EXITING THE VEHICLE TO GO IN A CROWDED RESTAURANT. IN A PRIVATE PARKING LOT.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
WE WERE DRIVING ON THE HIGHWAY ON 5/16/20. WE WERE DRIVING AROUND 65 MPH STRAIGHT. WE WERE DRIVING ON BLACK ASPHALT AND THEN WHEN WE DROVE OVER A BRIDGE WITH WHITE/GRAYISH CONCRETE, THE CAR'S EMERGENCY BRAKING SYSTEM ACTIVATED AND APPLIED SUDDEN BRAKING EVEN THOUGH WE WERE NORMALLY DRIVING. THE CAR JOLTED AND SLOWED DOWN AND ALL PASSENGERS WERE STOPPED BY AUTO-LOCKING SEATBELTS. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
STOPPED IN INTERSECTION WAITING TO MAKE A LEFT TURN. WHEN ATTEMPTING TO ACCELERATE ENGINE DID NOT START HYBRID WARNING STATED HYBRID SYSTEM FAILURE STOP IMMEDIATELY. GLIDED TO A PARKING SPACE. ATTEMPTED TO RESTART ENGINE CONTINUE TO GET SAME WARNING. AFTER THREE ATTEMPTS CALLED AAA AND TOYOTA DEALERSHIP. I WAS URGED TO TOW THE VEHICLE. AFTER APPROXIMATELY 20 MINUTES, ATTEMPTED TO START AGAIN THE VEHICLE TURNED ON AS IF NOTHING HAPPENED. ALL WARNING LIGHTS AT THAT TIME WERE EXTINGUISHED. DEALERSHIP FOUND A GENERAL WARNING ON VEHICLE COMPUTER. DEALERSHIP COULD FIND NOTHING WRONG WITH THE VEHICLE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2016 TOYOTA HIGHLANDER HYBRID. WHILE DRIVING 40 MPH USING THE FACTORY COMPACT SPARE TIRE, THE CONTACT LOST CONTROL OF THE STEERING WHEN DRIVING OVER GROOVED ROADS. THE CONTACT FILED A COMPLAINT WITH THE MANUFACTURER, BUT THERE WAS NO RESOLUTION. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 28,000. *TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2016 TOYOTA HIGHLANDER HYBRID. WHILE DRIVING 40 MPH USING THE FACTORY COMPACT SPARE TIRE, THE CONTACT LOST CONTROL OF THE STEERING WHEN DRIVING OVER GROOVED ROADS. THE CONTACT FILED A COMPLAINT WITH THE MANUFACTURER, BUT THERE WAS NO RESOLUTION. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 28,000. *TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .