2020 Toyota Highlander Hybrid Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2020 Toyota Highlander Hybrid, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Airbags444.4%
- Brakes222.2%
- Body & structure111.1%
- Tires & wheels111.1%
- Visibility111.1%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
The contact owns a 2020 Toyota Highlander Hybrid. The contact received notification of NHTSA Campaign Number: 23V865000 (Air Bags); however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was made aware of the issue and confirmed that parts were not yet available. The manufacturer was made aware of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
The contact owns a 2020 Toyota Highlander Hybrid. The contact received notification of NHTSA Campaign Number: 23V865000 (AIR BAGS); however, the part to do the recall repair was unavailable. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was not notified of the issue. The contact had not experienced a failure. VIN tool confirms parts not available.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
After driving on an interstate and having my foot on the brake - the car jumps forward and accelerates. It has done this for a couple years, and it continues to happen more frequently. Sometimes it just jumps forward when you are driving through town and go to slow down. This seems like a safety issue.
The contact owns a 2020 Toyota Highlander. The contact stated that while driving at various speeds, the brake pedal would depress to the floorboard and the vehicle would fail to stop. There was no warning light illuminated. The vehicle was taken to a dealer where the mechanic repaired the brake calibrations and brake alignment. Despite the repair, the contact stated that the failure returned. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 38,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
The contact owns a 2020 Toyota Highlander Hybrid. The contact stated that while driving on the highway at 75 MPH, the front passenger’s and driver’s side top shield assembly and the engine cover under components became detached from the vehicle. There was no warning light illuminated. The contact was unable to recover the parts. The vehicle was taken to a local dealer where it was diagnosed, and the contact was informed that the was no reason for the parts to have detached from the vehicle unless there was a crash. The contact emphasized that the parts had detached while driving. The components were replaced, and the vehicle was repaired; however, the contact believed that the repair was not appropriate because there were zip ties left underneath the vehicle. The manufacturer was notified of the failure. The approximate failure mileage was 60,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2020 TOYOTA HIGHLANDER HYBRID EQUIPPED WITH GOODYEAR TIRES, TIRE LINE: EAGLE, TIRE SIZE: 235/55/R20, DOT NUMBER: M68AJM1R0720. THE CONTACT STATED WHILE DRIVING 70 MPH, THE TREAD ON THE PASSENGER'S SIDE REAR SEPARATED, CAUSING THE TIRE TO EXPLODE. THE CONTACT PULLED OVER AND REPLACED THE TIRE WITH THE SPARE TIRE. THE VEHICLE WAS TAKEN TO VANCOUVER TOYOTA (10455 NE 53RD ST, VANCOUVER, WA 98662, (360)944-3001) WHERE THE TIRE WAS REPLACED. THE MANUFACTURER WAS INFORMED OF THE FAILURE HOWEVER, THERE WAS NO ASSISTANCE PROVIDED. THE APPROXIMATE FAILURE MILEAGE WAS 9,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
The contact owns a 2020 Toyota Highlander Hybrid. The contact stated that the climate control system failed to defrost the windows during rainy or cold weather conditions. As a result, the contact was unable to defrost the windows, making it difficult to see the roadway. The contact was concerned for his safety while operating the vehicle. An undisclosed dealer was notified of the failure. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 19,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .