2009 Toyota RAV4 Powertrain (other) Problems

My rear passenger suspension has multiple part damage. Rear shock bracket failure and other parts.

NHTSA ID

11532363

Incident

May 16, 2023

WHEN THE VEHICLE TRAVELS ABOVE 25 MPH, A LOUD WHINING NOISE CAN BE HEARD FROM THE REAR-CENTER OF THE VEHICLE. THE NOISE PROGRESSIVELY INCREASES IN VOLUME AS THE VEHICLE INCREASES ITS SPEED. ONCE THE VEHICLE TRAVELS FAST ENOUGH, OR ENOUGH POWER IS FED THROUGH, POWER OF THE VEHICLE CAN BE AFFECTED. *TR

NHTSA ID

11324360

Incident

Sep 25, 2019

Mileage

91,000 mi

TL* THE CONTACT OWNS A 2009 TOYOTA RAV4. WHILE DRIVING VARIOUS SPEEDS, THE CONTACT HEARD ABNORMAL NOISES COMING FROM THE REAR OF THE VEHICLE. AN INDEPENDENT MECHANIC DIAGNOSED THE VEHICLE AND STATED THAT THE REAR DIFFERENTIAL NEEDED TO BE REPAIRED. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE DEALER WAS NOT CONTACTED. THE FAILURE MILEAGE WAS 112,000.

NHTSA ID

11207845

Incident

May 1, 2019

Mileage

112,000 mi

HAVE A 2009 TOYOTA RAV4. HAD GROWLING NOISE IN REAR IN 2017. HAD REAR DIFFERENTIAL COUPLER SUB ASSEMBLY REPLACED UNDER WARRANTY ENHANCEMENT. NOW 20000 MILES LATER IN NOVEMBER 2018 HAVE GROWLING NOISE AGAIN AND LOCAL TOYOTA DEALER SAYS COUPLER WOULD NEED TO BE REPLACED AGAIN. WARRANTY ENHANCEMENT EXPIRED OCTOBER 2018. TOYOTA WON'T STAND BY NEW PART AND DEALER SAYS WOULD COST ABOUT $1900 INCLUDING LABOR.

NHTSA ID

11160850

Incident

Nov 17, 2018

Mileage

105,000 mi

GROWLING NOISE FROM REAR DIFFERENTIAL WHILE DRIVING. 4 MONTHS PAST ENHANCED WARRANTY PERIOD. RECALL IS NEEDED. UNSAFE TO DRIVE AND VERY EXPENSIVE REPAIR.

NHTSA ID

11099545

Incident

Jun 2, 2018

Mileage

140,000 mi

TL* THE CONTACT OWNS A 2009 TOYOTA RAV4. WHILE DRIVING AT AN UNKNOWN SPEED, THE VEHICLE STALLED AND THE CHECK ENGINE INDICATOR ILLUMINATED BEFORE AND DURING THE FAILURE. THE VEHICLE WAS TOWED TO AUTONATION TOYOTA WINTER PARK (225 N SEMORAN BLVD, WINTER PARK, FL 32792) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED. THE VEHICLE WAS THEN TOWED TO AN INDEPENDENT MECHANIC WHERE THE TRANSMISSION WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED AND INFORMED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN A RECALL OR WARRANTY. THE FAILURE MILEAGE WAS 110,000.

NHTSA ID

11084380

Incident

Apr 9, 2017

Mileage

110,000 mi

MY VEHICLE IS LISTED AS 4 WHEEL DRIVE WHEN DRIVING IN SNOWY CONDITIONS THE CAR WILL KICK OUT OF 4 WHEEL DRIVE IF I REACH 25 MILES AN HOUR. WAS DRIVING IN HEAVY SNOW AND THE CAR WAS CONSTANTLY KICKING OUT AS MY TIRES WERE SLIPPING WHICH WERE NEW TIRES. I WAS THEN DRIVING IN LIGHT SNOW AND HAD TURNED ON THE 4 WHEEL DRIVE AS SOON AS GOT CLOSE TO 25 MPH IT KICKED OUT AGAIN.

NHTSA ID

11054807

Incident

Dec 11, 2016

Mileage

75,000 mi

AT 30-40 MPH THERE IS A NOISE WHICH WHEN TEST DRIVEN BY ME WITH A TOYOTA DEALER DESCRIBED IT AS A SHUTTERING NOISE. I AM SCHEDULED TO BRING MY RV4 FOR ANALYSIS TOMORROW 7/28/17.

NHTSA ID

11011113

Incident

Jul 26, 2017

Mileage

172,000 mi

WHEN CAR IS AT 1500 RPM AT 40 MPH, THE TRANSMISSION VIBRATES AND THRUSTS. NOISE GOES AWAY IF ABOVE 2000 RPM OR ABOVE 40 MPH. IT'S TOYOTA OF MANCHESTER NH HAS BEEN ABLE TO REPRODUCE. WAITING TO SEE IF TOYOTA WILL DO ANYTHING.

NHTSA ID

10895541

Incident

Apr 8, 2016

Mileage

135,547 mi

ON MAY 20, 2015 MY 2009 RAV 4 DEVELOPED A WHINING NOISE IN REAR AREA THAT GOT LOUDER THE FASTER I WENT. VEHICLE HAS 78,385 MILES ON IT AND IS JUST OUT OF WARRANTY. TOOK TO DEALER AND WAS TOLD THAT IT WAS THE VISCOUS COUPLER ASSEMBLY THAT NEEDED TO BE REPLACED AT A COST OF $1,806.75. I MENTIONED THE SERVICE BULLETIN PUT OUT IN 2013 AND THE MULTIPLE POSTS ON THE RAV 4 FORUM ONLINE BUT THEY STILL REFUSE TO COVER THE REPAIR.

NHTSA ID

10722810

Incident

Jun 1, 2015

Mileage

78,385 mi

(NO ACCIDENT) A WHINE STARTED IN THE REAR OF THE CAR THAT GOT PROGRESSIVELY MORE PROMINENT OVER THE COURSE OF A WEEK. MY MECHANIC DISCOVERED THAT THE REAR DIFFERENTIAL COUPLING HUB ASSEMBLY HAS FAILED. ACCORDING TO TOYOTA PARTS MANAGER -- AND MUCH INTERNET 'CHATTER' I LATER DISCOVERED -- THIS IS A WIDE-SPREAD PROBLEM (THEY CAN'T KEEP THE PART IN STOCK) AND THERE HAS BEEN A TSB (0080-13/ SPECIAL POLICY ADJUSTMENT WAB 2190) ISSUED, YET TOYOTA WILL NOT COVER, OR EVEN PARTIALLY COVER, THIS KNOWN DEFECT. IT'S A VERY EXPENSIVE REPAIR, AND WHILE A 2009 ISN'T UNDER WARRANTY ANYMORE, IT'S FAR TOO NEW TO HAVE A PROBLEM LIKE THIS. *TR

NHTSA ID

10714989

Incident

May 6, 2015

Mileage

68,000 mi

TL* THE CONTACT OWNS A 2009 TOYOTA RAV4. WHILE DRIVING AT 55 MPH, THE CONTACT HEARD A NOISE COMING FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE DIFFERENTIAL NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 88,000. UPDATED 7/1/15*CN UPDATED 9/15/2015*JS

NHTSA ID

10713529

Incident

Apr 15, 2015

Mileage

88,000 mi

DIFFERENTIAL GEAR BOX STARTED TO SLOWLY LEAK FLUID JUST OVER 100,000 MILES AND EVENTUALLY THE REAR DIFFERENTIAL CARRIER ASSY HAD TO BE REPLACED. *TR

NHTSA ID

10691411

Incident

Jun 13, 2014

Mileage

100,000 mi

TL* THE CONTACT OWNS A 2009 TOYOTA RAV4. WHILE DRIVING VARIOUS SPEEDS, A LOUD UNKNOWN NOISE EMITTED FROM THE REAR OF THE VEHICLE. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE VISCOUS COUPLING NEEDED TO BE REPLACED. THE REPAIRS WERE MADE AND THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 67,000.

NHTSA ID

10671973

Incident

Dec 26, 2014

Mileage

67,000 mi

THE BRAKE WAS ENGAGED IN TRAFFIC WHEN THE CAR STARTED TO ACCELERATE. I APPLIED THE BRAKE MORE FIRMLY AND PUT THE CAR IN PARK. THE ENGINE BEGAN TO REV UNCONTROLLABLY IN A CLOUD OF WHITE SMOKE. I SWITCHED THE CAR OFF AND RESTARTED THE MOTOR AND IT THEN RAN NORMALLY. *TR

NHTSA ID

10631628

Incident

Sep 8, 2014

Mileage

38,364 mi

I PURCHASED A USED 2009 RAV4 WITH ABOUT 78,000 MILES. IT WAS A ONE OWNER WITH A CLEAN CAR FAX. IT WAS GREAT DURING THE TEST DRIVE. ABOUT 2 DAYS AFTER I PURCHASED IT, IT STARTED TO MAKE A RATTLE/RUMBLE/VIBRATION AT APPROXIMATELY 40MPH AND 1500 - 1800RPM. IT SEEMS LIKE THE NOISE WAS COMING FROM THE TRANSAXLE/TRANSMISSION AREA. THE NOISE PROGRESSIVELY GOT WORSE. IT TYPICALLY HAPPENED WHEN ON AN INCLINE. I TOOK IT INTO A DEALER AND THEY FLASHED THE ECU SINCE THERE WERE MULTIPLE TSBS OUT WITH THIS PROBLEM RELATED THE ECU. THIS HELPED WITH THE PROBLEM FOR A WEEK. THEN THE RUMBLE CAME BACK WITH A VENGEANCE. THE DEALER WORKED ON DIAGNOSING FOR A COUPLE OF DAYS. THE TOYOTA ENGINEERS ON THE TECHNICAL SERVICE LINE HAD THE DEALER'S TECHNICIAN TAKING HEAT SHIELDS, PLASTIC COVERS OFF, ETC THINKING SOMETHING WAS JUST HITTING RESONATE FREQUENCY AND VIBRATING LOUDLY. NOTHING HELPED. EVENTUALLY THE TECHNICIAN USED LISTENING EARS AND ISOLATED THE NOISE TO THE TRANSFER CASE. THE OFFICIAL DIAGNOSIS WAS COMPONENTS IN THE TRANSFER CASE WERE FAILING. I BOUGHT THIS VEHICLE THINKING TOYOTA STILL WERE HIGH QUALITY. I'VE DISCOVERED RAV4S ARE BASICALLY TIN CANS ON WHEELS. IT MAKES AN AMAZING AMOUNT OF CREAKS AND RATTLES. WHEN I SPOKE TO THE TOYOTA CUSTOMER SERVICE REPRESENTATIVE ON THE PHONE I WAS BASICALLY INFORMED TOYOTAS ARE NOW DESIGNED TO GO THE 60,000 MILES (THE MANUFACTURER WARRANTY). AFTER THAT IT'S ANYONE'S GUESS HOW LONG THE MECHANICAL COMPONENTS WILL LAST. *TR

NHTSA ID

10630560

Incident

Jul 7, 2014

Mileage

78,555 mi

TL* THE CONTACT OWNS A 2009 TOYOTA RAV4. THE CONTACT STATED THAT WHEN ATTEMPTING A DOWNWARD TURN, THE VEHICLE SPORADICALLY FAILED TO RESPOND TO ACCELERATION ATTEMPTS. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE FAILURE MILEAGE WAS 500. THE CURRENT MILEAGE WAS 35,000. ..UPDATED 12-30-13 *BF

NHTSA ID

10550382

Incident

Oct 1, 2009

Mileage

500 mi

I WAS COMING TO A STOP AT TRAFFIC LIGHT. AS I SLOWED DOWN WITH MY FOOT ON THE BRAKE THE ENGINE SUDDENLY BEGAN TO SURGE. SINCE MY FOOT WAS ALREADY ON THE BRAKE I WAS ABLE TO PUSH DOWN HARDER ON IT TO STOP IT FROM HITTING THE CAR AHEAD OF ME. WITHIN A SECOND OR TWO, AS THE ENGINE CONTINUED TO SURGE, I SHIFTED THE TRANSMISSION INTO PARK. WHEN I DID THIS THE ENGINE SURGED EVEN MORE. I THEN TURNED OFF THE ENGINE BY TURNING THE KEY WHICH DID SHUT EVERYTHING DOWN. I THEN RESTARTED THE ENGINE AND IT RAN NORMALLY. I WAS SOMEWHAT SHAKEN UP BY THE INCIDENT. NOTE THAT THIS HAD NOTHING TO DO WITH THE FLOOR MATS OR HITTING THE WRONG PEDAL. MY FOOT WAS ON THE BRAKE PEDAL THE WHOLE TIME THE INCIDENT OCCURRED-IF IT HADN'T BEEN I WOULD HAVE CRASHED INTO THE CAR IN FRONT OF ME. *TR

NHTSA ID

10492337

Incident

Jan 12, 2013

Mileage

26,000 mi

WHILE BRAKING (AT ABOUT 5 MPH) TO MAKE A TURN INTO OUR CARPORT, THE VEHICLE BEGAN TO ACCELERATE WITH A RAPID INCREASE IN ENGINE RPMS. IN ORDER TO STOP THE VEHICLE, THE GEAR WAS SHIFTED INTO PARK (TRIED TO SHIFT IT INTO NEUTRAL, BUT ENDED UP IN PARK). CAR RETURNED TO IDLE. IMMEDIATELY CHECK THE FLOOR MAT TO FIND IT WAS NOT A FACTOR. CALLED TOYOTA DEALERSHIP IN THE AREA AND MADE APPOINTMENT FOR FOLLOWING WORK DAY. AFTER 1-1/2 WEEKS AT THE DEALERSHIP, THEY CHECKED THE VEHICLE AND SAID NOTHING WAS FOUND WRONG WITH IT. HE NOTED THAT THE FLOOR MATS WERE AFTER MARKET FLOOR MATS AND NOT RECOMMENDED. I EXPLAINED THAT THIS WAS CHECKED IMMEDIATELY AFTER THE CAR RETURNED TO IDLE AND WAS NOT A FACTOR. HE ASSURED ME THAT EVERYTHING WAS CHECKED AND NOTHING WAS FOUND WRONG WITH THE VEHICLE. *TR

NHTSA ID

10474006

Incident

Aug 17, 2012

Mileage

75,676 mi

MY WIFE WAS PARKING HER 2009 TOYOTA RAV4. AFTER BACKING UP INTO A SPACE SHE PUT THE CAR IN DRIVE AND IT TOOK OFF, CRASHING INTO THE CAR IN FRONT OF HER. MY WIFE WAS PETRIFIED BEING MY DAUGHTER ,WHO IS SIX MONTHS PREGNANT WAS IN THE PASSENGER SEAT. THANK GOD NO ONE WAS HURT. THE OWNER OF THE OTHER CAR WAS MORE CONCERNED ABOUT THE WELL BEING OF MY WIFE AND DAUGHTER THEN THE DAMAGE TO HIS CAR. TO BAD TOYOTA DIDN'T FEEL THE SAME. CALLED TOYOTA FINANCIAL AND REPORTED THE INCIDENT. ASKED TO HAVE CAR TOWED TO THE DEALER AND DID NOT WANT CAR ANYMORE BEING MY WIFE WAS AFRAID TO DRIVE IT , BEING IT WAS AN UNSAFE VEHICLE. THATS WHEN THE FUN STARTED. TALKING TO A RUDE REP. I WAS INFORMED THAT WHETHER I WANTED THE CAR OR NOT I WAS LIABLE FOR THE PAYMENTS IF THE DEALER HAD IT OR NOT. I THEN ASKED HIM IF HE GAVE THE SAME RESPONSE TO THE FAMILY'S OF THE 34 PEOPLE WHO HAVE BEEN KILLED WITH THIS ACCELERATOR PROBLEM OR THE HUNDREDS OF PEOPLE WHO HAVE BEEN INJURED. HIS RESPONSE WAS THAT IF I DID NOT MAKE THE PAYMENTS THEY WOULD SCREW MY CREDIT RATINGS FOR THE NEXT SEVEN YEARS. HUNG UP. CALLED TOYOTA CUSTOMER PROTECTION CENTRER. MORE FUN. WAS TOLD I WOULD HERE FROM A CASE MGR. THE NEXT DAY. WOULD HAVE CAR TOWED TO DEALER AND WOULD BE PROVIDED WITH A LOANER CAR WHILE SAID CAR WAS BEING INSPECTED. 3 DAYS LATER AND 5 PHONE CALLS I WAS ABLE TO GET CASE MGR. NO LOANER CAR WOULD BE PROVIDED, 7 TO 10 DAY BEFORE SOMEONE WOULD CALL TO MAKE AN APPT. TO LOOK AT CAR, AND APPROX. 30 DAYS TO GET RESPONSE. THE TOYOTA HAS BEEN IN THE DRIVEWAY FOR TWO WEEKS PLENTY OF CALLS WHICH ARE ALL DOCUMENTED AND SOME ONE WILL CALL YOU SOON. MADE PAYMENT IN GOOD FAITH. TODAY IS DEC 15., TEN DAYS TILL CHRISTMAS. I CAN SEE THE HOLIDAY EXCUSES COMING. MAYBE I MGHT SEE SOME ONE IN THE NEXT FEW MONTHS, BUT REMEMBER THEY WANT THEIR MONEY. *TR

NHTSA ID

10370808

Incident

Dec 2, 2010

Mileage

5,364 mi

ENGINE ATTEMPTED TO ACCELERATE ON 2009 TOYOTA RAV 4 WHILE STOPPED AT STOPLIGHT BEHIND OTHER VEHICLES. DRIVER, STANDING ON BRAKES, QUICKLY PUT CAR IN NEUTRAL AND THEN PARK AND ENGINE RETURNED TO NORMAL IDLE SPEED. *TR

NHTSA ID

10305774

Incident

Jan 30, 2010

Mileage

6,700 mi