2014 Toyota RAV4 Owner Complaints

Request for Investigation – 2014 Toyota RAV4 Airbag Non-Deployment On [XXX], at approximately [XXX]., the vehicle was involved in a traffic collision in Lakeland, Florida. The vehicle sustained a significant impact to the driver’s-side front area. Despite the nature and location of the collision, the Supplemental Restraint System (SRS) airbags did not deploy. Law enforcement responded to the scene and completed Police Report. Emergency medical services also responded, and the driver was transported from the scene by ambulance due to injuries sustained in the collision. The primary concern is whether the airbag system, including the crash sensors and SRS components, functioned as designed during this crash. Based on the impact, I am seeking an investigation into whether the non-deployment of the airbags was the result of a defect or malfunction. I respectfully request that NHTSA review this incident, document it within its vehicle safety database, and determine whether similar complaints involving 2014 Toyota RAV4 vehicles exist that may indicate a broader safety concern warranting further investigation. Supporting documentation, including photographs of the vehicle damage, the police report, and any other relevant records, can be provided upon request. Thank you for your attention to this important vehicle safety matter. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11754652

Incident

Jul 31, 2026

The contact owns a 2014 Toyota Rav4. While driving at various speeds, the steering wheel became difficult to turn, with several unknown warning lights illuminated. The failure was intermittent. The failure lasted for several seconds before the power steering feature returned, and the vehicle returned to normal operation and the warning lights were no longer illuminated. The vehicle was taken to a dealer, and the contact received an estimate for a diagnostic test. Upon further investigation, the contact discovered NHTSA Campaign Number: 20V373000 (Steering); and associated the failure with the recall; however, the manufacturer confirmed that the VIN was not included in the recall. No additional assistance was provided. The failure mileage was approximately 140,000.

NHTSA ID

11754570

Incident

Jun 1, 2026

Mileage

140,000 mi

I am filing a complaint regarding Toyota’s handling of a known paint defect affecting my 2014 Toyota RAV4 Limited in Blizzard Pearl paint. Over the past several years, the paint on my vehicle has progressively peeled and deteriorated. Approximately 50% of the vehicle’s paint is now damaged. This issue is clearly consistent with Toyota’s known Blizzard Pearl paint defect program. However, I was never notified by Toyota about this defect program through mail, email, or phone call. In addition, I regularly serviced my vehicle at authorized Toyota dealerships during the years the program was active, yet no dealership or Toyota representative informed me that my vehicle qualified for repair coverage. I only recently learned about the existence of this program after visiting a Toyota dealership regarding another issue. At that time, I was told the program had already expired in April 2024 and that Toyota would no longer provide assistance. I believe this is unfair because: - Toyota acknowledged this as a manufacturing-related defect. - I was never properly notified. - Toyota dealerships had multiple opportunities to inform me during regular service visits. - The defect became progressively worse over time. I am requesting that Toyota reconsider my case and provide goodwill assistance or repair coverage despite the expiration date, due to the lack of notification and the severity of the defect. Toyota Brand Engagement Center still told me the recall expiated.

NHTSA ID

11737937

Incident

May 5, 2026

My vehicle's factory applied paint which is Blizzard Pear 070 is failing and peeling on entire vehicle in multiple areas including roof, hood, interior doors, side panels, and rear door. This started as chipping back in 2019 and then peeling around late 2019 and has progressively gotten worse with even being garaged. This is a know issue acknowledge by Toyota customer support program that has since expired. The paint is delaminating down to the primer with bare metal exposed. Yes it is available for inspection and actually had my local Toyota dealer who I purchased from take pictures last month and tell me the peeling paint is from the know manufacture defect. This is a could pose a safety risk as peeling paint can detach while driving and and also the exposed metal is susceptible to corrosion which could lend to body panels deterioration over time. Toyato manufacturer was contacted and I was told the customer support warranty is expired. Although Toyato said they sent out recall noticed I never received them. Back in 2019 I approached the dealership service dept with issue but they didn't document it and at the time told me it was general wear and tear. Now Toyato manufacturer is not standing behind it. They dealership also told me there are many others having the same issue when I took my car in to get assessed. If there are this many people Toyato should stand behind the paint defect and extend the opportunity for it to be fixed.

NHTSA ID

11735636

Incident

May 4, 2019

UPDATE TO PRIOR COMPLAINT — Filed April 2, 2026. VIN: [XXX] . 2014 Toyota RAV4 AWD XLE. Team Toyota Langhorne, 746 E Lincoln Hwy, Langhorne PA 19047. Vehicle remains out of service — 53 days as of April 10, 2026. SECOND REPLACEMENT VEHICLE — April 4-5, 2026: Dealership presented 2014 RAV4 VIN [XXX] as replacement. Upon visual inspection: valve cover leaking; blue silicone sealant on valve cover applied unevenly indicating prior engine disassembly or concealed active oil leak; catalytic converter flanges rotted top to rear requiring full replacement; oil on bottom of motor. Photographs available. Dealership declined to repair at estimated cost of $2,500 — April 6, 2026. DEALER RESOLUTION FAILED — April 7, 2026: Bill Sullivan, Pre-Owned Sales Director, offered buyback or trade. Both rejected as inadequate. No resolution provided. Two defective replacement vehicles presented — neither acceptable. Cases: [XXX] / [XXX] / [XXX] [XXX] — [XXX] — [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11730513

Incident

Jun 11, 2025

2014 Toyota RAV4 AWD XLE purchased June 2025. Multiple pre-existing safety defects confirmed by dealership personnel were never disclosed at time of sale. POWER TRAIN: Torque converter failure — vibration documented at pre-sale inspection, never disclosed or diagnosed. Axle bracket corroded so severely it was fused to axle and required cutting off — confirmed by service advisor on recorded call. BRAKES: Aftermarket brake parts installed pre-sale without disclosure. Brake system rated RED by dealership within 9,734 miles of purchase. Severe brake pedal pulsation confirmed on multiple invoices. ODY/STRUCTURE: Severe underbody and structural corrosion — subframe, crossmembers, fuel tank surfaces — never disclosed. Swollen lug nuts documented. Prior welded exhaust repair undisclosed. Exhaust flange separation and catalytic converter failure — repair quote $4,745. SEAT BELT: Rock found lodged in seat belt buckle — safety restraint failure — not noted on pre-sale inspection. RECALL 23V734000 / 23TA13: Aftermarket battery used as recall remedy — OEM replacement required — non-compliant — fire risk not disclosed at sale. All defects confirmed by dealership invoices, MPI video, and recorded calls. Vehicle out of service since February 2026. Complete documentation available.

NHTSA ID

11728692

Incident

Feb 17, 2026

I was in a car accident and the side and steering airbags deployed. While the main steering airbag deflated successfully following the accident, the driver's side door side airbag never deflated. Once I was trying to get out of the car and had the door open, this meant it was much harder and took longer to get out as I had to slide out from underneath it. Because I wasn't able to get out quickly, I remained in a car in direct line of traffic with my driver's side door where it would have been hit first putting me in more danger.

NHTSA ID

11721674

Incident

Mar 3, 2026

All four of my door lock actuators are not working properly. All four usually don’t work, however once in a great while they will actually lock or unlock. This is a big safety issue because when I think they lock, they don’t. When I drive at night with my daughter in the backseat I do not feel safe. I always have to check all 4 doors a couple times, because sometimes they will unlock but not lock. Also note that they do not work all at the same time. It always varies by the day. I was going to pay for them to be fixed myself, but it was too costly.

NHTSA ID

11721326

Incident

Apr 1, 2024

The contact owns a 2014 Toyota Rav4. The contact stated that while driving approximately 20 MPH and turning right at an intersection, the steering wheel seized with several unknown warning lights illuminated. The contact completed the turn, and the steering wheel started functioning normally, and the warning lights were no longer illuminated. The failure reoccurred while making a right turn. The vehicle was taken to an independent mechanic, and the contact was referred to the dealer for assistance. The dealer was contacted and confirmed that the VIN was not under recall related to the failure. The vehicle was not repaired. The contact had stopped driving the vehicle. After researching online, the contact associated the failure with NHTSA Campaign Number: 20V373000 (Steering): however, the VIN was not included. The manufacturer was not informed of the failure. The failure mileage was approximately 200,000.

NHTSA ID

11719827

Incident

Feb 19, 2026

Mileage

200,000 mi

BATTERY DIED MID-DRIVE NOW THE RADIO HEAD UNIT IS IN A BOOT LOOP RENDERING ALL FUNCTIONS UNAVAILABLE.

NHTSA ID

11711594

Incident

Jan 31, 2025

The contact owns a 2014 Toyota Rav4. The contact’s son stated that while attempting to start the vehicle, the vehicle failed to start and became inoperable, and lost power. There was no warning light illuminated. The vehicle was towed to an independent mechanic, where it was diagnosed that the engine had failed and needed to be replaced. The vehicle was not repaired. The dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 200,000.

NHTSA ID

11699219

Incident

Nov 13, 2025

Mileage

200,000 mi

1) Vehicle had a recall for something concerning the transmission. Service was done and just after the warranty expired on that issue the transmission went out while driving and I had to put a new one in the vehicle, Toyota did help with $1500 of the cost but it cost me out of pocket over $4000. 2) For the last 2 years the car has been burning oil excessively, I have to put a quart of oil in almost every week. Now the vehicle out of the blue will start shaking and all the warning lights come on and I have to be able to pull over. I no longer can drive on the highway in fear this could happen. I am now being told I need a new or rebuild engine. I seen online that others have had this problem and there was a Class Action Law suit several years ago. What are the chances a Toyota Rav4 would need a transmission and now a engine.

NHTSA ID

11699167

Incident

Dec 31, 1969

Headlight Brightness - it's been degrading for the last 10 yrs to the point that I don't feel safe driving in the dark anymore. I've already had the lenses buffed out, but that only helped about 20%. The brightness looks like I have a dead battery (it's brand new). Not sure if this is a bulb or lens issue but it's not safe.

NHTSA ID

11697142

Incident

Jan 1, 2018

The contact owns a 2014 Toyota Rav4. The contact stated that during a rainstorm, rainwater leaked into the cabin of the vehicle from the A, B, C, and D pillars and the ceiling control center. The contact stated that the vehicle was serviced several times due to the failure, but the failure reoccurred. Additionally, the rear passenger side carpet was previously replaced due to excessive water entering the vehicle. The contact was concerned that the leaks were near the curtain air bag housing and might cause the air bags to malfunction. The manufacturer was notified of the failure, but no assistance was provided. The vehicle was not yet repaired. The failure mileage was 100,000.

NHTSA ID

11691031

Incident

Dec 1, 2018

Mileage

100,000 mi

Lift gate struts quit working.The lift gate is no longer is accessible or responsive to the proximity key commands to open or close, even after changing proximity key batteries. You cannot open the lift gate by hand because of the resistance of the hydrolics of the struts. I have complained to Toyota, and the dealership where it was purchased. Both said they would contact me if there was a recall and suggested I file a complaint, which I am doing now. The is a huge inconvenience when grocery shopping, or traveling to spot events, or trying to get the dog to the vet. Luckily I don't use a wheelchair yet. I'm very late in filing this complaint, as the liftgate failure took place in April of 2021. I cannot afford to get them replaced on my limited income. I'm just looking for a little help.

NHTSA ID

11691021

Incident

Apr 8, 2021

Year: 2014 Make: Toyota Model: RAV4 Approx. mileage: 60K 2. Incident Details Date of most recent incident: [XXX] Problem: Vehicle stalls and loses power steering while turning. Engine shuts off suddenly, causing complete loss of steering control. Consequence: On [XXX], my son lost control of the RAV4, hit a curb, and went through bushes before stopping. Previous stalls also occurred while turning, with loss of steering assist. This is a severe safety hazard. Frequency: Has occurred multiple times, even after dealership inspection and repairs. 3. Dealer/Repair Info Dealer name: Sarasota Toyota Address: 7435 S Tamiami Trail, Sarasota, FL 34231 Repair attempts: Dealer inspected in August 2025, charged nearly $900, but problem persists. Car is now back in the shop (not Toyota) for a second opinion at an additional cost of over $200. 4. Description My 2014 Toyota RAV4 repeatedly stalls and loses engine power and power steering without warning, especially while turning. On [XXX], my son lost control of the vehicle, hit a curb, and went through bushes before managing to stop. This is extremely dangerous and could have resulted in a serious accident. Sarasota Toyota has inspected the vehicle and charged nearly $900 for repairs, but the defect was not fixed. The vehicle continues to stall and is unsafe to drive. I am pursuing a second opinion at additional expense. This issue places my family and others on the road in danger. I am filing this complaint so that Toyota and regulators address this defect. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11688355

Incident

Sep 19, 2025

The contact owns a 2014 Toyota Rav4. The contact stated that the power steering assist intermittently failed to operate as needed, with the maintenance warning light displayed on the instrument panel. The vehicle was taken to an independent mechanic and a dealer however, there were no fault codes retrieved. The contact stated that while making a left turn onto a side road, the steering wheel seized, and excessive force was needed to steer the vehicle. The vehicle was taken back to the independent mechanic, where the contact was informed that the vehicle would reset itself. The failure intermittently persisted, and the vehicle was taken back to the dealer where the vehicle was diagnosed with a defective steering column. Upon investigation, the contact linked the failure to NHTSA Campaign Number: 15V144000 (Steering); however, the vehicle was not included in the recall. The manufacturer was notified of the failure, and the contact was provided a case number. The vehicle was not repaired. The failure mileage was approximately 118,000.

NHTSA ID

11686288

Incident

Jul 13, 2025

Mileage

118,000 mi

The contact owned a 2014 Toyota RAV4. The contact stated that while driving at 30-40 MPH, while depressing the accelerator pedal, the vehicle stopped independently. No warning lights illuminated. The contact mentioned she noticed smoke and flames coming from the engine, and smoke started coming inside the vehicle. There was a fuel odor. present. The contact exited the vehicle and stood on the side of the road, and called 911. No injuries were sustained. No medical attention was required. A police report was filed. The fire department extinguished the fire. The vehicle was destroyed. The vehicle was towed to an unknown location. The vehicle was not repaired. The contact mentioned days prior to the battery warning light illuminating, and the battery was determined to be functioning as normal; therefore, the vehicle was resumed to be driven as normal. The manufacturer was not notified of the failure. The failure mileage was unknown

NHTSA ID

11684519

Incident

Aug 29, 2025

The contact owns a 2014 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (ELECTRICAL SYSTEM). The dealer was contacted; however, the contact was informed that parts were not yet available for the recall repair. The vehicle was not repaired. The manufacturer was not contacted. The contact stated that while driving 20 MPH, and making a right turn, the vehicle lost motive power. There was no warning light illuminated. The vehicle was towed to the local dealer. The approximate failure mileage was 170,000.

NHTSA ID

11681310

Incident

Jul 23, 2025

Mileage

170,000 mi

The electric power steering has malfunctioned. The malfunction of the EPS may cause the car to jerk or swerve. The dealership has said they have seen countless problems with the EPS. There is a recall on the EPS in the 2014 Rav4, however this vehicle did not fall under the previous recall. No warning lamps or messages appear for this particular issue with the vehicle. The vehicle is available for inspection. The dealership has quoted $3014.00 for the repair. Steering column assembly replacement and EPS motor replacement.

NHTSA ID

11672933

Incident

Jul 1, 2025

“The factory paint on my 2014 Toyota RAV4 (Blue ) is peeling in large sections on the roof and hood. The metal underneath is exposed. This appears to be a widespread issue affecting this paint color, and Toyota has acknowledged it in other models. I’m concerned about corrosion and long-term durability.”

NHTSA ID

11666831

Incident

Mar 1, 2025

The contact owns a 2014 Toyota Rav4. The contact received notification of NHTSA Campaign Number: 23V734000 (Electrical System); however, the part to do the recall repair was not yet available. The local dealer was contacted. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The manufacturer was made aware of the issue. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11654404

Incident

Apr 14, 2025

My 2014 Toyota RAV4 (Blizzard Pearl, paint code 070) began experiencing hood paint peeling in early 2023. I first assumed it was simply a disappointing paint quality issue. However, this past weekend, the problem significantly worsened when large sections of paint on the roof suddenly flaked off completely, leaving exposed metal vulnerable to rust and corrosion. After this severe flaking occurred, I researched the issue online and discovered this problem is widespread among Toyota's with paint code 070. Toyota acknowledged this known manufacturing defect through their Customer Support Program (ZKG), but I was never notified of this program, despite receiving other recall notices. Additionally, my local Toyota dealership did not inform me about ZKG during a service visit before the program expired in 2024. On March 28th, 2025, I called Toyota’s customer service line to request goodwill assistance and was informed that they are not willing to offer any support or extend the program. I was told that the only thing they could do was “document” my case, and that if enough complaints were received, Toyota might reconsider extending the program in the future. I believe this response is quite unreasonable, especially given that this is a clear manufacturing defect now manifesting in catastrophic failure for many customers shortly after the 10-year ZKG window closed. The cost of a full repaint is commonly quoted around $4,000 to $5,000. For many RAV 4's currently valued at approximately $10,000, that repair cost represents nearly 50% of the car’s value—essentially totaling the vehicle due to a known paint defect. It’s an extreme hardship for customers that a widely acknowledged exterior manufacturing issue can result in such significant devaluation and repair costs. For this to happen to so many people just outside the expiration window (which only ended recently in 2024), and for Toyota to decline any extension or support, does not seem fair. Thank you for your time.

NHTSA ID

11651340

Incident

Mar 22, 2025

I received a recall letter from Toyota to replace me battery in my 2014 RAV4. I made an appointment with Toyota on 31 in Clinton, NJ for 1/28/2025 at 9:30am. Upon bringing in my car for the recall I was told it will cost me $189.00+tax to replace my battery. The reason was because there is another battery in my car. I advised them that I bought the car second hand and had no reason to check my car's battery at that time. (who knew). In the letter of recall it states that the battery change is "the hold down clamps and short circuit, increasing the risk of fire." With that stated, changing my battery is the benefit to securing safety to me and my passengers. Isn't that the main reason for the recall! Safety by Toyota without Charge!

NHTSA ID

11643922

Incident

Feb 2, 2025

In reference to Toyota Motor North America - Customer Support Program ZKG. My Toyota vehicle has experienced paint peeling on the exterior metal body panels. I have applied to receive coverage from Toyota for the paint peeling as part of the ZKG Program. Toyota has denied my request for coverage and did not provide me with notice of the ZKG Program. The paint color of my vehicle is the original factory applied Blizzard Pearl (070) paint color. The vehicle experienced noticeable paint peeling around 9.5-10 years from the Date of First Use of the vehicle. I reported the paint peeling to my local Toyota dealer service center around 5 months after the car was ten years past the Date of First Use. Because the ZKG program coverage had expired by the time I had reported the paint peeling, the Toyota dealer service center referred me to the Toyota Brand Engagement Center. The Toyota Brand Engagement Center denied my request for coverage because the vehicle was reported shortly after the Duration of Coverage. I did not receive notice of the Customer Support Program ZKG from Toyota. I became the owner of this vehicle three years before that the program notification was sent out, but the Toyota Brand Engagement Center representative and a Resolution Specialist both indicated that notices were sent to the previous owner. I purchased the vehicle directly from a Toyota dealership using Toyota financing. The paint peeling did not start until very close to time of coverage expiration for my vehicle. I was unaware that I would be required to report the paint peeling issue to Toyota by a certain date as I was never made aware of the Customer Support Program ZKG from Toyota.

NHTSA ID

11640949

Incident

Mar 1, 2024