1994 Toyota T100 Owner Complaints

VEHICLE WOULD NOT START. SHIFT LEVER IN FIRST GEAR, CLUTCH PEDAL FULLY DEPRESSED AND CLUTCH BYPASS SWITCH ENGAGED. VEHICLE LURCHED FORWARD APPROXIMATELY ONE FOOT WHILE TURNING KEY NEARLY RAMMING INTO THE SIDE OF ANOTHER VEHICLE PARKED DIRECTLY IN FRONT OF DISABLED VEHICLE. VISUAL INSPECTION OF CLUTCH PEDAL SUPPORT ASSEMBLY, TOYOTA P/N 107-34010, REVEALED TWO METAL FATIGUE CRACKS IN THE SUPPORT, ONE APPROXIMATELY ONE AND ONE HALF INCHES LONG AND THE OTHER APPROXIMATELY ONE HALF AN INCH LONG IN THE HEAT ZONE OF ONE SPOT WELDED AREA. THE LARGER OF THESE TWO CRACKS ALLOWS THE FIREWALL PORTION OF THE BRACKET TO MOVE IN (FLEX) TOWARDS THE FIREWALL WHEN THE CLUTCH PEDAL IS FULLY DEPRESSED PREVENTING THE CLUTCH MASTER CYLINDER PUSH ROD FROM FULLY DISENGAGING THE CLUTCH. THE CLUTCH MASTER CYLINDER PUSH ROD HAS BEEN ADJUSTED (LENGHTEDED) AS MUCH AS POSSIBLE AND ADDITIONAL ADJUSTMENT WILL NOT FIX THE PROBLEM. A PHOTOGRAPH OF THE CRACKED BRACKET IS AVAILABLE, IF DESIRED. THANK YOU! *TR

NHTSA ID

10619467

Incident

Aug 5, 2014

Mileage

131,171 mi

TL* THE CONTACT OWNS A 1994 TOYOTA T100. THE CONTACT STATED THAT WHILE IN REVERSE, THE FRONT DRIVER SIDE TIRE SUDDENLY DISCONNECTED FROM THE FRAME. THE CONTACT WAS UNABLE TO STEER THE VEHICLE. THE CONTACT HAD THE VEHICLE TOWED TO A LOCAL MECHANIC WHERE THE MECHANIC NOTICED EXTENSIVE RUST ON THE FRAME. THE MECHANIC ADVISED THE CONTACT THAT THE VEHICLE WAS NOT REPAIRABLE. THE CONTACT CALLED THE MANUFACTURER REGARDING THE FRAME RUST AND THE MANUFACTURER ADVISED THAT THERE WAS NOTHING THEY COULD DO TO ASSIST. THE FAILURE MILEAGE WAS 120,000. UPDATED 05/09/12*LJ

NHTSA ID

10449682

Incident

Jul 13, 2011

Mileage

120,000 mi

TOYOTA REFUSES TO ACCEPT OUR COMPLAINT ABOUT OUR 1994 TOYOTA T-100. TOYOTA REFUSES TO ACKNOWLEDGE 05V389000 AS A VALID SOURCE FOR A COMPLAINT. TOYOTA STATES THAT THERE IS NO RECALL FOR OUR VEHICLE. WE NEVER RECEIVED ANY NOTICE FROM TOYOTA OF A RECALL. *TR

NHTSA ID

10263654

Incident

Jan 2, 2009

Mileage

70,000 mi

DT*: THE CONTACT STATED WHILE DRIVING 30 MPH ON NORMAL ROAD CONDITIONS, THE VEHICLE RODE ROUGH AND AT ONE POINT, OVERHEATED AND BLEW A HEAD GASKET. THE VEHICLE WAS TAKEN TO THE NEAREST INDEPENDENT MECHANIC SHOP, WHO DETERMINED THE HEAD GASKET WAS DEFECTIVE AND CAUSED SEVERE ENGINE DAMAGE. NO REPAIRS WERE MADE. THE MANUFACTURER WAS CONTACTED, AND DETERMINED THAT THE RECALL ON THIS ISSUE HAD EXPIRED IN 2004.

NHTSA ID

10174394

Incident

Nov 20, 2006

Mileage

106,000 mi

DT*: THE CONTACT STATED WHILE TURNING LEFT AT 5MPH THE VEHICLE IS DIFFICULT TO STEER. UPON INSPECTION THE CONTACT DETERMINED THERE IS A CRACK IN THE STEERING RELAY ROD. THERE IS A NHTSA RECALL, # 05V389000, REGARDING THE STEERING RELAY ROD. THE VEHICLE HAS THE SAME PROBLEMS AS INDICATED IN THE RECALL; HOWEVER IT IS NOT INCLUDED IN THE RECALL DUE TO THE VIN.

NHTSA ID

10153937

Incident

Mar 28, 2006

Mileage

156,000 mi

I AM HAVING A PROBLEM WITH A DEFECT WITH THE CLUTCH AND ASSEMBLE NO LONGER BEING ATTACHED TO THE VEHICLE. I LOST USE WHEN I WAS DRIVING DUE TO THEM NO LONGER BEING ATTACHED AT THE WELDS AND WALLS! THIS WAS NOT FUNNY AND DANGEROUS. NOT BEING ABLE TO SHIFT AND NO LONGER ABLE TO START THE TRUCK. THE PEDAL WON'T EVEN TOUCH THE BUTTON TO ENGAGE THE TRUCK TO START. THE PEDAL LEADS TO THE ASSEMBLY INSIDE THE TRUCK THAT IS NOT ATTACHED ANY LONGER.

NHTSA ID

10007704

Incident

Feb 9, 2003

CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEMS WITH THE ANTIFREEZE IS LEAKING INTO THE ENGINE BLOCK AND THEN IS BEEN PASS INTO THE EXHAUST SYSTEM WHICH CONSUMER THINKS IS BURNING IT AND PASSING A WHITE SMOKE THAT GOES IN TO HIS HOUSE AND GIVING HIM SEVERE HEADACHES. DEALER WAS CONTACTED AND STATED THAT WILL ONLY GIVE HIM A CERTAIN AMOUNT OF MONEY AND NOT BE RESPONSIBLE OF ANYTHING ELSE IF THERE IS ANYTHING ELSE WRONG WITH THE VEHICLE. TS

NHTSA ID

8022192

TIRE WALL FAILED CASTASTROPHICALLY ENTIRE WALL LET GO. DID NOT HIT ANYTHING, TIRE PRESSURE MAINTAINED AT 35 PSI CHECHED UNDAMAGED TIRES AFTER INCIDENT ALL AT 35 PSI WITH TWO DIFFERENT TIRE GAUGES. TOOK TIRE TO DEALER (SAM'S) TREAD REMAINING 6/32 OR ORGINIAL 14/32. DEALER WILL REFUND ON 33% OF ORGINIAL COST BUT MICHENLIN DEMANDS DAMAGED TIRE BE RETURNED IN? CONCERNED BECAUSE I RECOMMENDED THESE TIRES AS REPLACEMENTS FOR MY DAUGHTERS 2000 FORD EXPLORER . CALLED MICHENLIN AND GOT NO INDICATION OF ANY CONCERN ABOUT THE INCIDENT OR DESIRE TO LEARN WHY TIRE FAILED.*AK

NHTSA ID

763520

Incident

Jun 25, 2002

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

NHTSA ID

763042

Incident

Jul 1, 1998

PLASTIC RETRACTOR STICKS OUT OF DOOR.*AK

NHTSA ID

8008247

Incident

Mar 15, 1997

WHEN SITTING IN VEHICLE WHILE IT WAS IN IDLE AIR BAGS DEPLOYED WITHOUT ANY NOTICE. PLEASE PROVIDE MORE INFORMATION.*AK

NHTSA ID

899489

Incident

Sep 15, 2001

THE VEHICLE WAS RECALLED DUE TO FAULTY HEAD GASKETS, HAD THEM REPLACED BY DEALER IN 1998 AND AT THAT TIME THE DEALER STATED TOYOTA KNEW THERE WAS A PROBLEM WITH ENGINE. THE HEAD GASKET HAS AGAIN "BLOWN" AND I HAD TO PAY FOR THIS SECOND REPAIR FROM MY OWN POCKET. I WANT TO KNOW WHY TOYOTA, KNOWING THE PROBLEM WITH THE ENGINE, WON'T REPAIR IT A SECOND TIME...OR IF THEY WILL REIMBURSE ME THE MONEY I HAD TO PUT OUT (1,300 DOLLARS) FOR REPAIRS AND CAR RENTAL.*AK

NHTSA ID

751804

AFTER PARKING VEHICLE NOTICED LOTS OF FULE LEAKS. DEALER HAS BEEN CONTACTED. DEALER STATED STATED THAT FUEL TANK NEEDED TO BE REPLACED. PLEASE PROVIDE FURTHER INFORMATION. *AK

NHTSA ID

861960

HAD PARKED & LEFT VEHICLE. RETURN & STARTED VEHICLE. THE AIR BAG LIGHT CAME ON. AFTER ARRIVING HOME, AIR BAG LIGHT WAS STILL ON. TOOK VEHICLE TO DEALER & INFORMED THE SENSORS WERE GONE & WAS NOT COVERED UNDER WARRANTY. *AK

NHTSA ID

836504

Incident

Feb 1, 1999

HEAD GASKET WAS REPLACED BY DEALER AT NO COST,BUT I ALSO NEEDED TO REPALCE THE TIMING BELT ACCORDING TO THE DEALER. THE DRIVE TRAIN HAS A WARRANTY FOR 60,000 MILES,AND I PURCHASED AN EXTENDED WARRANTY FOR SIX YEARS OR 100,000 MILES. YOU WOULD THINK THE TIMING BELT SHOULD BE REPLACED AT NO CHARGE WITH A TRUCK WITH SUCH LOW MILEAGE. MY EXTRA WARRANTY WAS USELESS IN THIS MATTER ACCORDING TO THE DEALER. IF I DIDN'T HAVE IT FIXED THEY WOULD SAY I DIDN'T DO PROPER MAINTANCE TO THE TRUCK MAKING MY WARRANTY VOID.I WAS IN A CATCH 22 SITUATION. IFEEL THE DEALER OR TOYOTA SHOULD REFUND MY $185 FOR INSTALLING THE TIMING BELT.

NHTSA ID

701145

Incident

Nov 27, 1998

FADED PAINT.

NHTSA ID

538671

NO DEPLOYMENT OF AIR BAGS. *SD

NHTSA ID

501524

Incident

Dec 7, 1995

AXLES FAILED. *SD

NHTSA ID

490775

Incident

Aug 24, 1994