2016 Toyota Tacoma Driver assistance Problems

I brought my truck into Miller Toyota of Anaheim due to a violent shuddering and acceleration at about 40 to 50 mph. This could have caused driver to lose control and injure themselves, passengers, and other drivers on the road. Dealership diagnosed the problem as a bad torque converter in the transmission and said it would cost about $3200.00 to repair. Couldn't afford that so I took vehicle to an independent repair shop and they notified me that there was a Toyota Service Bulletin that addressed this concern and that they would have to do a complete reprogramming update of Transmission Control Module. I haven't had any issues since this was done but the dealership should have been aware of this problem which could be potentially fatal. There were no warning lamps, messages or other symptoms prior to this failure or during the failure.

NHTSA ID

11465484

Incident

Apr 21, 2022

On 11-27-2021 I lost all power while on a highway. I would lose power even with my foot all the way down the rpm would not rise at all. The power would come back adruptly and throw me back into my seat. The trac off and check engine light came on. My truck seemed like it was gonna stall and had a really low and rough idle. It was only about 0-500 rpm at idle and truck was shaking bad because of the engine. After getting towed home I tested the battery and alternator and those were fine. I believe it is the crankshaft position sensor. I have read that this has happened to man other people with the same truck as mine. There was a recall for the cps but for some reason my truck was not included.

NHTSA ID

11441971

Incident

Nov 27, 2021

WAS TOLD BY THE MECHANIC THAT THERE WAS A BULLETIN TO REPLACE IF AN ISSUE BEFORE THE 3 YEARS 36,000 MILES. HAVE HAD THE TRUCK FOR 4.5 YEARS AND NOW THE BSM LEFT SIDE NEEDS TO BE REPLACED. ONLY HAVE 26,567 MILES ON THE TRUCK! IF THEY HAD AN ISSUE, WHY AREN'T THEY REPLACING THEM IF THE ISSUES HAPPEN WITHIN THE 36,000.

NHTSA ID

11387119

Incident

Dec 16, 2020

Mileage

3 mi

TRANSMISSION SLIPS WHEN SHIFTED FROM PARK TO DRIVE OR REVERSE TO DRIVE. HAS A 1-3 SECOND DELAY. IN ADDITION THIS SLIP MOTION CREATED A LOUD GEAR CRANKING NOISE AS I TRIED TO ACCELERATE ON A U-TURN. THE TRUCK DID NOT MOVE OR SHIFT DESPITE HEARING THE ENGINE ACCELERATE ACCOMPANIED BY THE METALLIC GEAR-LIKE GRIND SOUND. SOUND VERY SIMILAR TO A STICK CAR WHEN YOU TRY TO ENGAGE A SHIFT WITHOUT THE CLUTCH (BUT MY TRUCK IS 2016 AUTOMATIC TRD-SPORT). LASTLY, WHEN TAKING SPEED BUMPS OR HARD SHIFTING MOTION (UP-DOWN) YOU CAN HEAR THE SUSPENSIONS MAKE A LOUD CLANK NOISE AS THE TRUCK SHIFTS IN THE SPEED BUMP MOTION.

NHTSA ID

11311986

Incident

Feb 27, 2020

Mileage

59,900 mi

CAR HESITATES WHEN NEEDING TO ACCELERATE RAPIDLY. WHILE SLOWING DOWN THE CAR FEELS LIKE IT IS PUSHING ,NOT DOWN SHIFTING FAST ENOUGH. THE DIFFERENTIAL BANG AT TIME WHEN COMING TO A STOP, IT SEEMS LIKE IT IS NOT DISENGAGING. I THINK THERE IS A PROGRAMMING ISSUE THAT TOYOTA IS NOT ADMITTING TO. I ALSO HEARD THAT THERE IS A BLOWER ISSUE. THE TRANSMISSION DISENGAGES AT DIFFERENT SPEEDS WHEN YOU GO TO ACCELERATE THEN DON'T AND THEN DO. CAR GOES INTO NEURTAL HUNTING FOR A GEAR

NHTSA ID

11301459

Incident

Mar 2, 2016

Mileage

40,400 mi

DRIVING ON THE INTERSTATE 70 MPH, ENGINE QUITS. 2 DASH LIGHTS COME ON TRUCK MAXES OUT AT 40MPH OUT OF NOWHERE. PULLED OVER SHUT TRUCK OFF AND STARTED IT UP NO RAN FINE NOTE: CHECK ENG LIGHT IS NOW ON. BAD GAS DIAGNOSIS. GAS REPLACED HAPPENS 1 MORE TIME. DIAGNOSED WITH BAD FUEL INJECTORS NOT COVERED UNDER EXTENDED WARRANTY, CAUSE WAS BAD GAS. THE LOSS OF POWER HAPPENED 2 OTHER TIMES.

NHTSA ID

11230835

Incident

Jul 4, 2019

Mileage

67,000 mi

MY WIFE AND I DROVE FROM AUSTIN TEXAS TO ARKADELPHI ARKANSAS DUE TO ME GETTING OUT OF THE ARMY'ACTIVE' AND MY TRUCK HAD BEEN SLOWLY STUDDERJNG, SPITTING ETC.. WELL IT IS STALLED AT A PARKING LOT FOR A WEEK NOW.. THERE IS A RECALL FOR THE 'CRANKSHAFT POSITION SENSOR' FOR MY EXACT MODE AND TOYOTA WILL NOT HONOR MY TRUCK FOR IT AND THAT'S THE CODE IT'S READING ETC..

NHTSA ID

11157209

Incident

Nov 30, 2018

Mileage

73,000 mi

MY BSM SENSORS WERE BLINKING AND A NOTICE CAME UP ON THE CONSOLE TO CHECK BSM INDICATORS. I MANUALLY TURNED OFF THIS FUNCTION AND BACK ON---THE LIGHT WAS BLINKING AND THE BSM SENSORS WERE STILL NOT WORKING CORRECTLY. WHEN I BROUGHT IT IN THE DEALERSHIP TODAY THEY DID SOME TESTS AND LOOKED AT IT AND SAID THEY NEEDED TO REPLACE THE BSM WIRE HARNESS BECAUSE OF WATER DAMAGE GETTING INTO THE REAR BUMPER. THE ESTIMATE WAS FOR 1,0588.49 FOR REPARE. I THINK IF TOYOTA IS SELLING BLIND SPOT MONITORS AS A SAFETY FEATURE, THEY SHOULD LAST MORE THAN 2 YEARS AND NEEDS TO BE RECALLED. THIS IS AN OFF ROAD VEHICLE? THIS SEEMS LIKE A COMMON PROBLEM AFTER RESEARCHING IT ONLINE AND IT'S A SAFETY HAZARD, NOT TO MENTION THE VEHICLE IS ONLY 2 YEARS OLD.

NHTSA ID

11156655

Incident

Nov 21, 2018

Mileage

45,000 mi

MY CAR 2016 TOYOTA TACOMA HAS REBUILT TITLE AND VOIDS THE POWER TRAIN WARRANTY. TOYOTA CORP HAS TSB 0077-16 SHIFT FEELING ENHANCEMENTS FOR THE TRANSMISSION DUE TO: DELAYED ENGAGEMENT PARK TO DRIVE OR REVERSE TO DRIVE. HARSH 1ST - 2ND UPSHIFT. DELAYED UPSHIFT WHEN USING CRUISE CONTROL. I EXPERIENCE HARSH UP SHIFT AND DOWNSHIFT IN THE TRANSMISSION WHILE DRIVING. IT NEEDS SIMPLE SOFTWARE UPDATE, BUT THE TOYOTA COP DECLINED THIS UPDATE FOR MY VEHICLE (CASE# 1808271028 ON 08/28/2018) IF THE PROBLEM PERSISTS IT MAY MAKE TRANSMISSION UNCONTROLLABLE ORE DELAYED AND VEHICLE MAY GET INTO THE ACCIDENT. WE HAVE ONE SCHOOLED BOY AND INFANT GIRL. I WANT TO INFORM ABOUT THE ISSUE SO THAT ALL VEHICLES WITH THE SAME PROBLEM AND BRANDED TITLES ARE TO BE CORRECTED BY TOYOTA CORP AT NO EXPENSE TO THE OWNERS. I WILL ATTACH THE TSB TOYOTA DOCUMENT THAT EXPLAINS WHAT IS THE PROBLEM

NHTSA ID

11123596

Incident

Aug 28, 2018

TL* THE CONTACT OWNS A 2016 TOYOTA TACOMA. THE CONTACT STATED THE VEHICLE EXPERIENCED HESITATION AND THE ENGINE DE-POWERING. THE FAILURE OCCURRED WITHOUT WARNING. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT ONCE THE ACCELERATOR PEDAL WAS DEPRESSED BEFORE THE VEHICLE RECOGNIZED THE SPEED THE SOFTWARE CAUSED THE ENGINE TO DE-POWER FOR INTERVALS OF ONE TO TWO SECONDS BEFORE THE VEHICLE WOULD OPERATE NORMALLY. A REMEDY WAS NOT DISCLOSED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 10,005.

NHTSA ID

10978779

Incident

Mar 17, 2017

Mileage

10,005 mi

TL* THE CONTACT OWNS A 2016 TOYOTA TACOMA. WHILE DRIVING APPROXIMATELY 40 TO 65 MPH, THE VEHICLE RANDOMLY UPSHIFTED AND/OR DOWNSHIFTED AND ACCELERATED OR DECELERATED ON ITS OWN. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS DRIVEN TO THE DEALER AND A SOFTWARE UPDATE WAS PERFORMED. THE ISSUE RECURRED NUMEROUS TIMES. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED. THE APPROXIMATE FAILURE MILEAGE WAS 4,000.

NHTSA ID

10936668

Incident

Aug 10, 2016

Mileage

4,000 mi

WHEN DRIVING ON THE HIGHWAY THE ACCELERATION IS ERRATIC. I WILL PRESS ON THE ACCELERATOR TO GET TO A CRUISING SPEED (THIS HAPPENS ANYWHERE BETWEEN 40-60 MPH) AND THE VEHICLE SUDDENLY ACCELERATES AND THE TACHOMETER JUMPS FROM BETWEEN 2000 AND 3000 TO THE UPPER 4000 ? 5000 RANGE. ADDITIONALLY, WHEN I HAVE THE CAR IN CRUISE CONTROL, IT DOES THE SAME THING WHEN GOING UP HILLS. THE ENGINE REVS LOUDLY AND THE TRUCK LURCHES ERRATICALLY FORWARD, SO I HAVE TO QUICKLY TAKE IT OUT OF CRUISE CONTROL AND GET THE PEG ON THE TAC DOWN TO A MORE REASONABLE LEVEL. MECHANICS AT THE SCHEDULED DID NOT MAKE A NOTE OF ANY ISSUES. I WILL PRESS THIS WITH THEM AT THE NEXT TUNE-UP AND SAFETY CHECK. THE ONLINE FORM HERE ASKS FOR A SPECIFIC DATE. THIS HAS BEEN ONGOING SINCE I PURCHASED THE CAR 11-JUNE-2016 TO PRESENT (21-OCT-16). *TR

NHTSA ID

10917788

Incident

Oct 21, 2016

Mileage

6,500 mi

FIRST INCIDENT OCCURED WHILE VEHICLE WAS STUCK IN LIGHT SNOW AND ICE CONDITION. 4-WHEEL DRIVE SYSTEM DID NOT APPEAR TO BE OPERATING PROPERLY. ENGAGED NEW "CRAWL-CONTROL" SYSTEM PER OWNER'S MANUAL INSTRUCTIONS. DURING USE OF CRAWL-CONTROL THE MOTOR RPM'S EXCEEDED 5,500; IMMEDIATELY PRESSED ENGINE-STOP BUTTON AND APPLIED BRAKES. INCIDENT RESULTED IN CATASTROPHIC DAMAGE OF FRONT DRIVE-LINE. DAMAGE INCLUDED FRONT DRIVE-SHAFT FAILURE; DEALER INDICATED "DRIVE-LINE" REPLACED. SIGNIFICANT DAMAGE TO COMPONENTS ADJACENT TO FRONT DRIVE-SHAFT. VEHICLE REPAIRED UNDER WARRANTY. TWO DAYS AFTER SERVICE RANDOM BRAKE LOCK-UP OCCURS WHILE DRIVING; VEHICLE SKIDS OUT OF CONTROL. NO MALFUNCTION INDICATORS SHOWING. ABS ALSO DOES NOT ACTIVATE DURING PANIC STOP BRAKE APPLICATION. BRAKE LOCKUP EXPERIENCED IN WINTER CONDITIONS AT HIGH ELEVATION NEARLY CAUSING POTENTIALLY FATAL ACCIDENT (1,000FT DROP FROM ROAD TO CANYON BOTTOM, NO GUARD-RAILS). WHILE DRIVING AT 30MPH THE REAR END OF THE TRUCK BEGINS TO SLIDE SIDEWAYS. UPON COMING TO A STOP IT IS DISCOVERED THAT THE VEHICLE WILL NOT DRIVE FORWARD. ENGAGED 4-WHEEL DRIVE AND VEHICLE STRUGGLED TO MOVE. ENGAGED DIFFERENTIAL LOCK AND DROVE BACKWARDS FOR 80FT. WHEELS APPEAR TO BECOME UN-LOCKED. DRIVE FORWARD FOR ANOTHER 500 YARDS AND SAME SITUATION OCCURS.

NHTSA ID

10823868

Incident

Jan 30, 2016

Mileage

2,500 mi

ON 11/23/15 I WAS ABLE TO TAKE POSSESSION OF THE VEHICLE. ON 11/24/15 I GOT INTO THE VEHICLE TO CRANK IT UP WHEN THE VEHICLE'S WARNING LIGHTS OF BRAKE, ABS WARNING TO CHECK THE ANTI'LOCK BRAKE SYSTEM AND CHECK BRAKE SYSTEM AND THE ANTISKID/TRACTION LIGHTS CAME ON AT APPROXIMATE 110 MILES. I IMMEDIATELY CALLED THE DEALERSHIP AND WAS TOLD THAT IT WOULD NOT HURT THE VEHICLE TO DRIVE IT AND THAT IT WAS SAFE. I WAS TOLD THAT IT WAS PROBABLY JUST A FUSE BY A SALESPERSON, WHO ALLEGEDLY TALKED TO ONE OF THE MASTER TECHNICIANS ABOUT THE SITUATION. ON 11/30/15 I ALSO REPORTED THAT THE CRUISE CONTROL WAS ALSO NOT WORKING TO THE SERVICE DEPARTMENT WHEN I ARRIVE AT THE DEALERSHIP. THE VEHICLE WAS DIAGNOSED WITH A BAD LEFT REAR SPEED SENSOR AT 185 MILES AND AGAIN THAT THE VEHICLE WAS SAFE TO DRIVE. ON 12/04/15 AT 334 MILES THE SENSOR WAS REPLACED. AS I WAS GOING HOME ON THE INTERSTATE HIGHWAY AND LESS THAN 10 MILES AWAY, THE SAME LIGHTS AND WARNING READOUTS CAME BACK ON. I IMMEDIATELY TURNED THE VEHICLE AROUND AND PROCEEDED BACK TO THE DEALERSHIP. ON MY WAY BACK TO THE DEALERSHIP WHILE SLOWING DOWN, A LOUD METALLIC BANGING/RATTLE COULD BE HEARD COMING FROM THE REAR END. WHEN I GOT BACK TO THE DEALERSHIP, I EXPLAINED THE SAME SYMPTOMS HAPPENED AGAIN AS BEFORE AND THAT NOW CLANGING/RATTLE IN THE REAR END HAD DEVELOPED TO THE SERVICE MANAGER. AT APPROXIMATELY 4:00P.M., I RECEIVED A CALL FROM THE SERVICE DEPARTMENT AND WAS TOLD THAT A REAR WHEEL BEARING WAS NOT INSTALLED CORRECTLY FROM THE FACTORY, THAT IT HAD DONE SOME DAMAGE AND THAT THE PARTS WERE ORDERED. I EXPRESSED MY CONCERNS ABOUT POSSIBLE OTHER DAMAGE SUCH AS THE BRAKES, TIRE, SENSORS OR THE REAR HOUSING AND SAFETY OF THE VEHICLE.

NHTSA ID

10809882

Incident

Nov 30, 2015

Mileage

110 mi