2019 Toyota Tacoma Engine Problems

The contact owns a 2019 Toyota Tacoma. The contact stated that while driving at an undisclosed speed, there was an abnormal clattering sound coming from the engine, with a misfire coming from the engine. The check engine warning light was illuminated. The vehicle was restarted; however, the failure reoccurred. The vehicle was taken to several mechanics, where it was diagnosed and determined that the fuel injector in cylinder #3 had failed and needed to be replaced. The vehicle was not repaired. The vehicle was then taken to the dealer, where it was diagnosed with engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 89,000.

NHTSA ID

11716829

Incident

Feb 9, 2026

Mileage

89,000 mi

The engine in my 2019 Toyota Tacoma TRD Off Road suffered internal damage that appears linked to Toyota’s low-pressure fuel pump recall (issued 10/28/2020, repaired 581 days later on 6/10/2022). While out on personal lease, the truck was driven over 16,000 miles with the defective pump, which can cause lean running conditions and elevated combustion temperatures. The result was metallic contamination and a damaged wrist pin in cylinder #6, requiring full engine replacement. All failed components remain available for inspection upon request. The fuel pump defect and resulting internal engine damage continues to place my safety and others’ at risk by creating potential for loss of power, engine stall, or total failure while driving. The problem was confirmed by two separate Toyota dealerships, both of which diagnosed the need for engine replacement. The vehicle has been inspected by multiple Toyota service centers and the Toyota Brand Engagement Center, which opened and later denied my case. No warning lights or messages appeared prior to the ticking noise that first appeared around 62,000 miles. In fact, no warning lights have ever illuminated on the dash. Despite clear evidence that the recall-related defect likely caused the damage, Toyota has refused to provide any assistance or coverage toward repairing or replacing the failed engine, leaving me with a $21,000 repair for a vehicle that was otherwise maintained and operated responsibly.

NHTSA ID

11698872

Incident

Mar 11, 2025

My check engine light came on when I was traveling in Oregon. I didn't notice any major changes in my vehicle's performance. Drove it all the way back to Colorado without issues. It went off and came back on several times. I replaced the cabin air filter, engine air filter and put fuel injector cleaner in the vehicle. Finally I took it in to the Toyota dealership to get an oil change and then the check engine light came back on. I paid for them to do a diagnostic test and they stated they were almost certain it was the 2nd fuel injector running rich. Brought it back a week later for the repair. Fyi...I was still getting 20 mpg in fuel and I wasn't noticing anything major in performance. They replaced the fuel injector and then the check engine light came back on with a different code. They are now running "another" more expensive diagnostic test and I still don't have my truck. They are saying it could be the 2nd cylinder or the engine and claiming it has 150,000 miles so I should expect these issues (and conveniently my warranty has run out).

NHTSA ID

11666121

Incident

Jun 10, 2025

Engine Block

NHTSA ID

11649915

Incident

Mar 20, 2025

Timing cover gasket failed. I notice leak at 70k but the gasket may have failed earlier. I believe this to be a manufacture defect as this is a common issue.

NHTSA ID

11624316

Incident

Jan 1, 2023

The transmission cooling line in my 2019 Toyota Tacoma was never installed by an authorized repair shop following an accident. This critical component failure led to the transmission failing just 1.5 hours after I retrieved the vehicle from the shop. My safety was compromised, as the failure occurred while driving at highway speeds, without any warning lights or messages indicating an issue. The failure has been confirmed by the dealership (MotorWorld Toyota) currently inspecting my vehicle. The shop responsible for the initial repairs has taken liability for missing the installation of the transmission cooling line. My insurance company (GEICO) has been involved but is delaying total loss consideration. No warning lamps or messages appeared before or after the transmission failure, which is highly suspicious. This negligence has caused severe damage to a vital component of my vehicle, and I question the overall integrity of the repairs.

NHTSA ID

11621816

Incident

Oct 22, 2024

The contact owns a 2019 Toyota Tacoma. The contact stated that while driving at various speeds, the vehicle suddenly stalled. The contact stated that the failure had occurred on several occasions. The cause of the failure was not yet determined. The local dealer was contacted. The manufacture was not contacted. The failure mileage was approximately 120,000.

NHTSA ID

11614457

Incident

Sep 13, 2023

Mileage

120,000 mi

Experienced a check engine light and took the 2019 Toyota Tacoma to the Toyota dealer where they ran diagnostic check revealing the # 1 cylinder had little to no compression due to damaged valves. Mileage at the time of failure was 59966 miles.

NHTSA ID

11572698

Incident

Feb 8, 2024

This 2019 truck feels like it just doesn’t want to go. It struggles to go up ANY hill no matter how small. The engine jumps feels like it’s got a heart beat while riding. The gas mileage is horrendous and awful the 2015 was all around a better truck I read somewhere that Toyota recalled a bunch of 2019 trucks for a gas line rip was causing fires and whatever else. I thought for sure it had to be my trucks issue bc that would absolutely explain why it’s running so weird and ragged. The poor thing … I’m very worried about it.

NHTSA ID

11552003

Incident

Jul 16, 2023

The engine part “Coolant bypass joint” failed, started leaking coolant at 44k miles, because it was made of inferior plastic material, unlike the same part used in the same 3.5L V6 engines in the Lexus vehicles, which are made of aluminum. This is a widespread failure since 2016 model years, and Toyota refused change the design or manufacturing material of the part, or to repair it under warranty. The part number for this failed part is 16356-31051.

NHTSA ID

11519611

Incident

Apr 12, 2023

Engine stalled unexpectedly

NHTSA ID

11504762

Incident

Sep 16, 2020

Engine lifters making abnormal noise.

NHTSA ID

11504752

Incident

Nov 30, 2020

Engine making ticking noise, this is approximately 4000 miles after repeated engine stalls.

NHTSA ID

11504747

Incident

Apr 28, 2020

Vehicle stalled unexpectedly

NHTSA ID

11504745

Incident

Apr 27, 2020

Fuel system - vehicle surged (high RPMS) while gearshift lever was in the Drive position after release of pressure on the accelerator as I was parking the vehicle surged and smashed into a cement post, the vehicle traveled approximately 10 to 15 feet. The vehicle is currently at the dealership where an independent contractor, who is contracted by Toyota, will be doing a visual and diagnostic analysis. I expect the vehicle to be returned to me on 1/19/2023. The vehicle and components have not been inspected by any other individual at this time. There were no warning lights on prior to the surge. Unknown if any warning light came during the incident which I believe was two (2) seconds until impact with the post.

NHTSA ID

11502194

Incident

Dec 29, 2022

I was told of a coolant leak in my truck... Took it in to have it looked at and there is a bubble in the block that popped. Toyota current has the same issue with their 2.5 liter engines when a flow meter wasn't working properly causing issues with the casting of the engine blocks. I brought this to Toyota and they say its out of warrantee. This isn't a warranty issue its a safety issue now because if the vehicle looses all coolant it can overheat causing catastrophic failure to the engine. The service director told me personally that it wouldn't matter if I babied this truck or if I rode it hard the bubble would've popped either way. The pictures I sent are of the passenger side of the block on the left side of the motor mount.

NHTSA ID

11450876

Incident

Feb 1, 2022

I was driving my truck a 2019 TRD off road Tacoma from San Diego to LA I was on the 605 freeway in the fast lane when I noticed smoke smell and then I noticed fire flames by the air conditioner and the phone charging plate I proceed to Exit the freeway thankfully I did not get in a car accident with any other vehicles however I was unable to stop and put out the fire. It's very upsetting because at no fault of my own I am now lob obligated to find another vehicle and I am not in the financial or credit position that I was when I bought my truck that is now a total loss by my insurance it covers my loan but not much after that so the fact that I've heard that this has been an issue for a few other Tacoma's And it's not even listed yet there's a problem the fact that this is not within my control as to what happened and there's nothing but oh well good luck getting another car Something needs to change.

NHTSA ID

11419291

Incident

May 19, 2021

TL* THE CONTACT CALLED ON BEHALF OF HIS PARENT WHO OWNS A 2019 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE STALLED WHILE DRIVING AT AN UNDISCLOSED SPEED. THE VEHICLE WAS RESTARTED HOWEVER, THE VEHICLE DROVE POORLY. THERE WAS NO WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO HAMER TOYOTA (11041 SEPULVEDA BLVD, MISSION HILLS, CA 91345) BUT WAS NOT DIAGNOSED NOR REPAIRED. THE CONTACT STATED THAT THE VEHICLE WAS RETURNED TO THE DEALER FOR A BUY BACK CONSIDERATION HOWEVER, THE DEALER DECLINED TO PROVIDE A BUY BACK. THE VIN WAS INCLUDED IN NHTSA CAMPAIGN NUMBER: 20V682000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 12,000.*DT*JB

NHTSA ID

11388813

Incident

May 18, 2019

Mileage

12,000 mi

UNPROMPTED ACCELERATION - WHILE DRIVING AT ABOUT 15 MPH IN MODERATE TRAFFIC, I ACCELERATED BRIEFLY AND THEN LET OFF THE GAS PEDAL. AFTER RELEASING THE GAS PEDAL, THE TRUCK CONTINUED TO ACCELERATE AND EVEN DOWNSHIFTED, CAUSING THE TRUCK TO LURCH FORWARD. CONDITIONS - I WAS IN LIGHT TO MODERATE TRAFFIC ON MY COMMUTE TO WORK. THE TRAFFIC WAS STOP-AND-GO. THE CARS AHEAD OF ME ACCELERATED, SO I DID AS WELL. THE CARS AHEAD OF ME QUICKLY DECELERATED, SO I LET OFF THE GAS BUT DID NOT NEED TO BRAKE AS I WAS A SAFE DISTANCE. THE TRUCK CONTINUED TO ACCELERATE WELL AFTER I LET OFF THE GAS AND IT LURCHED FORWARD AND DOWNSHIFTED IN THE PROCESS. THE ENGINE RPM WENT TO ABOUT 3,500. I WAS ABLE TO APPLY THE BRAKE, AND THE ACCELERATION STOPPED AND THE ENGINE WENT BACK TO IDLE. I HAVE EXPERIENCED DECELERATION LAG IN MANY VEHICLES, BUT IN THIS CASE, IT WAS A SURGE, NOT A LAG. IT WAS LONG ENOUGH FOR ME TO THINK OF SHIFTING TO NEUTRAL AND APPLYING THE EMERGENCY BRAKE.

NHTSA ID

11383510

Incident

Dec 15, 2020

Mileage

13,735 mi

MY VEHICLE (VIN# [XXX]) HAS NOT HAD SAFETY RECALL ADDRESSED BY MY LOCAL DEALERSHIP. THE RECALL WAS INITIATED ON 28 OCTOBER 2020. THE LOCAL DEALERSHIP HAS HAD MORE THAN A MONTH TO MAKE A PLAN TO FIX THE PROBLEM AND HAS RESPONDED TO MY REQUEST BY STATING THAT PARTS ARE NOT YET AVAILABLE AND FEEL I SHOULD CONTINUE TO OPERATE MY VEHICLE IN ITS CURRENT STATE. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

11378300

Incident

Dec 7, 2020

Mileage

5,128 mi

TL* THE CONTACT OWNS A 2019 TOYOTA TACOMA. THE CONTACT STATED THAT THE VEHICLE HESITATED AND STALLED WHILE DRIVING WITHOUT WARNING. THE VEHICLE WAS RESTARTED. THE CONTACT STATED THAT WHEN THE VEHICLE WAS RESTARTED IT FELT AS IF THE VEHICLE WAS RUNNING OUT OF FUEL. THE VEHICLE WAS ABLE TO DRIVE TO THE CONTACT'S RESIDENCE. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN NUMEROUS TIME FOR THE SAME FAILURE TO TOYOTA OF BRISTOL, 3045 W. STATE ST, BRISTOL, TN 37620, AND WAS DIAGNOSED THAT THE VEHICLE WAS DANGEROUS TO BE DRIVEN. THE CONTACT WAS INFORMED BY THE DEALER NOT TO DRIVE THE VEHICLE AND THAT THEY WOULD NOT DRIVE THE VEHICLE DUE TO THE HESITATION. THE VEHICLE WAS NOT REPAIRED. THE CONTACT MENTIONED THAT THE FAILURE STARTED SINCE THE PURCHASE OF THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THEY WOULD GET BACK WITH HIM BUT HAVE NOT YET CALLED BACK. THE FAILURE MILEAGE WAS APPROXIMATELY 8,000 *JS *JS

NHTSA ID

11343841

Incident

Aug 14, 2019

Mileage

8,000 mi

TL* THE CONTACT OWNS A 2019 TOYOTA TACOMA. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V012000 (FUEL SYSTEM, GASOLINE). THE CONTACT STATED THAT WHILE DRIVING AT VARIOUS SPEEDS, THE CHECK ENGINE WARNING LIGHT ILLUMINATED. THE BRAKE PEDAL WAS DEPRESSED AND BECAME SOFT, EXTENDING THE BRAKING DISTANCE. ADDITIONALLY, THE FUEL GAUGE PROVIDED INCONSISTENT FUEL LEVEL READINGS. THE VEHICLE WAS TOWED TO KEYES TOYOTA (5855 VAN NUYS BLVD, VAN NUYS, CA 91401) WHERE IT WAS DIAGNOSED THAT THE FUEL TANK AND FUEL GAUGES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER ON 5 SEPARATE OCCASIONS DUE TO THE FAILURE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, AND INFORMED THE CONTACT TO TAKE THE VEHICLE BACK TO THE DEALER HOWEVER, THE DEALER OFFERED NO ASSISTANCE. THE CONTACT REFERENCED NHTSA CAMPAIGN NUMBER: 18V888000 (SERVICE BRAKES, HYDRAULIC) AS A POSSIBLE SOLUTION TO THE FAILURE HOWEVER, THE VIN WAS NOT INCLUDED. THE FAILURE MILEAGE WAS APPROXIMATELY 900.

NHTSA ID

11331809

Incident

Mar 27, 2019

Mileage

900 mi

THE ENGINE STALLS WHEN COASTING. THE VEHICLE WAS IN MOTION ON A STATE HIGHWAY. A RECALL NOTICE WAS ISSUED ON JANUARY 13, 2020 FOR THIS ISSUE BUT SIX MONTHS HAVE ELAPSED WITH NO REMEDY YET AVAILABLE. THIS IS TOO LONG.

NHTSA ID

11331381

Incident

Jun 28, 2020

Mileage

11,000 mi

I STARTED TO NOTICE WHEN YOU WOULD STOP AT A RED. LIGHT AND APPLY THE BRAKES THE PEDAL WOULD SLOWLY EASE OFF LIKE IT HAD AIR IN THE BRAKE LINE.THIS WENT ON FOR A COUPLE OF MONTHS.I HAD A DOCTORS APPOINTMENT AND WHEN I GOT TO THE OFFICE AND WAS PULLING IN THE PARKING SPACE I PRESSED THE BRAKE AND IT WENT TO THE FLOOR SO I PRESSED THE SECOND TIME AND THE SAME THING I DIDN'T HAVE TIME TO TRY THE THIRD TIME BECAUSE I HIT THE CONCRETE WALL AND DID APPROXIMATELY $5200 DAMAGES TO MY VEHICLE.THE ENGINE HAS A NOISE IN ENGINE COMPARTMENT ON THE PASSENGER SIDE THAT SOUNDS LIKE A LIFTER MAKING A NOISE THAT CAN BE HEARD OVER THE ENGINE RUNNING.THE BRAKE PROBLEM I BELIEVE HAS TO DO WITH THE BOOSTER. *TR

NHTSA ID

11329562

Incident

Jun 15, 2020

Mileage

5,500 mi

WHILE DRIVING IN CRUISE CONTROL ON A RELATIVELY TRAFFIC FREE ROAD THERE WAS AN ACCIDENT FAR AHEAD THE ROAD AND THE VEHICLE AUTOMATICALLY STARTED TO DECELERATE I TOOK CONTROL, AND AFTER I TOOK CONTROL ALL THE LIGHTS ON THE CONTROL PANEL LIGHT UP AND THE VEHICLE GOT JERKY. I WAS ABLE TO STOP AND SINCE THERE WAS AN ACCIDENT I TURNED OFF THE VEHICLE AND RESTARTED IT AGAIN. IT ACTED NORMAL AFTER THAT PARTICULAR INCIDENT. I MENTIONED IT TO THE MECHANIC WHEN TIME CAME FOR ITS FACTORY MAINTENANCE, BUT THE DEALER WAS NOT ABLE TO EXPLAIN THE SITUATION. I BECAME AWARE AT THAT TIME OF THE RECALL. *TR

NHTSA ID

11325998

Incident

Nov 27, 2019

Mileage

14,000 mi