RoadVitals

2008 Ud UD3300 Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
7
Newest Jun 4, 2012
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

7 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

12V252000

SERVICE BRAKES, AIR

Jun 4, 2012
261 units potentially affected
The defect: UD TRUCKS NORTH AMERICA (UD TRUCKS) IS RECALLING CERTAIN MODEL YEAR 2008-2010 UD 3300 TRUCKS EQUIPPED WITH A DUAL STEERING SYSTEM. MODIFICATIONS TO THE VEHICLES MAY HAVE RESULTED IN LOSS OF ISOLATION BETWEEN THE PRIMARY AND SECONDARY AIR BRAKE SYSTEMS. THUS, THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NUMBER 121, “AIR BRAKE SYSTEMS.” MODIFICATIONS TO THE VEHICLES MAY HAVE RESULTED IN LOSS OF ISOLATION BETWEEN THE PRIMARY AND SECONDARY AIR BRAKE SYSTEMS.
The risk: IF THE VEHICLE EXPERIENCES AN AIR LEAK IN EITHER THE PRIMARY OR THE SECONDARY SYSTEM, THE VEHICLE MAY EXPERIENCE A TOTAL LOSS OF BRAKES, INCREASING THE RISK OF A VEHICLE CRASH.
The remedy: UD TRUCKS WILL NOTIFY OWNERS AND WILL CORRECT THE AIR BRAKE SYSTEM OF THE AFFECTED VEHICLES. THE RECALL BEGAN ON JULY 12, 2012. OWNERS MAY CONTACT UD TRUCKS AT 1-336-393-2233.
UD TRUCKS CORPORATIONView on NHTSA.gov
10V006000

SERVICE BRAKES, AIR:SUPPLY:CHECK VALVE

Jan 8, 2010
1,004 units potentially affected
The defect: NISSAN DIESEL IS RECALLING CERTAIN MODEL YEAR 1999-2010 UD3300 VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." THESE VEHICLES HAVE INSUFFICIENT AIR TANK RESERVE CAPACITY AND MAY RESULT IN INSUFFICIENT AIR SUPPLY TO PROPERLY OPERATE THE BRAKES DURING REPETITIVE BRAKE APPLICATIONS.
The risk: THIS MAY RESULT IN REDUCED BRAKING PERFORMANCE WHICH COULD RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING TO THE VEHICLE OPERATOR.
The remedy: THE AIR RESERVOIR TANK'S VOLUME WILL BE INCREASED TO MEET FMVSS 121 REQUIREMENTS. OWNERS WILL BE ASKED TO BRING THEIR VEHICLES TO A DEALER TO HAVE THE REMEDY PERFORMED FREE OF CHARGE. THE SAFETY RECALL FOR OWNERS OF 2008 THROUGH 2010 UD3300 VEHICLES BEGAN ON AUGUST 20, 2010. NOTIFICATION TO OWNERS OF THE 1999 THROUGH 2007 UD3300 VEHICLES IS EXPECTED TO BEGIN AT THE END OF JANUARY 2011 . OWNERS MAY CONTACT NISSAN DIESEL AT 972-756-5500.
NISSAN DIESEL AMERICA, INCView on NHTSA.gov
10V005000

SERVICE BRAKES, AIR:SUPPLY:QUICK RELEASE VALVE

Jan 1, 2010
1,004 units potentially affected
The defect: NISSAN DIESEL IS RECALLING CERTAIN MODEL YEAR 1999-2010 UD3300 VEHICLES. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." THE BRAKE ACTUATION AND RELEASE TIMING OF THE AIR BRAKE SYSTEM ON THESE VEHICLES MAY NOT PERFORM CORRECTLY.
The risk: OPERATION OF A VEHICLE WITH INCORRECT AIR BRAKE APPLY/RELEASE TIMING MAY RESULT IN REDUCED BRAKING PERFORMANCE WITHOUT WARNING TO THE VEHICLE OPERATOR, WHICH COULD RESULT IN A VEHICLE CRASH.
The remedy: THE AIR BRAKE LINE WILL BE MODIFIED. DEALERS WILL INSPECT AND REPAIR VEHICLES AT NO CHARGE. THE SAFETY RECALL FOR OWNERS OF 2008 THROUGH 2010 UD3300 VEHICLES BEGAN ON AUGUST 20, 2010. NOTIFICATION TO OWNERS OF THE 1999 THROUGH 2007 UD3300 VEHICLES IS EXPECTED TO BEGIN AT THE END OF JANUARY 2011. OWNERS MAY CONTACT NISSAN DIESEL AT 1-972-756-5500.
NISSAN DIESEL AMERICA, INCView on NHTSA.gov
09V487000

SERVICE BRAKES, AIR:SUPPLY:QUICK RELEASE VALVE

Dec 22, 2009
73 units potentially affected
The defect: NISSAN DIESEL IS RECALLING CERTAIN MODEL YEAR 2007 AND 2008 UD3300 VEHICLES THAT WERE MODIFIED BY INSTALLING DUAL STEERING CONTROLS FOR USE AS STREET SWEEPERS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." BRAKE RECERTIFICATION WAS NOT PERFORMED ON THESE VEHICLES DURING MODIFICATION OF THE DUAL STEERING SYSTEM.
The risk: OPERATION OF A VEHICLE WITH INCORRECT AIR BRAKE APPLY/RELEASE TIMING MAY RESULT IN REDUCED BRAKING PERFORMANCE WHICH COULD RESULT IN A VEHICLE CRASH WITHOUT PRIOR WARNING TO THE VEHICLE OPERATOR.
The remedy: DEALERS WILL INSPECT AND REPLACE THE NECESSARY COMPONENTS FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE FEBRUARY 15, 2010. OWNERS MAY CONTACT NISSAN DIESEL AT 1-972-756-5500.
NISSAN DIESEL AMERICA, INCView on NHTSA.gov
09V337000

STEERING

Aug 27, 2009
94 units potentially affected
The defect: NISSAN DIESEL IS RECALLING CERTAIN MODEL YEAR 2007-2008 UD3300 VEHICLES THAT WERE MODIFIED BY INSTALLING DUAL STEERING CONTROLS FOR USE AS STREET SWEEPERS. THE RIGHT SIDE STEERING DRAG LINK MAY HAVE BEEN INSTALLED INCORRECTLY.
The risk: INCORRECT INSTALLATION OF THE RIGHT SIDE STEERING DRAG LINK AND/OR IMPROPER ADJUSTMENT OF THE STEERING STOPS COULD ALLOW THE TIRE TO CONTACT THE RIGHT SIDE STEERING DRAG LINK DURING A FULL LEFT TURN. CONTINUED OPERATION WITH THE RIGHT FRONT TIRE CONTACTING THE RIGHT SIDE STEERING DRAG LINK MAY RESULT IN STRUCTURAL WEAKENING AND BENDING OF THE DRAG LINK. THIS COULD RESULT IN A LOSS OF STEERING CONTROL AND/OR CAUSE A VEHICLE CRASH WITHOUT WARNING TO THE VEHICLE OPERATOR.
The remedy: DEALERS WILL REINSTALL THE RIGHT SIDE STEERING DRAG LINK AND THE STEERING STOP ADJUSTMENT WILL BE ADJUSTED FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE OCTOBER 12, 2009. OWNERS MAY CONTACT NISSAN DIESEL AT 972-756-5500.
NISSAN DIESEL AMERICA, INCView on NHTSA.gov
09V111000

SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS

Apr 6, 2009
10 units potentially affected
The defect: NISSAN DIESEL IS RECALLING 10 MY 2008 UD3300 TRUCKS EQUIPPED WITH ARVIN MERITOR 2-SPEED REAR AXLE. THE LENGTH OF THE AIR BRAKE HOSE INSTALLED BETWEEN THE RELAY VALVE AND QUICK RELEASE VALVE FOR THE LEFT REAR AIR BRAKE ASSEMBLY IS INCORRECT AND MAY INCREASE THE RESISTANCE IN THE AIR SUPPLY.
The risk: INCORRECT LENGTH OF AIR BRAKE HOSE WILL INCREASE THE RISK OF A CRASH.
The remedy: DEALERS WILL HAVE THE AIR BRAKE HOSE REPLACED BETWEEN THE RELAY VALVE AND THE QUICK RELEASE VALVE WITH THE CORRECT LENGTH HOSE FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN ON OR BEFORE MAY 4, 2009. OWNERS MAY CONTACT NISSAN DIESEL AT 972-756-5500.
NISSAN DIESEL AMERICA, INCView on NHTSA.gov
08V617000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Nov 24, 2008
549 units potentially affected
The defect: NISSAN DIESEL IS RECALLING 549 MY 2008 UD1800, UD2000, UD2300, UD2600, AND UD3300 MEDIUM DUTY TRUCKS. A FAILURE OF THE FUEL INJECTION PUMP DRIVE COUPLER CAN OCCUR. THE BOTTOM CORNER OF THE NOTCHED DRIVE SURFACE WAS IMPROPERLY MACHINED. WITH INCREASED FUEL PUMP PRESSURE, THE REQUIRED TURNING TORQUE ON THE DRIVE COUPLER INCREASED. THE INCREASED TURNING TORQUE COULD CRACK THE COUPLER AT THE BOTTOM CORNER WITHOUT WARNING UNDER NORMAL VEHICLE OPERATION.
The risk: CONTINUED OPERATION WITH A CRACKED DRIVE COUPLER COULD RESULT IN THE COUPLER BECOMING BROKEN AND CAUSING THE ENGINE TO STALL AND NOT RESTART, INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL REPLACE THE FUEL INJECTION PUMP DRIVE COUPLER. THE RECALL BEGAN ON JANUARY 19, 2009. OWNERS MAY CONTACT NISSAN DIESEL AT 1-972-756-5500.
NISSAN DIESEL AMERICA, INCView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources