2022 Vanleigh Beacon Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2022 Vanleigh Beacon, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Suspension342.9%
- Body & structure228.6%
- Brakes114.3%
- Other / unspecified114.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
See attached document for complaint.
This is my second report with two different incidents of failure. These failures are connected to the Lippert frame of my fifth wheel trailer. While, traveling in Indiana near Gary, Indiana my leafspring on the rear axle on the driver side gave away, causing the trailer to veer hard to the left. Fortunately, there was no one to my left and I was able to regain control and get to the shoulder. After inspecting, I determined that the pin holding the leaf springs together sheared off after going over a bridge expansion joint. The second issue I discovered this spring is that I have two significant cracks in the upper deck frame, causing extreme frame flax. Lippert is refusing to cover the fix under the warranty. Lippert has been very difficult to deal with during this process and I have been forced to use a third-party to fix their poor welds. I have pictures if need be. There are many other frame issues that other people are dealing with. All have the Lippert frames! Someone will be severely injured or killed if Lippert is not held accountable by the federal government.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
This is my second report with two different incidents of failure. These failures are connected to the Lippert frame of my fifth wheel trailer. While, traveling in Indiana near Gary, Indiana my leafspring on the rear axle on the driver side gave away, causing the trailer to veer hard to the left. Fortunately, there was no one to my left and I was able to regain control and get to the shoulder. After inspecting, I determined that the pin holding the leaf springs together sheared off after going over a bridge expansion joint. The second issue I discovered this spring is that I have two significant cracks in the upper deck frame, causing extreme frame flax. Lippert is refusing to cover the fix under the warranty. Lippert has been very difficult to deal with during this process and I have been forced to use a third-party to fix their poor welds. I have pictures if need be. There are many other frame issues that other people are dealing with. All have the Lippert frames! Someone will be severely injured or killed if Lippert is not held accountable by the federal government.
I purchased this vehicle new July 14, 2022. On its first trip, I noticed a gap starting on the side panels near the overhang of the 5th wheel. I reported this to the dealer and they determined that there was excessive flame flex. The vehicle had to be taken back to the manufacturer to be repaired. I’m still having issues with frame flex. This 5th wheel weighs 18,500 pounds and the fact that there is broken components to the frame put all of us at risk of great bodily harm or death. This is an issue in the RV 5th wheel industry that needs to be addressed immediately.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
The contact owns a 2022 Vanleigh Beacon RV Trader. The contact stated while his friend was driving his RV trader at 30 mph while trying to brake, he felt a delay in the brake pedal. The trader was taken to the dealer on a separate occasion. The dealer diagnosed that the brakes needed to be flushed. The manufacturer flushed the brakes but the failure continued. The RV trader was not repaired. The Rv trader was towed. The manufacturer was notified of the failure. The failure mileage 400,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
See attached document for complaint.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .