Owner-reported complaints naming the engine system, filed with NHTSA
Data refreshed
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components. Every record below is an owner-reported complaint about the 1998 Volkswagen Beetle submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 34 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
The 25 most recent of 34, in the owner's own words
DAUGHTER WAS DRIVING TO SCHOOL, CAR STALLED, RESTARTED CAR THEN SAW SMOKE AND FIRE UNDER PASSENGER SIDE DASH. CAR BURNT COMPLETELY, TOTALED. HAVE BEFORE AND AFTER PICTURES. ..UPDATED 11/12/14 *BF
TL* THE CONTACT OWNS A 1998 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT WHILE DRIVING 60 MPH, THE VEHICLE STALLED AND FAILED TO SHIFT INTO ANY GEAR WITHOUT WARNING. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE AND CURRENT MILEAGE WAS 85,000.
TL* THE CONTACT OWNS A 1998 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT WHILE DRIVING 55 MPH, THE TEMPERATURE LIGHT BEGAN BEEPING, THEN SUDDENLY STOPPED BEEPING AND A RED LIGHT BEGAN FLASHING. THE CONTACT NOTICED A THUMP UNDER THE ACCELERATOR PEDAL SO SHE STOPPED THE VEHICLE ON THE LEFT SIDE OF THE HIGHWAY. SHE ATTEMPTED TO DRIVE THE VEHICLE TO THE RIGHT SIDE, BUT THE VEHICLE WOULD NOT START, SO SHE COASTED OVER TO THE RIGHT SIDE OF THE HIGHWAY. WHEN THE HOOD WAS OPENED, THERE WERE FLAMES ERUPTING AND THE ENTIRE VEHICLE WAS ENGULFED IN FLAMES. THE VEHICLE WAS DESTROYED. THE FIRE DEPARTMENT WAS CALLED BUT NO REPORT WAS FILED. THE MANUFACTURER HAD NOT BEEN NOTIFIED. THE VIN WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 136,000.
TL* THE CONTACT OWNS A 1998 VW BEETLE DIESEL. DRIVER WAS TRAVELING ABOUT 5MPH ON A CLEAR DAY WHEN SHE NOTICED A SQUEAK IN THE ENGINE. TOOK TO DEALER FOR A NEW BATTERY AND TO CHECK SQUEAK IN FRONT END AND CHECK AIR CONDITIONER. THE TECHNICIAN DISCOVERED FUSES WERE BURNT AND THAT BOTH FANS WERE MELTED. AFTER REPAIRS MADE CONTACT STATES THAT SQUEAK STILL PRESENT AND FANS STILL NOT WORKING. TECHNICIAN INFORMED CONTACT THAT REPAIRS MADE CORRECTLY. CONTACT TOOK VEHICLE BACK TO DEALER AND IT IS STILL THERE. FAILURE MILEAGE WAS 106,000. CURRENT MILEAGE 106,075.
MY CAR BEGAN TO OVER HEAT IN JULY AND I TOOK IT TO THE MECHANIC. I HAD TO REPLACE THE WATER PUMP, THERMOSTAT AND TIMING BELT. @ MONTHS PASS AND AGAIN ITS OVERHEATING AGAIN NOW I'M TOLD THE HEAD GASKET IS BAD. I FIX THE HEAD GASKET AND ITS OVERHEATING. THEY DO NOT KNOW WHAT IS CAUSING IT TO OVERHEAT. $1500 LATER I'M STILL IN THE SAME BOAT. *TR
SINCE I PURCHASED MY BEETLE IN 2001, IT HAS BEEN AN ONGOING MONEY DRAIN. IN 6 YRS. I HAVE REPLACED THE MANUAL TRANSMISSION TWICE, HAD THE BRAKES WORKED ON A NUMBER OF TIMES, BEEN UNABLE TO OPEN THE GAS "DOOR" ON THE CAR W/ THE GAS CAP LATCH, HAD TO REPLACE THE HOOD OPENING LATCH, HAD REPEATED ELECTRICAL FAILURES, PROBLEMS W/ FRONT & REAR LIGHT WIRING, HAD DOOR LOCKS/ALARM FAIL & SUBSEQUENTLY HAD MY LAPTOP STOLEN FROM THE CAR, THE RADIO HAS NOT WORKED FOR 1+ YEAR, & IT'S COVER PANEL IS LOOSE & FALLING BACK INTO THE DASH, THE REAR-VIEW MIRROR SWITCHES HAVE FAILED, THE POWER WINDOW SWITCHES HAVE HAD TO BE REPLACED, THE DRIVERS SIDE DOOR FELL OFF (!) OF ITS TOP HINGE WHEN THE HINGE BROKE WHILE OPENING THE DOOR NORMALLY AT A GAS STATION, THE AIR COMPRESSOR HAS FAILED MANY TIMES, THE A/C IS CURRENTLY NOT WORKING, THE DRIVERS SIDE DOOR LOCK FELL OUT OF THE HANDLE(!!!!), THE CATALYTIC CONVERTER HAS BEEN REPLACED TWICE, & THE LIST GOES ON. CURRENTLY I HAVE NOT BEEN DRIVING THE CAR FOR SEVERAL WKS B/C THOUGH ONLY A WEEK OR TWO OUT OF THE SHOP, AGAIN IT IS HAVING TRANSMISSION PROBLEMS. I AM AT MY WITS END WITH THIS CAR & HAVING RECENTLY GRADUATED FROM COLLEGE, AM NOT IN THE GREATEST POSITION TO HAVE TO BUY A NEW CAR. MOREOVER, I AM SO DISPLEASED W/ THE CAR THAT I WOULD LITERALLY FEEL GUILTY ABOUT TRADING IT IN TO BE SOLD TO SOME OTHER UNSUSPECTING PERSON. VW SHOULD BE SO ASHAMED OF THEMSELVES, & SHOULD BE REIMBURSING OWNERS OF THE 1998 BEETLE IN FULL FOR ALL OF THE STRIFE & TROUBLE THAT THEY HAVE CAUSED. IN FACT, AFTER WRITING THIS & REALIZING HOW MANY PROBLEMS THIS CAR HAS HAD, I MAY TRY TO TAKE LEGAL ACTION - THIS IS TOTALLY UNACCEPTABLE! FINALLY, OUR LOCAL VW DEALER IS TERRIBLE, KEEPING MY CAR FOR WKS. LONGER THAN EXPECTED, ONE TIME LEAVING A CANDY BAR STUCK TO MY PASSENGER SIDE SEAT!!!, AND ACTING LIKE THEY COULD CARE LESS ABOUT THE POOR QUALITY OF THEIR PRODUCTS & LABOR. *TR
WHILE DRIVING AT ANY SPEED VEHICLE VIBRATED AND JERKED UNCONTROLLABLY. CONSUMER WAS ABLE TO MAINTAIN CONTROL OF THE VEHICLE, AND DROVE IT TO THE DEALER FOR INSPECTION, BUT MECHANIC WAS NOT ABLE TO DUPLICATE THE PROBLEM. TWO WEEKS LATER, VEHICLE WAS TAKEN BACK TO THE DEALER FOR THE SAME PROBLEM, AND MECHANIC DETERMINED THAT ONE MOTOR MOUNT BOLT WAS MISSING AND ONE NEEDED TO BE TIGHTENED. *AK *JB
THE LOCK MECHANISM ON THE PASSENGER SIDE DOOR OF MY 1998 BEETLE JUST FELL OUT WITHOUT WARNING. I DISCOVERED THAT IT WAS MISSING AND WENT TO A REPAIR SHOP TO GET IT REPLACED, ONLY TO LEARN THE THIS IS A COMMON PROBLEM WITH BEETLES BECAUSE THE LOCK IS HELD IN BY ONLY ONE TINY SCREW. THIS DEFECT WILL COST ME $350.00 TO REPAIR, IN A CAR THAT HAS ONLY 50,000 MILES ON IT. I ALSO RECENTLY HAD TO REPLACE A FUSE THAT POWERED THE RADIATOR FAN BECAUSE THERE IS NO EARLY WARNING SYSTEM IN THE CAR TO INDICATE THAT THE FAN IS NOT WORKING. I WAS ONLY AWARE THERE WAS A PROBLEM WHEN THE CHECK-ENGINE LIGHT CAME ON, BY WHICH TIME THERE COULD HAVE BEEN EXTENSIVE DAMAGE TO THE RADIATOR. THE FUSE ITSELF HAD GOTTEN SO HOT IT HAD VIRTUALLY MELTED. THIS PROBLEM COST ME NEARLY $370.00 TO FIX. THE MECHANIC NOTED THAT HE HAD SEEN THIS HAPPEN WITH BEETLES SEVERAL TIMES BECAUSE THERE IS NO TEMPERATURE INDICATOR ON THE DASH -- YOU HAVE NO IDEA THERE IS A PROBLEM UNTIL THE CHECK-ENGINE LIGHT COMES ON. *NM
I HAVE INVESTED IN A 1998 VOLKSWAGEN BEETLE I ONLY DROVE IT 3 TIMES IT WHEN DOWN ON ME 6 MILES FROM MY HOUSE THE GUY THAT'S WORKING ON SAID MY HEADON MOTOR WAS CRACK , THEN I HAD ELE , PROBLEMS EVERYDAY I CALL IT IS SOMETHING ELSE I PAY DOWN TO EZWAY AUTO 5,000.00 THEN I PAY 383.00 A MONTH I HAVE ONLY HAD THIS CAR FOR 2 WEEKS . I ASK FOR MY MONEY BACK THEY SAID NO .WHAT SUCH I DO I AM DISABLE ON A LIMIT INCOME. *NM
WHEN CRUISE CONTROL WAS ENGAGED VEHICLE WOULD SUDDENLY ACCELERATE BEYOND THE SET SPEED. THE DEALER EXAMINED THE VEHICLE, AND FOUND THAT THE THROTTLE CONTROL MODULE WAS DEFECTIVE. *AK THE VEHICLE'S SPEEDOMETER WOULD NOT GO PAST 60 MPH. THE A/C COMPRESSOR FAILED WHICH CAUSED A LOUD SQUEALING NOISE WHEN TURNING THE A/C ON. THE MIL LIGHT ILLUMINATED INTERMITTENTLY. THE DEALER REPLACED THE AIR HOSE , AIR PUMP AND MASS AIR FLOW SENSOR. *NM
UPON STARTING THE VEHICLE THE SIDE AIR BAG DEPLOYED. THERE WAS NO COLLISION. CONSUMER WAS INJURED. ONE MONTH PRIOR TO THE AIR BAG DEPLOYMENT, THE AIR BAG LIGHT ILLUMINATED ON THE DASH BOARD. ALSO, THE ENGINE LIGHT ILLUMINATED PRIOR TO THE SIDE AIR BAG DEPLOYMENT. RECALL 98V100000 WAS ISSUED. *AK
WHILE DRIVING CHECK ENGINE LIGHT APPEARED ON DASHBOARD AND REMAINED ON. THEN, VEHICLE STALLED. CONSUMER TRIED TO RESTART VEHICLE, BUT WAS UNABLE TO DO SO. CONSUMER HAD THE VEHICLE TOWED TO THE DEALER FOR INSPECTION, AND MECHANIC COULD NOT DUPLICATE THE PROBLEM. CONSUMER INFORMED THE MECHANIC THAT PROBLEM OCCURRED MORE THAN ONCE, AND HAD NOT BEEN RESOLVED. *AK
I BOUGHT A 1998 VOLKSWAGEN BEETLE FROM TORRANCE NISSAN ON 5 JANUARY, 2003: SINCE THE DATE OF PURCHASE, THIS CAR HAD BEEN OVERHEATING OFF AND ON. I RETURNED IT TO THE DEALERSHIP BUT WAS INFORMED THAT IT WAS NOTHING TO WORRY ABOUT.? THEY WENT AS FAR AS TAKING IT TO A VW SERVICE REP ON 5 AND 6 JANUARY, 2003 FOR CONFIRMATION. I FOUND OUT LATER THAT VW HAS NO RECORD OF EVER SERVICING OR EVEN SEEING THE VW UNTIL 1 APRIL, 2003! DURING THE MONTHS OF FEBRUARY AND MARCH, 2003 I STILL EXPERIENCED THE VEHICLE OVERHEATING AND EACH TIME I CALLED AMIR, I WOULD FOLLOW UP WITH A VISIT TO TORRANCE NISSAN. THEIR REPLIES WERE ALWAYS THE SAME, THEY COULD NOT FIND A PROBLEM FOR THE OVERHEATING? THERE WERE MANY TIMES I TOLD THE DEALERSHIP THAT I NO LONGER WANTED THIS CAR AND EVEN SUBMITTED IT IN WRITING ON 15 APRIL, 2003. ON 1 APRIL, 2003 I TOOK THE BEETLE TO VOLKSWAGEN MYSELF AND HAD IT FIXED, BUT THE WATER PUMP BROKE AGAIN AND WAS REPLACED ON 4-9-03. THREE DAYS LATER, THE CAR WAS GETTING HOT. I TOLD BOTH VOLKSWAGEN AND TORRANCE NISSAN THAT I NO LONGER WANT THIS CAR! I HAVE PROOF OF ALL THE REPAIRS PERFORMED AND STILL IT OVERHEATS! ON 12 APRIL, 2003 I TOOK THE CAR ONCE MORE TO VOLKSWAGEN TO THOROUGHLY CHECK IT OUT AND THEY CALLED THEIR TECHNICAL SUPPORT. A FEW DAYS LATER THEY FOUND A CRACKED HEAD ON THE ENGINE BLOCK. TO TOP IT OFF, I HAD A CAR ACCIDENT ON 28 APRIL, 2003 ON MY WAY TO WORK AND HAD TO BE TOWED TO THE LONG BEACH HONDA BODY SHOP. LATER THAT NIGHT THE CAR CAUGHT FIRE AND WAS BURNED DOWN WITH 3 OTHER CARS IN THE BODY SHOP. BEFORE THE CAR CAUGHT FIRE, I WAS IN PROCESS OF A VALID CLAIM UNDER THE LEMON LAW & MAGNUSON-MOSS WARRANTY ACT WITH THE ADAM KROHN OF THE CONSUME LAW CENTER. ISSUES: RENTAL CAR $1,607.78 (MY INSURANCE ONLY COVERED $600.00, MY INSURANCE COVERED ONLY ACTUAL VALUE OF $10,788.31; LEAVING ME WITH A BALANCE OF $1,043.00 OUT-OF-POCKET. WHICH MY INSURANCE INFORMS ME MAKE A CLAIM AGAINST THE BODY SHOP FOR DIFFERENCE ON BALANCE AND $ 1007.78 OF THE CAR RENTAL.
WHILE DRIVING AT AN UNDETERMINED SPEED THE VEHICLE STALLED. THE CONSUMER TOOK THE VEHICLE TO A MECHANIC. PLEASE ADD ANY ADDITIONAL INFORMATION. *NLM
CONSUMER REPLACED BRAKE LIGHTS/HEADLIGHTS/REAR BRAKE PADS AND ROTORS/ ENGINE SHIELD AND COOLING SYSTEM. *AK *JB
VEHICLE CAUGHT ON FIRE, POSSIBLE ENGINE FAILURE, WHILE DRIVING THE VEHICLES BRAKE SYSTEM FAILED AND THE DRIVER HAD TO USE THE EMERGENCY BRAKE TO STOP VEHICLE. *MR THE HEAD LIGHT MALFUNCTIONED AND THE VEHICLES IS FLLING APART AFTER ONE MONTH OF OWNERSHIP. THE DEALER REFUSED TO FIX IT. *YH
CONSUMER STATED WHILE DRIVING, THE EPC INDICATOR LIGHT ILLUMINATED, THE DEALER STATED THE SWITCH WAS DEFECTIVE AND A NEW BRAKE SWITCH WAS INSTALLED, HOWEVER WHEN CONSUMER RECEIVED THE VEHICLE BACK AND PROCEEDED TO DRIVE, SHE NOTICED THAT IT FELT DIFFERENT, IT FELT TIGHT, CONSUMER SOON DISCOVERED THAT THE BRAKES HAD FROZE AND WOULD NOT MOVE, THE VEHICLE WAS TOWED TO THE DEALERSHIP IN WHICH THEY DISCOVERED THAT THE NEW BRAKE SWITCH THAT WAS INSTALLED HAD CAUSED THE BRAKES TO LOCK UP AND HAD TO BE REPLACED AGAIN.*JB
WHILE DRIVING,CONSUMER HEARD A LOUD NOISE, THEN A FIRE STARTED UNDERNEATH THE ENGINE COMPARTMENT, ONE PERSON WAS INJURED IN ACCIDENT, CLAIM 11-3827-188. *SLC
THIS CAR DRINKS OIL, THE ENGINE KNOCKS, VW HAS DONE NOTHING TO EVEN AKNOWLEDGE THE PROBLEM. THE WINDOW REGULATORS ARE DEFECTIVE AND ONE BROKE COMPLETELY WITH THE WINDOW FALLING OUT. THE PASSENGER SIDE DOOR CAN NOT BE OPEND WITH A KEY AND HAS BEEN CORODE
BAD WIRING, ALARM GOES OFF IN THE MIDDLE OG THE NIGHT, REAR HATCH LIGHT COMES ON AND OFF, WIRING IS BAD IN COLD WEATHER, FRONT HEADLIGHTS KEEP BURINING OUT, EXCESSIVE OIL CONSUMPTION, AT ABOUT 2000 MILES ENGINE WILL BE BONE DRY, EXCESSIVE ROAD NOSIE, RADIO NO LONGER WORKS, IN GENERAL THE CAR IS IN BAD SHAPE AFTER TWO YEARS OF USE AND IT SEESM TO BE ALL FACTORY RELATED TYPE OF PROBLEMS.
CAR OVERHEATS ROUTINELY. INITIALLY IN FOR REPAIR ON 1/25/01 WHEN DEALER CLAIMED TO HAVE REPLACED THE WATER PUMP AND THERMOSTAT. SINCE THEN, CAR HAS OVERHEATED ON THREE OCCASIONS, AND WATER LEAKAGE HAS BEEN OBSERVED. DEALER SAYS THEY CAN NOT REPLICATE THE ISSUE. DRIVER'S SIDE DOOR DOES NOT LOCK AND UNLOCK RELIABLY, FORCING ME TO ENTER AND EXIT CAR THROUGH PASSENGER DOOR. REPORTED TO DEALER THREE TIMES (INITIALLY 5/31/00). ONE TIME DEALER LUBRICATED LOCK; CURRENTLY THEY SAY THEY CAN NOT REPLICATE THE ISSUE AND WILL NOT FIX. AFTER WATER PUMP REPAIR IN 1/01, CAR EXHIBITED A WHINING NOISE AND POWER STEERING STIFFNESS AT LOW RPMS -- LIKELY DUE TO IMPROPER WORKMANSHIP DURING THAT REPAIR. DEALER CLAIMS POWER STEERING FLUID WAS LOW, AND HAS BEEN "TOPPED OFF" TO ALLEVIATE PROBLEM. HOWEVER, I RECENTLY HAD ROUNTINE MAINTENANCE AT ANOTHER ESTABLISHMENT JUST 4 DAYS PRIOR TO TAKING INTO SHOP; DURING THAT SERVICE, POWER STEERING FLUIDS WERE INDICATED AS "OK." OIL CONSUMPTION IS EXCESSIVE. DESPITE REPEATED REPORTS TO VW (INITIALLY 5/00), HAVE RECEIVED NO RESOLUION OR INVESTIGATION INTO THIS ISSUE. THROUGH RESEARCH, I HAVE LEARNED THAT THIS IS A COMMON BEETLE PROBLEM, AND SOME BEETLE OWNERS ARE RECEIVING NEW ENGINES OR VALVE STEM REPAIRS TO REMEDY. TRANSMISSION JERKS SEVERLY WHEN SHIFTING FROM REVERSE TO DRIVE. INITIALLY REPORTED 9/29/98 AT 9596 MILES AND NOT ADDRESSED BY DEALER. RECURRING PROBLEMS WITH HEADLIGHT SEALANT LEAKAGE AND WATER GETTING INTO HEADLIGHT ASSEMBLY, CAUSING HEADLIGHTS TO BE UNRELIABLE AND POTENTIAL ELECTRICAL/FIRE HAZARD. HAVE RESEARCHED VW AND LEARNED DURING INITIAL BEETLE PRODUCTION IN PUEBLA, MEXICO, THEY EXPERIENCE AN ABOMINAL 40% DEFECT RATE. FROM RESEARCH INTO OTHER CONSUMER ISSUES WITH 1998 BEETLES, I AM CERTAIN THAT VW PASSED THESE DEFECTIVE VEHICLES ON TO CONSUMERS. PLEASE CONTACT ME FOR FURTHER DETAILS. I HAVE ALSO EXPERIENCED WINDOW REGLATOR FAILURES, DEAD BATTERY, INTERIOR PIECES FALLING APART AND OTHER ISSUES. THANK YOU!*AK
COOLANT LOSS ON TWO OCCASIONS CAUSING ENGINE TO BLOW, NO WARNING UNTIL LAST MINUTE, ALL FLUIDS AND MAINTENACE DONE AND UNDER EXTENDED WARRANTY, DEALER REFUSED TO PAY FOR NEW ENGINE. *AK
WHILE DRIVING PLASTIC COVER THAT PROTECTS ENGINE/ EXHAUST SYSTEM AND PLUGS DISENGAGED FROM UNDER VEHICLE. PLEASE GIVE ANY FURTHER DETAILS.*AK
MULTIPLE PROBLEMS WITH CAR SINCE PURCHASE.
POSSIBLE ENGINE FAILURE AND MISSING OIL CAP CAUSED FIRE. YH
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .