2004 Volkswagen Beetle Owner Complaints

DRIVING MY 2004 VOLKSWAGEN BEETLE IS DANGEROUS. THE TIPTRONIC TRANSMISSION IN THE 2004 VW BEETLE IS KNOWN BY VOLKSWAGEN TO BE DEFECTIVE. AT ANY POINT THE VALVE BODY CAN FAIL, WHICH CAUSES DELAYED SHIFTING, AND HARD JERKING BETWEEN GEARS. MY 2004 BEETLE FAILS TO SHIFT WHEN ACCELERATING BETWEEN 2ND AND 3RD GEAR. THIS CAUSES THE VEHICLE TO COAST FOR SEVERAL SECONDS, SOMETIMES REQUIRING PULLING OFF THE ROAD BECAUSE OF TRAFFIC. WHEN DOWNSHIFTING IT JERKS EXTREMELY HARD. YOU GET IN, START THE ENGINE, AND RECEIVE NO WARNINGS THAT ANYTHING IS WRONG WITH THE VEHICLE. NO CHECK-ENGINE LIGHT PROVIDES ANY INDICATION THAT THE VEHICLE IS DANGEROUS. YOU DRIVE DOWN SOME CITY STREETS AND HOP ONTO THE FREEWAY TO GO TO YOUR FAVORITE GROCERY STORE. AFTER GETTING OFF THE FREEWAY THE CAR IS FULLY WARMED UP, AND AS IT DOWNSHIFTS FROM 4TH TO 3RD GEAR IT LURCHES. IT FEELS LIKE THE ENGINE IS TRYING TO JUMP OUT OF THE CAR! NO ENGINE LIGHT COMES ON. THEN YOU STOP AT THE END OF THE OFF-RAMP, AND WAIT FOR A TRAFFIC LIGHT TO TURN. AFTER TURNING THE CAR SHIFTS FROM 1ST TO 2ND GEAR. THEN IT FAILS TO SHIFT FROM 2ND TO 3RD GEAR. THE GEAR DOESN'T ENGAGE, AND THE CAR COASTS DOWN THE ROAD WITHOUT ANY POWER. DRIVERS PASSING BY ARE STARING. THE SUV BEHIND YOU IS RIGHT ON YOUR BUTT; THEY BEGIN HONKING. THERE'S NOTHING YOU CAN DO. FINALLY, AFTER 20 SECONDS OF COASTING THE CAR ENTERS 3RD GEAR WITH A GIANT LURCH. IT FEELS LIKE IT'S GOING TO EXPLODE! YOU PULL INTO THE GROCERY STORE PARKING LOT, HEART RACING, KNOWING THAT THE CAR YOU'RE DRIVING ALMOST CAUSED AN ACCIDENT THAT COULD KILL A HALF A DOZEN PEOPLE. AND YOU KNOW TO GET HOME IT'S GOING TO HAPPEN ALL OVER AGAIN. THIS PROBLEM IS REPORTED BY HUNDREDS OF OWNERS. THIS IS AN EXTREME SAFETY HAZARD. VOLKSWAGEN NEEDS TO RECALL THE AFFECTED VEHICLES AND PAY DAMAGES FOR THOSE WHOSE TRANSMISSIONS WERE DESTROYED BY THIS DEFECTIVE VALVE BODY AND TRANSMISSION.

NHTSA ID

11415125

Incident

Jun 11, 2019

Mileage

160,000 mi

AIR BAG LIGHT NEVER GOES OFF, STARTED AT 33650 MILES, RIGHT AFTER MY MOM SIGNED OVER THE CAR TO ME.

NHTSA ID

11352371

Incident

Aug 24, 2020

Mileage

33,640 mi

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. THE CONTACT STATED THAT THE AIR BAG WARNING LIGHT ILLUMINATED AND REMAINED ILLUMINATED FOR TWO MONTHS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE AIR BAG SENSOR WHICH WAS A PART OF THE DRIVER'S FRONTAL SEAT BELT SYSTEM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. A LOCAL DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS CONTACTED AND INFORMED OF THE FAILURE. THE CONTACT WAS INFORMED BY THE MANUFACTURER THAT THE PART NEEDED FOR THE REPAIR WAS ON BACK ORDER. THE APPROXIMATE FAILURE MILEAGE WAS 94,000.

NHTSA ID

11297990

Incident

Jan 8, 2020

Mileage

94,000 mi

AIR BAG LIGHTS ON AND SEEMS THE DEALER CANNOT GET PARTS TO FIX ??

NHTSA ID

11268768

Incident

Oct 10, 2019

Mileage

32,000 mi

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING 60 MPH, THE BATTERY AND ABS INDICATORS ILLUMINATED AND THE VEHICLE DOWNSHIFTED INTO FIRST GEAR. THE VEHICLE SEIZED AND WAS MOVED TO THE SIDE OF THE ROAD. THE CONTACT ATTEMPTED TO RESTART THE VEHICLE, BUT WAS UNSUCCESSFUL. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE WIRE HARNESS FAILED AND NEEDED TO BE REPLACED. THE FUSE BOX WAS REPLACED THREE TIMES, BUT THE FAILURE RECURRED. LEITH VOLKSWAGEN OF CARY (2300 AUTOPARK BLVD, CARY, NC 27511, (919) 842-5624) AND THE MANUFACTURER STATED THAT THE VIN WAS NOT INCLUDED IN A RECALL. THE FAILURE MILEAGE WAS APPROXIMATELY 157,000.

NHTSA ID

11231906

Incident

Jul 26, 2017

Mileage

157,000 mi

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING AT A SLOW RATE OF SPEED, THE CONTACT SMELLED BURNING RUBBER AND THE VEHICLE'S RADIO STOPPED WORKING. AS THE CONTACT PROCEEDED DRIVING, SEVERAL UNKNOWN WARNING INDICATORS BEGAN FLASHING. THE CONTACT STATED THAT THE VEHICLE SHUT COMPLETELY OFF. THE CONTACT WAS ABLE TO RESTART THE VEHICLE AND TOOK IT TO AN INDEPENDENT MECHANIC. THE MECHANIC WAS ABLE TO DIAGNOSE THE VEHICLE AND HAD THE FUSE BOX REPLACED, YET THE FAILURE STILL PERSISTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.

NHTSA ID

11230138

Incident

May 13, 2019

Mileage

50,000 mi

WHEN DRIVING THE CAR SHUTS OFF IN TRAFFIC IN TOWN AND ON THE HIGHWAY. 2 TIMES NO CHECK ENGINE LIGHT CAME ON. ONE TIME LIGHT CAME ON. MECHANIC IS NOT SURE WHY. I HAVE READ SEVERAL SIMILAR OCCURANCES ONLINE BY OTHER OWNERS. SOUNDS LIKE A RISK FOR FATALITY TO ME. MY DAUGHTER JUST BOUGHT THIS CAR FROM ANOTHER PARTY.

NHTSA ID

11220226

Incident

Jun 9, 2019

Mileage

148,000 mi

2004 BEETLE WITH 85,000 MILES HARD SHIFTING DOWN - IT JERKS FROM GEAR TO GEAR UNTIL IT COMES TO FULL STOP. . NOW WHILE UPSHIFTING IT COULDN'T MAKE IT OUT OF 3RD GEAR AND HAVE ALMOST BEEN REAR ENDED 3 TIMES. CAR JERKS ,SHUDDERS, LURCHES . TRANSMISSION PROBLEM IS CONSISTENT WITH LOW MILEAGE VW BEETLES

NHTSA ID

11164006

Incident

Nov 6, 2018

I BOUGHT MY VW BEETLE 2004 USED 3 MONTHS AGO. (EPC LIGHT ON, CHECK ENGINE LIGHT ON) SINCE THEN IVE HAD TO FIX THE TIMING BELT, COOLING, AND HOSES BECAUSE OF BACKFIRE. I GOT NOTIFIED THAT THERE IS A RECALL IN MY CAR, YET WENT TYPING THE VIN # IT SAYS IT NO RECALLS HAVE BEEN FOUND FOR MY CAR. I HAVE DOCUMENTATION TO SHOW THE REPAIRS AND COSTS. I'M WONDERING WHO DO I CONTACT TO DETERMINATE IF MY CAR DOES HAVE A REAL OR NOT.

NHTSA ID

11161757

Incident

Nov 1, 2018

Mileage

8 mi

THE PASSENGER FRONT SEAT HEATER WAS LEFT ON POWER LEVEL 3 WITH A BAG OF CLOTHES IN THE SEAT. AN ODOR WAS DETECTED AND UPON MOVING THE BAG, AN APPROXIMATELY 6' X 10' BURN WAS DISCOVERED ON LOWER PORTION OF THE SEAT BACK.

NHTSA ID

11151369

Incident

Nov 13, 2018

Mileage

150,000 mi

I BOUGHT THE NEW BEETLE NOT EVEN A MONTH AND I NOTICED A JERKING IN THE TRANSMISSION. I FOUND OUT USING SPECIALIZED WEBSITES FOR ENTHUSIASTS THAT VOLKSWAGEN ISSUE LETTERS TO OWNERS OF NEW BEETLES IN 2010 INFORMING THAT TONS OF OWNERS COMPLAINED ABOUT THE HARD SHIFT THEY WERE EXPERIENCING IN THE AUTOMATIC TRANSMISSION OFTHEIR NEW BEETLE. VOKSWAGEN OFFERED TO EXTEND THE WARRANTY ON THE TRANSMISSION VALVE BODY. THE MODELS AFFECTED SPANS FROM 2003 TO 2008. IN OTHER WORDS, VOLKS SOLD FAULTY CARS WITHING THIS TIME RANGE AND ONLY RECOGNIZED LATER IN 2010 ABOUT THE ISSUE. HOWEVER, THE VALVE BODY FAILURE IN THE TRANSMISSION IS ACROSS THE BOARD AND A RECALL SHOULD HAVE BEEN ISSUED FOR THE RANGE OF 2003-2008. THE COMPONENT WAS DESIGNED TO FAIL BY DESIGN. NOT EVEN THE REPLACEMENT WOULD FIX IT BECAUSE IT WOULD HAPPEN AGAIN. IMAGINE THE DANGER WHEN THERE IS A HARD-SHIFT AND THE CAR STARTS TO JERK AND CHANGING GEARS ERRATICALLY ? IMAGINE THIS HAPPENING ON I95 OR ANY OTHER HIGHWAY. VW JUST EXTENDED THE WARRANTY BUT A RECALL IS NEEDED HERE. I CALLED VW AND THEY ARE REFUSING TO FIX IT SAYING IT IS AN OLD CAR AND WARRANTY IS EXPIRED, BUT THE TRUTH IS SINCE 2003 THE HARD SHIFT CONDITION EXISTED. IT TAKES TIME FOR THE VALVE BODY TO FAIL BUT IT WILL FAIL. I HAVE OTHER CARS, BUT WHEN I NOTICED THE JERK I INVESTIGATED. I ATTACHED THE LETTER THAT I OBTAINED FROM THE NEW BEETLE.ORG SITE AND THERE THERE IS A DETAIL EXPLANATION HOW THE AUTOMATIC TRANSMISSION WILL FAIL DUE TO THE DESIGN

NHTSA ID

11093711

Incident

Apr 25, 2018

FEUL LEAK, REAR PASSANGER SIDE RIGHT. SAME SIDE THAT THE FUEL FILL IS ON.

NHTSA ID

11083941

Incident

Apr 7, 2018

Mileage

79,000 mi

THE FUSE BOX IS BURNING BECAUSE SOME CABLES ARE TOO SMALL AND ACCORDING TO THE MECHANICS, IT IS SOMETHING EXTREMELY COMMON BUT ACCORDING TO ME, IT IS NOT SUPPOSED TO HAPPEN.

NHTSA ID

11066820

Incident

Jun 8, 2016

Mileage

350 mi

CONTINUED HEADLAMP FAILURE RE: HEADLAMP COVER GLASS / LEXAN COMES OFF AND FLYS OFF OF CAR. SEVERAL OWNERS REPORT SAME PROBLEM. CREATES HAZERDOUS DEBRIS WHEN IT HAPPENS ON HIGHWAY AND ALSO EXPOSES HEADLAMP LIGHTS DIRECTLY TO WEATHER AND CAUSES FAILURE.

NHTSA ID

11043985

Incident

Nov 3, 2017

Mileage

164,500 mi

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE FELT AS IF IT WERE IN NEUTRAL. THE CONTACT COASTED THE VEHICLE TO THE SIDE OF THE ROAD, PLACED THE GEAR SHIFTER IN PARK AND THEN BACK INTO DRIVE, AND WAS ABLE TO RESUME DRIVING. THE CONTACT STATED THAT SHE HAD TO REPEAT THE SAME PROCEDURE FIVE TIMES UNTIL SHE REACHED HER DESTINATION. THERE WERE NO WARNING INDICATORS ILLUMINATED. THE VEHICLE WAS TAKEN TO PERRYSBURG AUTO MALL (26875 N DIXIE HWY, PERRYSBURG, OH 43551, PHONE NUMBER: (419) 874-4331) WHERE IT WAS DIAGNOSED THAT THE TRANSMISSION FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.

NHTSA ID

11031424

Incident

Oct 2, 2017

Mileage

63,000 mi

VW CHECK ENGINE LIGHT ON, OBD SENSOR PORT NOT READING, BATTERY LIGHT CAME ON, AND ABS LIGHT CAME ON, NOW RADIO IS GOING ON AND OFF. STARTED YESTERDAY MORNING,WHILE DRIVING TO WORK THE ABS STARTED AFTER WORK ON THE WAY HOME.

NHTSA ID

11014835

Incident

Aug 11, 2017

Mileage

5 mi

THE GEARBOX SLIPS, STUTTERS AND JERKS . AND WILL SLIP OUT OF GEAR AND NOT GO BACK IN GEAR UNTIL ENGINE IS RESTARTED. THIS HAPPENS WHEN STARTING TO MOVE FROM A STOP.

NHTSA ID

10986055

Incident

Dec 22, 2016

Mileage

130,000 mi

WINDOW REGULATORS ARE EASY TO BREAK.

NHTSA ID

10935569

Incident

Dec 13, 2016

Mileage

135,400 mi

TRANSMISSION LOCKS UP, NOISY UPSHIFT AND DOWNSHIFTS. WHILE DRIVING UNPREDICTABLE GEAR SHIFTS.

NHTSA ID

10926488

Incident

Nov 12, 2016

Mileage

85,000 mi

AIR BAG LIGHT CAME ON LAST YEAR, RESOLVED. BACK ON, I SEE OLD RECALL? WHAT TO DO?

NHTSA ID

10898011

Incident

Jul 1, 2016

Mileage

60,000 mi

MY TRANSMISSION WENT OUT ALL AT ONCE MY AIRBAG/SEATBEILT LIGHT ON ALL THE TIME

NHTSA ID

10889201

Incident

Dec 27, 2015

Mileage

118,000 mi

THE FIRST TIME I ROLLED WINDOWS DOWN IN MY DRIVEWAY SO THAT I COULD TAKE TOP DOWN. THEY WOULD NOT ROLL UP PROPERLY TO MAKE A CONNECTION TO THE TOP CONVERTIBLE OF THE CAR. SO THE CAR WAS NOT WEATHER SAFE.

NHTSA ID

10882429

Incident

May 19, 2004

Mileage

15 mi

TRANSMISSION SLIPS, JERKS , DOWNSHIFTS , VEHICLE BECOMES DISABLED ON ROADWAY, DANGER TO DRIVER, PEDESTRIANS AND OTHER VEHICLES ON THE ROADWAYS. THERE IS A CLASS ACTION SUIT IN LOUISIANA REGARDING THIS PROBLEM . THIS PROBLEM HAPPENS WHILE VEHICLE IS IN MOTION 10-15 MINUTES AFTER IT IS IN MOTION .

NHTSA ID

10882136

Incident

Aug 15, 2015

Mileage

90,000 mi

TL* THE CONTACT OWNS A 2004 VOLKSWAGEN BEETLE. WHILE DRIVING AT ANY SPEED, WHEN THE VEHICLE SLOWED DOWN TO APPROACH A STOP SIGN OR TRAFFIC LIGHT, IT WOULD DOWNSHIFT INDEPENDENTLY. THE VEHICLE BECAME INOPERABLE AND HAD TO BE PULLED OVER, TURNED OFF, AND RESTARTED. THE MECHANIC STATED THAT THE TRANSMISSION NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT NOTIFIED AND THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 90,000.

NHTSA ID

10882120

Incident

Jul 15, 2015

Mileage

90,000 mi

1. AIR BAG: THE AIR BAG INDICATOR LIGHT IS ILLUMINATING. 2. SUNROOF DRAIN SYSTEM CLOGGED: THERE IS LEAKAGE THROUGH THE SUNROOF OF THE PASSENGER SIDE. ALL RAIN WATER IS COMING IN FROM THE PASSENGER DOOR. AFTER ABOUT 2 WEEKS OF THUNDER STORMS THE CAR HAS WATER ALL OVER THE INSIDE AND THE CEILING AND SMELLS BAD. (AS SOON AS I FOUND OUT THE SUNROOF LEAKAGE PROBLEM OF THIS CAR, I FOUND THAT HE U.S. COURT OF APPEALS FOR THE THIRD CIRCUIT HAS APPROVED A $69 MILLION SETTLEMENT STEMMING FROM A CLASS-ACTION LAWSUIT THAT STARTED IN 2007 OVER LEAKING SUNROOFS. HTTP://WWW.CARCOMPLAINTS.COM/NEWS/2014/VOLKSWAGEN-SETTLES-LAWSUIT-LEAKING-SUNROOFS.SHTML)

NHTSA ID

10876204

Incident

Jun 4, 2016

Mileage

122,000 mi