2001 Volkswagen Eurovan Problems

RELIABLE INTERNET AUTOMOTIVE SOURCES HAVE LISTED EXCESSIVE WEAR OF THE INTERMEDIATE (BALANCE SHAFT) VALVE TIMING CHAIN SPROCKET IN EARLY 2001 24-VALVE VR6 ENGINES. THE INADEQUATELY HARDENED SPROCKET TEETH WILL VEER EXCESSIVELY, SUCH THAT CHAIN "JUMPEDS" A TOOTH AND SINCE THE VR6 IS AN "INTERFERENCE" VALVE-TRAIN ENGINE, THE ENGINE WILL ESSENTIALLY BE IRREPARABLY DAMAGED. *TR

ENGINE COOLING FAN BLADE FAILURE. THE LARGER OF THE 2 FAN BLADE WHEELS HAS A LARGE MISSING PIECE WHICH HAS SOMEHOW DISINTEGRATED WITHOUT ANY REASONABLE EXPLANATION. I UNDERSTAND THERE WAS AN INVESTIGATION OF THE EUROVAN ENGINE COOLING FAN BLADE, HOWEVER A RECALL HAS NOT BEEN ISSUED, WHILE THERE WAS A RECALL ON THE RIALTA, WHICH USES THE SAME FAN AS THE EUROVAN. *TR

MY BRAKES ARE SOFT AND FAIL TO KEEP THE CAR AT REST. THE PROBLEM STARTED ON 09/29/2004. SINCE THEN THE VW DEALER WAS NOT ABLE TO FIND THE PROBLEM EVEN THOUGH MANY PARTS WERE REPLACED. *JB

I PURCHASED, NEW, A 2001 VW EUROVAN WINNEBAGO CAMPER. IN 31,000 MILES, THE VEHICLE IS NOW ON ITS' THIRD SET OF BRAKES. MY LAST VEHICLE, A 1992 MAZDA NAVAJO; I FINALLY REPLACED BRAKES AT APPROXIMATELY 72,000 MILES. MY DRIVING IS NOT AN ISSUE WITH THE VW. EACH SET OF CAMPER BRAKES COSTS, RIGHT AT $1,500.00. VW PICKED-UP THE COST OF BRAKE SET #2 AT 17,000 MILES. AN AWA, AS THEY ARE ONLY WARRANTEED FOR 12,000 MILES. RIDICULOUS, TO BE SURE. WE HAVE ABSOLUTELY NO WARNING THAT THE BRAKES ARE "GOING OUT". ONCE THE WARNING LIGHT COMES ON - YOU MUST REPLACE THE ENTIRE BRAKE SYSTEM, NOT JUST PADS. AT 3 SETS IN 31,000 MILES; BRAKES ALONE ARE COSTING $150.00 FOR EVERY 1,000 MILES DRIVEN. ALSO, THIS VEHICLE HAS GONE THROUGH ELEVEN TIRES IN THIS SAME TIME FRAME, DUE TO INAPPROPRIATE SHOCKS (NOT HEAVY DUTY), AND THE COLLAPSE OF A MAJOR SPRING WHICH SUPPORTS THE CAMPER IN THE REAR OF THE VEHICLE ON THE LEFT SIDE. I HAVE SPOKEN TO MANY OTHER VW CAMPER OWNERS WITH 2001 MODELS AND THEY ARE EXPERIENCING THE SAME THINGS WITH BRAKES AND TIRES. VW AND WINNEBAGO DO NOT CARE AND WILL NOT LOWER THE PRICE OF THEIR BRAKE SYSTEMS, NOR EVEN PROVIDE THE PART NUMBERS FOR ANY HEAVY DUTY SHOCKS THAT CAN BE PUT ON THIS VEHICLE, NOT ABSORB THE COSTS OF THE VERY EXPENSIVE AND UNIQUE TIRE THAT MUST BE PUT ON THIS VEHICLE DUE TO THE LOAD BEARING OF THE CAMPER PORTION. NO BRAKES SHOULD COST THIS MUCH, NO VEHICLE SHOULD GO THROUGH 11 TIRES IN 31,000 MILES. PLEASE HELP.*AK

DT: CONTACT STATES VEHICLE WILL NOT START. HOWEVER, AFTER WRIGGLING THE IGNITION SWITCH THE VEHICLE WILL START. THE SERVICE DEALER STATED IT WOULD BE AN EXPENSIVE REPAIR, THE WRIGGLING OF THE IGNITION MIGHTL RESOLVE THE PROBLEM.*AK

VEHICLE EXPERIENCED ELECTRICAL WIRING PROBLEMS IN FRONT WINDOWS ON BOTH SIDES. WHEN PRESSING THE BUTTON DOWN TO LOWER THE WINDOW SMOKE CAME OUT OF THE DOOR. CONSUMER TOOK VEHICLE TO A LOCAL REPAIR SHOP, AND REPLACED THE WIRING WHICH CONTROLLED BOTH FRONT WINDOWS. ALSO, THE WIRING BURNED DOWN TO THE CONTROL PANEL.*AK.....CONSUMER PAID $491,98 FOR REPAIRS. *AK

TL*- THE CONTACT STATED THAT WHILE HAVING THE WHEELS ON THE 2001 VOLKSWAGEN EURO VAN WITH14000 FAILURE MILEAGE INSPECTED DUE TO CONSTANT AIR LEAKAGE THE MECHANIC DISCOVERED STRESS CRACKS IN THE TWO REAR WHEELS. THE CURRENT MILEAGE WAS 16100.*AK

WHILE TRAVELING FORWARD AT ABOUT 2 MPH, THE PROPANE GAS PRESSURE REGULATOR BRACKET CAUGHT A SMALL RISE ON A PUBLIC STREET. THE GAS PRESSURE REGULATOR BRACKET BROKE FREE OF THE VEHICLE AND WAS FORCED BACKWARD INTO THE PROPANE STORAGE TANK. THE PROPANE STORAGE TANK RUPTURED AND IMMEDIATELY EXHAUSTED ABOUT 15 POUNDS OF PROPANE. THE PROPANE TANK OBSTRUCTS THE DESIGNATED JACKING POINT ON THE REAR DRIVER SIDE OF THE VEHICLE. I PLACED THE SUPPLIED JACK AS CLOSE TO THE JACKING POINT AS POSSIBLE AND PROCEEDED TO JACK UP THE VEHICLE. THE VEHICLE COLLAPSED ON THE JACK CAUSING VEHICLE BODY DAMAGE. I HAD JUST REMOVED MY HAND FROM UNDER THE VEHICLE WHILE RETRIEVING THE PRESSURE REGULATOR BRACKET. UPON INVESTIGATION I DISCOVERED THAT WINNEBAGO HAD FAILED TO SUPPLY A REPLACEMENT JACK AS DICTATED IN THE VOLKSWAGON OWNERS MANUAL.

I PURCHASED, NEW, A 2001 VW EUROVAN WINNEBAGO CAMPER. IN 31,000 MILES, THE VEHICLE IS NOW ON ITS' THIRD SET OF BRAKES. MY LAST VEHICLE, A 1992 MAZDA NAVAJO; I FINALLY REPLACED BRAKES AT APPROXIMATELY 72,000 MILES. MY DRIVING IS NOT AN ISSUE WITH THE VW. EACH SET OF CAMPER BRAKES COSTS, RIGHT AT $1,500.00. VW PICKED-UP THE COST OF BRAKE SET #2 AT 17,000 MILES. AN AWA, AS THEY ARE ONLY WARRANTEED FOR 12,000 MILES. RIDICULOUS, TO BE SURE. WE HAVE ABSOLUTELY NO WARNING THAT THE BRAKES ARE "GOING OUT". ONCE THE WARNING LIGHT COMES ON - YOU MUST REPLACE THE ENTIRE BRAKE SYSTEM, NOT JUST PADS. AT 3 SETS IN 31,000 MILES; BRAKES ALONE ARE COSTING $150.00 FOR EVERY 1,000 MILES DRIVEN. ALSO, THIS VEHICLE HAS GONE THROUGH ELEVEN TIRES IN THIS SAME TIME FRAME, DUE TO INAPPROPRIATE SHOCKS (NOT HEAVY DUTY), AND THE COLLAPSE OF A MAJOR SPRING WHICH SUPPORTS THE CAMPER IN THE REAR OF THE VEHICLE ON THE LEFT SIDE. I HAVE SPOKEN TO MANY OTHER VW CAMPER OWNERS WITH 2001 MODELS AND THEY ARE EXPERIENCING THE SAME THINGS WITH BRAKES AND TIRES. VW AND WINNEBAGO DO NOT CARE AND WILL NOT LOWER THE PRICE OF THEIR BRAKE SYSTEMS, NOR EVEN PROVIDE THE PART NUMBERS FOR ANY HEAVY DUTY SHOCKS THAT CAN BE PUT ON THIS VEHICLE, NOT ABSORB THE COSTS OF THE VERY EXPENSIVE AND UNIQUE TIRE THAT MUST BE PUT ON THIS VEHICLE DUE TO THE LOAD BEARING OF THE CAMPER PORTION. NO BRAKES SHOULD COST THIS MUCH, NO VEHICLE SHOULD GO THROUGH 11 TIRES IN 31,000 MILES. PLEASE HELP.*AK

DIOSCOVERED ONE OF FOUR BOLTS HOLDING THE REAR ANTI-SWAY BAR ON MY 2001 VW EUROVAN WAS LOOSE AND REQUIRED OVER TWO FULL TURNS BEFORE IT WAS TIGHTENED TO TORQUE SPECIFICATIONS.

DRIVER SEAT HEATER CAUGHT FIRE AND MELTED HOLE IN SEAT. THIS IS A VERY DANGEROUS AND SHOULD BE A RECALL ITEM. *TR

VEHICLE EXPERIENCED ELECTRICAL WIRING PROBLEMS IN FRONT WINDOWS ON BOTH SIDES. WHEN PRESSING THE BUTTON DOWN TO LOWER THE WINDOW SMOKE CAME OUT OF THE DOOR. CONSUMER TOOK VEHICLE TO A LOCAL REPAIR SHOP, AND REPLACED THE WIRING WHICH CONTROLLED BOTH FRONT WINDOWS. ALSO, THE WIRING BURNED DOWN TO THE CONTROL PANEL.*AK.....CONSUMER PAID $491,98 FOR REPAIRS. *AK

BRACKET ON VEHICLE THAT HOLDS PROPANE TANK GOT CAUGHT AND ALMOST RUPTURED THAT TANK. DESIGN IS POOR ON VEHICLE FOR THAT PART. CONTACTED DEALER, AND THE DEALER WASA NOT WILLING TO DO ANYTHING.*AK

AIR CONDITIONER COMPRESSOR FAILURE AT JUST OVER 25,000 MILES. OTHER VOLKSWAGEN EUROVAN DRIVERS HAVE REPORTED SIMILAR FAILURES, INCLUDING SEIZING OF THE COMPRESSOR, IMMEDIATE LOSS OF THE COMPRESSOR DRIVE BELT, AND A RESULTING LOSS OF POWER STEERING CONTROL, WHICH COULD RESULT IN LOSS OF VEHICLE CONTROL.*AK

I PURCHASED, NEW, A 2001 VW EUROVAN WINNEBAGO CAMPER. IN 31,000 MILES, THE VEHICLE IS NOW ON ITS' THIRD SET OF BRAKES. MY LAST VEHICLE, A 1992 MAZDA NAVAJO; I FINALLY REPLACED BRAKES AT APPROXIMATELY 72,000 MILES. MY DRIVING IS NOT AN ISSUE WITH THE VW. EACH SET OF CAMPER BRAKES COSTS, RIGHT AT $1,500.00. VW PICKED-UP THE COST OF BRAKE SET #2 AT 17,000 MILES. AN AWA, AS THEY ARE ONLY WARRANTEED FOR 12,000 MILES. RIDICULOUS, TO BE SURE. WE HAVE ABSOLUTELY NO WARNING THAT THE BRAKES ARE "GOING OUT". ONCE THE WARNING LIGHT COMES ON - YOU MUST REPLACE THE ENTIRE BRAKE SYSTEM, NOT JUST PADS. AT 3 SETS IN 31,000 MILES; BRAKES ALONE ARE COSTING $150.00 FOR EVERY 1,000 MILES DRIVEN. ALSO, THIS VEHICLE HAS GONE THROUGH ELEVEN TIRES IN THIS SAME TIME FRAME, DUE TO INAPPROPRIATE SHOCKS (NOT HEAVY DUTY), AND THE COLLAPSE OF A MAJOR SPRING WHICH SUPPORTS THE CAMPER IN THE REAR OF THE VEHICLE ON THE LEFT SIDE. I HAVE SPOKEN TO MANY OTHER VW CAMPER OWNERS WITH 2001 MODELS AND THEY ARE EXPERIENCING THE SAME THINGS WITH BRAKES AND TIRES. VW AND WINNEBAGO DO NOT CARE AND WILL NOT LOWER THE PRICE OF THEIR BRAKE SYSTEMS, NOR EVEN PROVIDE THE PART NUMBERS FOR ANY HEAVY DUTY SHOCKS THAT CAN BE PUT ON THIS VEHICLE, NOT ABSORB THE COSTS OF THE VERY EXPENSIVE AND UNIQUE TIRE THAT MUST BE PUT ON THIS VEHICLE DUE TO THE LOAD BEARING OF THE CAMPER PORTION. NO BRAKES SHOULD COST THIS MUCH, NO VEHICLE SHOULD GO THROUGH 11 TIRES IN 31,000 MILES. PLEASE HELP.*AK

WHEN ATTEMPTING TO PULL OFF FROM A LIGHT VEHICLE HAD A DELAY IN ACCELERATION. DRIVER HAD TO PUSH GAS PEDAL ALMOST TO THE FLOOR. THEN VEHICLE WOULD JUMP FORWARD. *AK *SC

DT*: THE CONTACT STATED WHILE DRIVING SMOKE WAS SMELLED. THE SMOKE WAS DISCOVERED COMING FROM THE FRONT PASSENGER SEAT. THE VEHICLE WAS TAKEN TO THE DEALERSHIP FOR INSPECTION. THEY DETERMINED THE SEAT HEATER BURNED THE SEAT. THE HEATER AND SEAT WERE REPLACED. AFTER PICKING UP THE VEHICLE FROM THE DEALERSHIP, WHILE DRIVING HOME THE ENGINE BLEW AND THE VEHICLE WAS TAKEN BACK TO THE DEALERSHIP AGAIN. THE DEALERSHIP INSPECTED AND DETERMINED THE ENGINE NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOTIFIED; HOWEVER NO ADDITIONAL REPAIRS WERE MADE.

THE ENGINE FELL FROM THE VEHICLE DUE TO A MISSING BOLT, ALSO THE TRANSMISSION WAS INOPERATIVE. *JB THE CONSUMER FOUND THAT THE ENGINE AND THE TRANSMISSION WAS REBUILT PRIOR TO PURCHASE. THE ENGINE LIGHT HAD COME ON, THE CONSUMER'S DAUGHTER HEARD A LOUD RATTLE AND VIEWED SMOKE COMING FROM THE ENGINE AREA. ON ANOTHER OCCASION WHEN THE CONSUMER HAD COME TO AN INTERSECTION, WHEN ACCELERATED, THE VEHICLE HAD MADE A NOISE THEN WOULD NOT MOVE. THE BOLTS HAD SPRAYED OVER THE ROAD. SCC