RoadVitals

2004 Volkswagen Eurovan Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest Mar 7, 2025
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2004 Volkswagen Eurovan, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Tires & wheels1100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Tires & wheels

Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.

1
report

From owner reports, verbatim

205/65R16C 107/105T Achillies Mulitvan Both front tires on vehicle failed along the entire inside sidewall approximately 1” from the rim. They cracked all the way through the rubber about 1/4” wide exposing the sidewall ply's. The tires were purchased in March of 2023 and have roughly 6000 miles on them. The outside sidewall was in perfect condition. The cracks were observed during a routine pre trip inspection. The cracks are so deep that the tires sidewall could blow out catastrophically. The fact that both inside sidewalls were compromised and not readily visible made this especially dangerous.

NHTSA ID 11647042 · filed Mar 7, 2025

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .