2016 Volkswagen Golf Sportwagen Owner Complaints

SRS/airbag warning light illuminated. A diagnostic scan (VCDS) confirmed stored fault codes for both front airbag crash sensors: driver's side 'short to ground' and passenger's side 'open or short to plus.' Upon further inspection, water was found pooled at the airbag control module connector, located under the center dash. The AC condensate drain line is routed directly above this module, and appears to be the source of the water intrusion — water drained from the connector itself when disconnected, and dampness was present at both the upper and lower AC drain hose connections near the module. After drying and reconnecting all components, an attempt was made to clear the fault codes via VCDS. The airbag module returned a 'not acknowledged' response to the clear command, indicating the fault condition and/or internal component damage may still be present. This vehicle's VIN was checked against active airbag recalls for this model year and found not to be included. However, given the safety-critical nature of the SRS system and the apparent design proximity of the AC drain to the airbag module connector, this may represent a broader risk for this chassis. Multiple independent repair shops declined to service this issue, citing liability concerns related to airbag system water intrusion. Volkswagen customer service denied a goodwill repair request, citing vehicle age/mileage without reviewing supporting documentation (VCDS diagnostic report and photos).

NHTSA ID

11754963

Incident

Jul 28, 2026

Junction between thermostat and water pump failed leading to total loss of coolant. At the time I was driving north on I-75 in heavy morning traffic at 65 MPH. I was able to steer the vehicle off the road without hitting anyone or coming to a complete stop. Had the vehicle towed to Jim Ellis VW of Kennesaw where they diagnosed the problem and replaced the water pump. The car had 18,762 miles on it at the time. Mechanic stated that the problem was oil from cam covers leaking onto water pump and was frequently seen. Vehicle had low coolant warning lights twice and I added several ounces of distilled water each time. Car had an engine warning light and was being taken to dealer for service that day. When the incident happened, there was an audible alarm for loss of coolant and a flashing yellow light on the dashboard. The car had been serviced and inspected at the dealership annually, there had been no reports of leaking oil from cam covers. There was no indication the water pump would catastrophically fail. The waterpump should not fail with this few miles on it. .

NHTSA ID

11702007

Incident

Oct 8, 2025

The fuel pump on my 2016 Volkswagen Golf SportWagen failed approximately three months after a safety recall repair for the suction jet pump (recall 20Y6). My independent mechanic explained that failure of the suction jet pump can cause fuel leakage or vapor transfer into the EVAP system, which may create pressure or vacuum imbalance inside the fuel tank. This can potentially damage other fuel-system components, including the fuel pump. My vehicle had no prior fuel-system issues. After the recall repair, the vehicle began experiencing symptoms consistent with fuel delivery problems, and the fuel pump ultimately failed. The mechanic who performed the repair noted that the failure was “highly likely related” to the suction-jet-pump defect because of the short time between the recall repair and the component failure. Volkswagen’s customer-service team stated that the fuel pump and suction jet pump are “unrelated,” but did not provide a technical explanation for that conclusion. Because both components interact within the sealed fuel/EVAP system, I am concerned that the recall defect or repair may have contributed to the fuel-pump failure. This problem may indicate a pattern of post-recall fuel-system failures involving suction-jet-pump malfunction, tank pressure changes, or collateral damage to in-tank components. I am submitting this report so NHTSA can review whether similar issues are occurring in other vehicles.

NHTSA ID

11699966

Incident

Oct 8, 2025

Component: Sunroof / Roof Assembly - Water Ingress Make / Model / Year: 2016 Volkswagen Golf SportWagen VIN: [XXX] Mileage: ~40,000 Sunroof leaks water while closed and glass intact. First replacement frame arrived damaged. Repair extended into second week. Known manufacturer defect (VW bulletin MC-10241196-0001). Volkswagen denied reimbursement based on time expiration despite incredibly low mileage ~40,000. Effect: Interior damage to headliner/carpets, possible electrical damage, disruption of daily use. Requested Action: Document for safety/recall investigation; use data to support future recall or enforcement action. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11692002

Incident

May 30, 2025

My car started smelling like gas 10 days ago. There was no visible leak. We took it to the shop still can’t figure out the issues. Took it to pick up my son from school, it started leaking fuel (I had 1/4 of a tank left). I turned off the car and it stopped leaking fuel. Needing a fix quick, I then drove 4 miles to get to the shop. Before I started driving I checked and it said I had enough gas to drive 15 miles. However, while at a stop light, the car shuddered and completely died. We then had it towed to the shop and hour away. The dealership had had it since then and found that it was related to the fuel pump suction recall. However, because the problem has gotten so bad, I now need a new fuel tank. Because it will in fact continue to keep leaking fuel and no matter how much gas you put it will just leak out. This is a safety hazard not only for me as a driver but also to other drivers. After diagnosing the problem, the dealership called VW corporate to inquire whether they will cover the fix since the recall was what caused the issue. 10 days later, VW is still looking into it, and I’ve now spent over $1500 on a rental car and towing fees. This car was completely unsafe to drive. And it is completely irresponsible for VW to allow customers to drive an unsafe vehicle and make us pay for repairs for issues that we didn’t cause.

NHTSA ID

11665944

Incident

May 2, 2025

VW USA is offering no help in getting our recall work done. Their only suggestion is for us to work with our shipper. Our car is located in Italy because we are an active duty family stationed under orders at naval air station Sigonella. Our shipper has contacted VW Italy, and they refuse to help. The shipper also notes that they can’t ship the car anywhere anyways because the recall has to do with the fuel system. In effect, our car is now trapped in Italy, unable to be shipped off the continent. Perhaps NHTSA could persuade VW USA to perform our recall work here in Italy?

NHTSA ID

11615900

Incident

Jul 31, 2024

See attached document for complaint.

NHTSA ID

11610141

Incident

Aug 2, 2024

Despite settling a class action lawsuit re: moonroof leakage, VW refuses to cover the same repair for my VW Golf Sportwagen. I have the same issue but could not participate in the class action suit due to mileage. I routinely have to bail 1/2 - 1 gallon of water out the spare tire area if its been raining. Water now also collects in the footwell behind the driver's seat/in front of my child's seat. The bolts affixing the seatbelts to the floor are rusted and there is mold under the carpet. The car now has electrical issues, including the alarm no longer sounding when I am reversing and someone is approaching in my blind spot. In addition, when the weather has been wet, the back up camera does not work and, mid trip, the car alarms sound, indicating the car must be serviced and the brakes and airbags are not working. These problems disappear after a few days of dry weather.

NHTSA ID

11588747

Incident

May 14, 2024

It has been 3 months since the issue below was reported (per NHTSA) and no repair is available. I called and asked what I can do in the meantime to ensure safety of me and my 6 year old and was not provided with any information. Feb 14,2024 Manufacturer Recall Number20UF NHTSA Recall Number24V110 Recall StatusRecall Incomplete, remedy not yet available Summary The suction jet pump inside the fuel tank is designed to purge fuel from the Evaporative Emissions (EVAP) system. If a specific seal inside an affected suction jet pump fails, the fuel may flow directly into the EVAP system. If this happens, fuel could accumulate in the EVAP system and may leak through the charcoal canister filter element. Leaking fuel, in the presence of an ignition source, may result in a fire. Safety Risk Leaking fuel, in the presence of an ignition source, may result in a fire. Remedy REPAIR NOT YET AVAILABLE Manufacturer's Notes If you should have any questions, please contact Volkswagen using your preferred method of communication at www.vw.com/contact or by calling 800-893-5298.

NHTSA ID

11588744

Incident

May 14, 2024

Performed NH Safety Inspection. Found upon Inspection Left Rear, Driver Side, Coil Spring has failed. Broken. This will make over Ten VW or Audi vehicles we have seen in the last year with this problem.

NHTSA ID

11578205

Incident

Mar 19, 2024

Clockspring failure. VW does not cover this critical safety part under warranty. Air bag is non functional (air bag light on) horn is non functional. Other controls on steering wheel not functional.

NHTSA ID

11576762

Incident

Mar 1, 2024

The contact owns a 2016 Volkswagen Golf Sportwagen. The contact stated while driving at high speeds, the vehicle started to shake abnormally. No warning lights were illuminated. The vehicle was taken to an auto body shop where it was diagnosed and determined that the rear axle coil springs had fractured and needed to be replaced. The vehicle was not repaired. The dealer was not notified of the failure. The manufacturer was not notified of the failure. The failure mileage was approximately 135,000.

NHTSA ID

11547064

Incident

Aug 28, 2023

Mileage

135,000 mi

The fuel system is completely shot, with fuel leaking from the gas tank after a ride once and pressure building up in the gas tank. Gas pumps click off after only putting one to two gallons in the tank, despite the tank being nearly empty. Mechanic replaced Evap canister and fuel suction pump, seemingly solving the problem temporarily only for them to resurface. Fuel leaking from the tank while driving severely risks my safety, as it is possible that pressure could cause the fuel to leak onto the engine, thus causing rapid combustion of the vehicle. The dealership has not assessed the problem, only a qualified mechanic has. It has not been inspected by manufacturer, police, insurance representatives, but has been inspected by a mechanic. No warning lights or messages have appeared in relation to this problem.

NHTSA ID

11538456

Incident

Aug 1, 2023

The rear coil spring fractured and caused a suspension issue. This is the same issue as reported in NHTSA campaign number: 19V188000 covering the same vehicles built a few months after mine. The vehcile is being repaired now and the issue has been confirmed. The component has been inspected by a service technician and the issue has been confirmed. Parts have been retained for evidence. There were no warnings, messages or symptoms. VW has been notified, but confirmed this is not their issue to fix. This issue should result in an extended recall to cover the same vehcile, just earlier models, so there are no resulting accidents, injuries, or deaths.

NHTSA ID

11532824

Incident

Jul 13, 2023

Car loses power due to clogged wastegate actuator and EPC light turns on and off. This has been confirmed by 2 different service centers. I have seen several cases of people saying they had the same problem which requires you to replace the entire turbo, which my car only has 67,000 miles. I have a 16 year old son who will drive my car and this could cause him an accident if he is not able to accelerate. This is clearly a faulty part as they've discontinued using the model of the original turbo.

NHTSA ID

11527996

Incident

Mar 1, 2023

May 27 and May 28: The car turned on the EPC and check engine lights while on parking mode and on. Started to loose power and didnt want to start again. Later on, the lights turned off and it started again. While trying to fill the fuel tank at the gasoline station it stopped and it was only half tank.(The system didnt allowed to continue). While driving in the highway, started to loose power and a strong smell of fuel was inside the car so the driver had to open all the windows to avoid an intoxication with emissions(as it seemed to be). When the driver got to the destination in the highway, near San Juan, the smell of fuel was so strong that had to turn off the car and call a tow truck because the return travel would be long and the smell of fuel was stronger… it seemed to be spilling fuel and it was not safe to drive the car back home. Tow truck carried the car home because the dealer was closed on Sunday. On monday 29, the car was towed again but from home to the Flagship dealer in Ponce, PR. In the dealer they say it doesnt “have anything” . It seems they didnt care about the hazzards being discussed. The dealer returned our car and insisted there wasnt a recall or issue to attend. As soon as the dealer returned the car we drove home and the fuel odor or emissions were perceived inmediately inside the car. The car was stopped at home and a fuel leak was visible on the road. We need help inmediately. It is a matter of safety and risks. Please advice us and help with this issue. It is my only car.

NHTSA ID

11525519

Incident

May 28, 2023

The EPC light has been continuously coming on for almost a year. It has been taken to the dealership 5 times and they cannot fix it or find the cause of it. At times when driving it enters "limp mode". Other times it has acted like it was overheating. And twice it has completely shut down. The vehicle is now out of warranty and no fix has been put in place. The EPC light will still randomly come on. VW has not addressed or come up with cause for this very common issue on their vehicles.

NHTSA ID

11523217

Incident

May 14, 2023

Both rear coil springs broken

NHTSA ID

11518602

Incident

Apr 24, 2023

My driver seat belt comes unbuckled when i'm driving. It's intermittent and random, and i'm very careful to lock in the belt and i pull on it before i start driving to make sure it's locked in, and it still comes undone. I then have to relock it while i'm driving, which is distracting, as well as worrisome that i am without a seatbelt until i can lock it again, especially if i'm on the freeway. I've taken it to my mechanic who drove the car and said the same thing happened to him several times while he was driving.

NHTSA ID

11509816

Incident

Mar 2, 2023

The contact owns a 2016 Volkswagen Golf Sportwagen. The contact received notification of NHTSA Campaign Number: 22V543000 (Air Bags) however, the part to do the recall repair was not yet available. The contact stated that the manufacturer had exceeded a reasonable amount of time for the recall repair. The dealer was not made aware of the issue. The manufacturer was made aware of the issue and confirmed that parts were not yet available. The manufacturer advised the contact to avoid using the front passenger’s side seat. The contact had not experienced a failure. VIN tool confirms parts not available.

NHTSA ID

11499505

Incident

Sep 1, 2022

In late summer (August 2022) I started seeing a warning but it would disappear so fast. Now it's popping up more: Yellow triangle appears. Engine is giving code# B116229 - "Selector lever park position lock switch Implausible signal" (mileage 104814 km). I originally received a recall notice like this and brought the car into the dealer. He said there was a VIN "Mix up" - something about the last two digits being reversed with another customer. Reading off my dash, this is my VIN [XXX] This sounds a lot like the "Shift Lever Micro Switch" recall which is a safety issue. Thank you INFORMATION Redacted PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).

NHTSA ID

11493741

Incident

Aug 19, 2022

The contact owns a 2016 Volkswagen Golf Sportwagen. The contact stated that there was an odor of gasoline in the vehicle. Additionally, the vehicle was stalling while driving. The contact stated she stopped at a gas station and attempted to add gasoline; however, the tank was already full. The contact was able to drive home safely. After the vehicle was parked, the contact noticed that gasoline was leaking underneath the vehicle. The dealer was contacted and informed that the vehicle had experienced the failure listed in NHTSA Campaign Number: 16V647000 (Fuel System, Gasoline, Engine And Engine Cooling) however, the vehicle was previously repaired under the recall. The contact was informed that the repair would be an out-of-pocket expense. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was 86,400.

NHTSA ID

11476587

Incident

Jul 22, 2022

Mileage

86,400 mi

Dealer maintained 2016 VW Golf Sportwagen - coolant level kept getting low. Recent dealer visit indicated a leak in the thermostat housing. This seems to be a common issue with many such VWs, and in some cases other owners have reported multiple repeated failures of this housing. My car only has 66K miles and i haven't had any of my other cars have this issue over 25years of various car ownership.

NHTSA ID

11473452

Incident

Jun 1, 2022

The passenger side rear coil spring snapped without any warning and with in normal highway and city street use with only 46,244 miles and 5 years of age. The was manufactured in August of 2015, was delivered in November of 2015, and the spring failed in the last week of June 2021. The vehicle is used on road and has had all maintenance done on time or early. I drove the vehicle on June 25th and when I was about 2 miles from home I slowed for an intersection and heard a clank sound from the rear of the vehicle, the remainder of the drive was uneventful. The next day when exiting our garage my wife and I heard a loud clanking sound. I test drove the car around the block and every turn, deceleration, and bump resulted in a clank from the back rear wheel area. The VW dealer confirmed the rear spring had snapped and also noted they had had a number of occurrences on MQB platform VWs and had a Tiguan (same chassis/platform) of similar age in the shop for the same reason. I drove slowly and on low roads to the dealer but it was clear the handling was compromised as it was not predictable in terms of both motions over bumps or when turning or reaction to steering inputs. I spoke with VW corporate and they confirmed an earlier recall on rear coil springs on VW Golf Sportwagens but that recall impacted the 2015. They were unable to assist with the repair but suggested I contact NHTSA. It is fortunate that the failure occurred when it did and not at highway speeds or severe weather. It is also fortunate no fragments of the spring impacted the tire or break components. I have owned many cars with significantly higher miles and managed armored and police vehicle fleets but have never had a car with so few miles have a spring snap.

NHTSA ID

11426160

Incident

Jun 25, 2021

1. I BELIEVE THE DRIVER'S SIDE AIRBAG MAY HAVE FAILED OR BEEN DISABLED DURING A RECENT COLLISION THAT OCCURRED ON 5/25/21. A DEER STRUCK THE FRONT END OF MY VEHICLE WHILE TRAVELING ON A 55MPH STATE HIGHWAY. THE VEHICLE IS CURRENTLY AT A COLLISION REPAIR SHOP GETTING AN ESTIMATE. THE SHERIFF'S DEPUTY WHO RESPONDED TO THE SCENE GAVE AN INITIAL DAMAGE ESTIMATE OF $9000.00. 2. IMMEDIATELY UPON IMPACT THE AIRBAG ERROR LIGHT ILLUMINATED BUT DID NOT DEPLOY. 3.ON 5/26/21, THE DAY AFTER MY ACCIDENT, I RECEIVED A WARRANTY EXTENSION NOTICE DUE TO A POTENTIAL CLOCK SPRING FAILURE THAT COULD RESULT IN THE DRIVER'S SIDE AIRBAG NOT DEPLOYING. 4. VEHICLE HAS BEEN INSPECTED BY SHERIFF'S DEPT AND IS CURRENTLY BE EVALUATED BY COLLISION SPECIALIST AND INSURANCE ADJUSTER. 5. THE AIRBAG ERROR LIGHT HAD NEVER ILLUMINATED PRIOR TO THE ACCIDENT.

NHTSA ID

11418740

Incident

May 25, 2021