2001 Volkswagen GTI Problems

THE COIL PACK FAILS, I HAVE REPLACED IT TWICE AND NO MATTER WHAT THE CHECK ENGINE LIGHT COMES BACK ON IN NO TIME AT ALL AND IT'S COIL PACK FAILURE, WHICH ALSO TRIGGERS OTHER SENSORS LIKE THE COOLANT SENSOR WHICH I HAVE REPLACED AS WELL. I THINK THE LONGEST TIME MY CHECK ENGINE LIGHT WAS OFF WAS 3 WEEKS! THIS CAR COSTS A FORTUNE TO FIX AND IT'S NEVER FIXED. *TR

ON THE MORNING OF 27 APRIL 2007, I STARTED MY 2001 VOLKSWAGEN GTI 1.8T. THE VEHICLE WAS IDLING VERY ROUGH AND DID NOT SOUND NORMAL. I THOUGHT THAT IT WAS BECAUSE THE VEHICLE WAS COLD. AT THIS POINT IT BACKED OUT OF MY DRIVEWAY AND DROVE DOWN THE ROAD. APPROXIMATELY A MILE OR TWO DOWN THE ROAD I CAME TO A STOP SIGN AND AFTER STOPPING AND THEN PROCEEDING THROUGH THE INTERSECTION MY VEHICLE SEEMED LIKE IT HAD LITTLE OR NO POWER TO THE ENGINE. AT THIS POINT MY CHECK ENGINE LIGHT STARTED FLASHING SO I IMMEDIATELY PULLED OF TO THE SIDE OF THE ROAD AND SHUT OFF MY ENGINE. I THEN OPENED MY HOOD AND SMOKE POURED OUT OF THE ENGINE COMPARTMENT. AT THIS POINT I CHECKED MY OIL TO SEE IT IT SMELT BURNT WHICH IT DID NOT. I THEN CHECKED MY COOLANT LEVEL AND IT WAS FULL AND WASN'T EVEN WARM. I THEN HAD MY VEHICLE TOWED TO MY MECHANIC AND HE DIAGNOSED MY VEHICLE AND TOLD ME THAT 1 OF THE 4 COILS IN MY ENGINE HAD STOPPED WORKING AND HAD CAUGHT ON FIRE AND THAT'S WHAT HAD CAUSED THE SMOKE AND THE CHECK ENGINE LIGHT. HE ALSO SAID THE ALL FOUR NEED TO BE REPLACED OR THIS COULD HAPPEN AGAIN. AT THIS POINT ALL FOUR COILS WERE REPLACED AND THE OLD ONES WERE GIVEN TO ME TO KEEP AS PROOF THAT THE PARTS WERE DEFECTIVE. *JB

Today is 11/05/2025 incident happened yesterday evening 11/04/2025 The driver airbag in the steering wheel auto deployed when I started the car I went to step out from my car while it was warming up and barley turning the steering wheel the airbag exploded with my arm still on the wheel hitting and fracturing my ulna bone n causing a burn that was so instant n hot it burnt through my skin causing more damage to my nerves and tissue im having the car inspecting and is available upon request I took pictures and documented everything immediately there still in no warning lamp on and never has been on displaying it needs to be inspected.. but after it deployed the dash light still remains off so I don’t know if it even deactivated the system like it should’ve done with a airbag deploying this just happened yesterday so nothing has been inspected yet this is my first report it makes safety issues cause it deployed out of nowhere when car was parked I just turned the key over it could’ve deployed when I was driving causing a serious accident or death and it broke my ulna bone that alone is serious more I can’t go back to work pry my bills raise my 5yr old until this fracture heals.. this not only if a serious safety our it’s a serious situation off what do I even do now car showered not warning signs of anything and still don’t even display that it’s srs bag deployed

THE CAR, A 2001 VW GTI 1.8T, WAS BEING DRIVEN AT LOW (RESIDENTIAL STREET -- 25 MPH OR LESS) SPEEDS AND MADE A RIGHT TURN. THE RIGHT REAR WHEEL PROBABLY GRAZED THE CURB, OR POSSIBLY HIT A POTHOLE. THE PASSENGER SIDE AIRBAG AND SIDE CURTAIN AIRBAG DEPLOYED. THE CAR LOST POWER, POSSIBLY DUE TO THE ENGINE STALLING (IT'S A MANUAL) THOUGH THAT'S NOT CERTAIN. THE DEALER SERVICE DEPARTMENT INSPECTED THE CAR AND THEY CONFIRM THERE IS NO DAMAGE OTHER THAN THE (SUBSTANTIAL!) DAMAGE OF THE AIRBAG DEPLOYMENT. FORTUNATELY THERE WAS NOBODY IN THE PASSENGER SEAT AND TRAFFIC WAS MINIMAL SO NO ONE WAS INJURED. IT SEEMS AS THOUGH A CURB OR POTHOLE HIT SHOULD NOT HAVE BEEN ENOUGH TO CAUSE AIRBAG DEPLOYMENT. THE CAR HAS VERY LOW MILEAGE, LESS THAN 60,000, AND HAS BEEN WELL-MAINTAINED.

TWO MONTHS AGO MY PASSENGER SIDE WINDOW BROKE - IT WAS THE REGULATOR (COST ME $400 +), THAT GOT FIXED AND TWO WEEKS AGO MY DRIVER SIDE WINDOW BROKE, I HAVE NOT TAKEN IT TO GET FIXED UNTIL I CHECKED ON RECALLS BUT I DID NOT LOCATE ANY. I AM SURE IT IS THE REGULATOR AND WILL PROBABLE COST ANOTHER $400. HAVE ANY OTHERS SUBMITTED THIS ISSUE. *JB

VEHICLE IS IN SHOP FOR REPLACEMENT OF CATALYTIC CONVERTER AND MASS AIR FLOW SENSOR, BOTH STILL UNDER WARRANTY BECAUSE THEY ARE EMISSION CONTROL. THE CULPRIT FOR THE FAILURE SEEMS TO BE THE COIL PACK HAS FAILED. THE COIL IS NOT COVERED UNDER WARRANTY AS THE CAR NOW HAS 43,000 MILES AND IS OUTSIDE OF WARRANTY, COST IS ABOUT $800. THE COIL PACK FAILED AND WAS REPLACED AT 19,000 MILES UNDER WARRANTY. WAS TOLD BY DEALER TO EXPECT TO REPLACE THE COIL ABOUT EVERY 2 YEARS. IN ADDITION HAD THE DRIVERS WINDOW CLIPS FAIL TWICE AND THE WINDOW FELL INTO THE DOOR, HORN SHORTED 3 SEPERATE TIMES, THE DEALER FINALLY REPLACED THE RELAY THE 3RD TIME IT CAME IN AND THAT CORRECTED IT.

2001 VW GTI BOUGHT USED. AT 79,000 MILES HAD 80K SERVICE DONE AT DEALERSHIP WHICH INCLUDED CHECKING TIMING BELT. AT 82,000 TIMING BELT BROKE CAUSING EXTENSIVE DAMAGE TO ENGINE. NEEDED TO REPLACE ENGINE COST ME $5300 IN WHICH VW WOULD NOT PAY FOR AS WARRANTY ONLY COVERS ORIGINAL OWNER. VW CLAIMS BELT IS SUPPOSED TO LAST 105,000 MILES. AFTER RESEARCHING ON INTERNET, NUMEROUS CLAIMS FOR ALL 1.8T ENGINES REGARDING THE TIMING BELT GOING WELL BEFORE 105,000. *TR

SINCE CAR WAS BOUGHT IN 2001 MIL LIGHT HAS BEEN COMING ON IN RAINING CONDITIONS. VW SAID IT WAS THE CATALYTIC CONVERTER AND REPLACED IN AT NO CHARGE IN MARCH OF 2003. SINCE REPLACEMENT LIGHT STILL COMES ON, AND IS NOW PERMANENTLY ON. WHEN CAR IS WET YOU CAN SEE SPARKS COMING FROM THE IGNITION COIL. THERE ARE NOTICEABLE CRACKS IN THE COIL HOUSING. *******EPA REFERENCE INFORMATION(IHTTP://WWW.EPA.GOV/OTAQ/CERT/RECALL/420B04018.PDF) *******EPA STATES THE FOLLOWING: CYLINDER IGNITION COIL FAILURE. CAUSING THE ENGINE TO MISFIRE AND ILLUMINATE THE MALFUNCTION INDICATOR LAMP (MIL). TWO SEPARATE FAILURE MODES MAY EXIST WITHIN THE DEFECTIVE IGNITION COILS TESTED, (1)COIL HOUSING DAMAGE CAUSED DURING THE ASSEMBLY PROCESS AT THE APPLICABLE VW OR AUDI FACTORY, (2)COIL DESIGN SHORTCOMINGS BY THE SUPPLIER. *****************NOTE: THE 2002 GOLF GTI VR6 (ENGINE CLASS 2VWXV02.8224) AND THE 2001 EURO VAN VR6 (ENGINE CLASS 1VWXV02.8225)USE THE SAME IGNITION COILS AS MY CAR, THE 2001 GOLF GTI VR6 (ENGINE CLASS 1VWXV02.8224). PLEASE HELP TO INCLUDE MY CALL THE 2001 GOLF GTI (VR6). MY CAR IS NOW AND HAS BEEN GOING THROUGH ALL KINDS OF ELECTRICAL ISSUES, EXCESS FUEL CONSUMPTION, EMISSIONS FAULTS, LOSS OF POWER ENGINE POWER WHILE DRIVING, EXCESS OIL COMSUMPTION ETC. *NM

ABS AND ASR SYSTEMS HAVE FAILED - EACH HAS ITS OWN DASHBOARD WARNING LIGHT, WHICH IS ON. DEALERSHIP DIAGNOSIS: FAULTY ABS CONTROLLER/PUMP MODULE, $1,025 TO REPAIR. VW HAS AN ABS RECALL, #02V031000, WHICH COVERS 2000-2002 NEW BEETLE, GOLF/GTI, JETTA. DEALERSHIP CLAIMS MY VEHICLE IS NOT COVERED. *TR

I EXPERIENCED A BRAKE LIGHT SWITCH FAILURE WHICH RESULTED IN MY CAR NOT MEETING SAFETY STANDARDS. *NM

THE COIL PACK FAILS, I HAVE REPLACED IT TWICE AND NO MATTER WHAT THE CHECK ENGINE LIGHT COMES BACK ON IN NO TIME AT ALL AND IT'S COIL PACK FAILURE, WHICH ALSO TRIGGERS OTHER SENSORS LIKE THE COOLANT SENSOR WHICH I HAVE REPLACED AS WELL. I THINK THE LONGEST TIME MY CHECK ENGINE LIGHT WAS OFF WAS 3 WEEKS! THIS CAR COSTS A FORTUNE TO FIX AND IT'S NEVER FIXED. *TR

WHEN I PASSED 24000 MILES, AFTER HAVING DRIVEN MY CAR EXTREMELY CAREFULLY (2001 VOLKSWAGEN GTI GLS 1.8T), THE CLUTCH BEGAN TO SLIP TO THE POINT WHERE THE CAR WAS UNDRIVEABLE, AND I HAD TO BUY A REPLACEMENT CLUTCH AS WELL AS THE INSTALLATION WHICH COST AROUND $700. I HAVE SPOKEN WITH SEVERAL OTHER VW OWNERS (SAME MODEL) AND HAVE FOUND THAT THIS IS A COMMON PROBLEM AND THINK THAT VOLKSWAGEN OF AMERICA SHOULD BE HELD LIABLE FOR THIS DEFECTIVE COMPONENT. *NM

SINCE CAR WAS BOUGHT IN 2001 MIL LIGHT HAS BEEN COMING ON IN RAINING CONDITIONS. VW SAID IT WAS THE CATALYTIC CONVERTER AND REPLACED IN AT NO CHARGE IN MARCH OF 2003. SINCE REPLACEMENT LIGHT STILL COMES ON, AND IS NOW PERMANENTLY ON. WHEN CAR IS WET YOU CAN SEE SPARKS COMING FROM THE IGNITION COIL. THERE ARE NOTICEABLE CRACKS IN THE COIL HOUSING. *******EPA REFERENCE INFORMATION(IHTTP://WWW.EPA.GOV/OTAQ/CERT/RECALL/420B04018.PDF) *******EPA STATES THE FOLLOWING: CYLINDER IGNITION COIL FAILURE. CAUSING THE ENGINE TO MISFIRE AND ILLUMINATE THE MALFUNCTION INDICATOR LAMP (MIL). TWO SEPARATE FAILURE MODES MAY EXIST WITHIN THE DEFECTIVE IGNITION COILS TESTED, (1)COIL HOUSING DAMAGE CAUSED DURING THE ASSEMBLY PROCESS AT THE APPLICABLE VW OR AUDI FACTORY, (2)COIL DESIGN SHORTCOMINGS BY THE SUPPLIER. *****************NOTE: THE 2002 GOLF GTI VR6 (ENGINE CLASS 2VWXV02.8224) AND THE 2001 EURO VAN VR6 (ENGINE CLASS 1VWXV02.8225)USE THE SAME IGNITION COILS AS MY CAR, THE 2001 GOLF GTI VR6 (ENGINE CLASS 1VWXV02.8224). PLEASE HELP TO INCLUDE MY CALL THE 2001 GOLF GTI (VR6). MY CAR IS NOW AND HAS BEEN GOING THROUGH ALL KINDS OF ELECTRICAL ISSUES, EXCESS FUEL CONSUMPTION, EMISSIONS FAULTS, LOSS OF POWER ENGINE POWER WHILE DRIVING, EXCESS OIL COMSUMPTION ETC. *NM

DT: THE ENGINE WILL BUCK OR STALL AND THEN COMPLETELY SHUT DOWN. THIS HAPPENED AT ALL SPEEDS AND EVEN AT AN IDLE. HAS BEEN TO THE DEALER 4 TIMES. THE DEALER CANNOT FIND THE CAUSE OF THE PROBLEM. VEHICLE HAS BEEN DIAGNOSTICALLY TESTED. ALSO, FUEL INJECTION WA SCLEANED. AT ANOTHER TRIP TO THE DEALER, AND THEY REPLACED THE FUEL PUMP AND FILTER, AND DID ANOTHER DIAGNOSTIC TEST. CURRENTLY, THE VEHICLE IS IN THE DEALERSHIP FOR THE SAME REASON AWAITING REPAIRS. CONTACTED THE MANUFACTURER, AN AREA REPRESENTATIVE CAME TO INSPECT THE VEHICLE, NO INFORMATION ON HIS FINDINGS. *AK

I BOUGHT A PAIR OF AFTERMARKET HEADLIGHTS FROM A MEMBER ON EBAY FOR MY 2001 VW GTI. I BOUGHT THESE HEADLIGHTS FROM A SELLER . I HAVE RECENTLY DISCOVERED THAT THESE HEADLIGHTS ARE DEFECTIVE AND FOGLIGHT (WHICH IS INCORPORATED INTO THE HEADLIGHT HOUSING) IS TURNED ON IT WILL CAUSE THE INSIDE OF THE HEADLIGHT TO MELT BECAUSE OF A MANUFACTURING DEFECT. I DO BELIEVE THESE ARE UNSAFE AND COULD EVENTUALLY LEAD TO AN ELECTRICAL FIRE; HOWEVER, AFTER SEVERAL EMAILS. HE HAS NOT RESPONDED TO ME. I'VE GONE AND DONE MY RESEARCH AND OTHER PEOPLE ARE HAVING THE SAME KIND OF PROBLEMS WITH THESE LIGHTS. THEY ARE MANUFACTURED BY DEPO FOR FK AUTOMOTIVE, AND I DON'T EVEN KNOW IF THIS SELLER IS AND AUTHORIZED DEALER OF THESE HEADLIGHTS. I JUST DON'T KNOW WHERE ELSE I CAN GO. PLEASE HELP ME OUT. *TR

REPLACED, AGAIN, THE PASSENGER SIDE HEADLIGHT BULB. I JUST REPLACED THE DRIVER SIDE THREE WEEKS AGO, AGAIN. THIS IS GETTING TO BE TOO EXPENSIVE AS THE BULBS COST $14 EACH. NOT TO MENTION THAT I MAY GET STOPPED BY THE POLICE AND CITED FOR NOT HAVING A WORKING LIGHT. THERE MUST BE SOMETHING DEFECTIVE WITH THE HEADLIGHT UNIT BECAUSE I HAVE CHANGED THE BULB TOO MANY TIMES. *JB

I HAVE A 2001 VW GTI AND MY SIDE CURTAIN AIRBAGS WRONGFULLY DEPLOYED. I RECEIVED MINOR DAMAGE TO MY REAR RIM FROM A STREET CURB THAT CAUSED MY AIRBAGS TO WRONGFULLY DEPLOY. I WAS NOT IN A COLLISION, NOR IN SERIOUS DANGER, ALTHOUGH WHEN MY AIRBAGS DEPLOYED I WAS FRIGHTENED AND VEERED TO MY LEFT LANE. LUCKILY NO ONE WAS IN THAT LANE, BUT I COULD HAVE RECEIVED MAJOR INJURIES. *TR

ENGINE MISFIRES ON DAMP MORNINGS CREATING SUDDEN LOSS OF ACCELERATION AND INTERMITTENT STALL CONDITION. MIL LIGHT MAY FLASH BUT DOESN'T REMAIN LIT AFTER EPISODE. DIAGNOSED AS SECOND COIL FAILURE IN JUST 2 YEARS TOTALING OVER $1,200 IN REPAIRS. THIS IS THE VR6 ENGINE WITH A SINGLE COIL UNIT - THE "GOOD" COIL NOT SUBJECT TO VOLKSWAGEN'S SECRET WARRANTY AS OFFERED ON COILS OF OTHER 2001 MODELS AND ON THE 2002 MODEL OF THE VR6. IT WOULD SEEM THE SECRET WARRANTY MAY HAVE BEEN ARBITRARILY LIMITED IN SCOPE. *JB

THE HEATED LEATHER SEATS IN MY 2001 VOLKSWAGEN GTI VR6 "OVERHEAT" AND BURNT THE SEAT MATERIAL. I OFTEN TURNED OFF THE HEATERS AS I FELT THEY WERE GETTING TOO HOT. THE HEATERS RUINED THE SEAT MATERIAL WHICH I HAD TO REPLACE. *TR

DRIVER'S SIDE HEATED SEAT BURNED A HOLE THROUGH SEAT COVER AND MY PANTS, WAS ABLE TO TURN THE SWITCH OFF WITHOUT CRASHING. VOLKSWAGEN SAYS I CAN PAY FOR THE DIAGNOSIS AND REPAIR AS THE ITEM IS NOT COVERED UNDER WARRANTY APPARENTLY AS MY CAR IS A 2001, NEWER MODELS WITH SAME SEATS ARE COVERED. I WILL BE LOOKING AT REPAIRING IT MYSELF IF NOT COVERED. *JB

HAVE POTENZA G 019 GRID TIRES MADE BY BRIDGESTONE,,,AS THEY WEAR THEY KEEP GETTING LOUDER AN LOUDER,,,I HAVE DONE EVERY THING BY HERE TIRE BOOK,,,AND STILL THEY ARE LOUD,,,READ SOME OF THE REVIEWS ON TIRE RACK.COM ITS CRAZY. *TR

CAR ACCIDENT POSSIBLY CREATED/CAUSED BY FULL/COMPLETE INNER SIDE WALL SEPARATION OF TIRE FROM ITSELF. *TR

TL* THE CONTACT OWNS A 2001 VOLKSWAGEN GTI. THE CONTACT STATED THAT THE HEATED FRONT PASSENGER SEAT CAUGHT FIRE AND BURNED THROUGH THE PASSENGERS JACKET. THE CONTACT DID NOT HAVE THE VEHICLE INSPECTED OR REPAIRED. THE CONTACT STATED THAT HE WAS NO LONGER UTILIZING THE HEATED SEAT FUNCTION AND THE FAILURE HAD NOT RECURRED SINCE. THE FAILURE AND CURRENT MILEAGE WAS 89,000. REMAILED 05/12/11*LJ

IN MY 2001 GTI GLX VR6 THE DRIVERS SIDE HEATED SEAT, HEATS UP SO MUCH THAT IT BURNS MY LEGS, ACTUAL RED BURN MARKS! EVEN IF TURNED DOWN TO THE LOWEST SETTING THE SEAT WILL BURN ME. I KNOW IN MY FRIENDS 2002 JETTA THEY HAD THEIR HEATER IN THE SEAT REPLACED BY VW FOR THE SAME ISSUE FREE OF CHARGE. I HAVE BEEN TO VW AND THEY SAY IT'S NOT COVERED. I WANT TO USE THE HEATED SEAT BUT NEVER TRUST IT TO NOT BURN ME. *TR

REVISED/UPDATE: ORIGINAL COMPLAINT 10222650 3-29-08. AS PER TIRE FORENSICS SPECIALIST RIGHT REAR TIRE HAS 2 NAIL PUNCTURES LIKELY PICKED UP ON THE FREEWAY, UNFORESEEN. HE SAID THAT DUE TO PUNCTURES,SLOW TO FAST PRESSURE CHANGES, THE TIRE HEATED UP, INNER SIDEWALL DE-VULCANIZED. SO MY TIRE FLATTENED, CAR LOST CONTROL, FISHTAILED ACROSS FWY, I COLLIDED WITH BIG RIG AND EVENTUALLY CAME TO STOP ON SHOULDER. DO TIRE MANUFACTURES TEST FOR THESE POSSIBILITIES FOR TIRES THEY MARKET? IF NOT, WHY NOT? IT IS ALMOST INEVITABLE FOR ANY NUMBER OF CAR TIRES TO PICK UP UNFORESEEN OBJECTS THAT COULD PUNCTURE THEM. IS THIS A DESIGN FLAW OR EQUIPMENT MATERIAL ISSUE IN AS MUCH AS THE INNER SIDE WALL AND OUTER SIDE WALL OF THIS PARTICULAR MODEL OF TIRES IS VERY DIFFERENT IN THEIR COMPONENT STRUCTURE?? PLEASE RESPOND. *TR

STEERING IS HAVING PROBLEMS. WHEN TRYING TO CHANGE GEARS ON A TURN, VEHICLE LOCKS UP. HAD NO CONTROL OF VEHICLE AND IT RAN OFF THE ROAD. CONTACTED DEALER.*AK CONSUMER ALSO STATES THAT VEHICLE PULLS SHARPLY. *TT

STEERING IS HAVING PROBLEMS. WHEN TRYING TO CHANGE GEARS ON A TURN, VEHICLE LOCKS UP. HAD NO CONTROL OF VEHICLE AND IT RAN OFF THE ROAD. CONTACTED DEALER.*AK CONSUMER ALSO STATES THAT VEHICLE PULLS SHARPLY. *TT