2001 Volkswagen New Beetle Electrical Problems

I HAVE A 2001 VOLKSWAGON BEETLE AND WAS VERY FRUSTRATED WHEN MY CHECK ENGINE LIGHT CAME ON AND THE CAR STARTED SHAKING. I TOOK IT IN TO THE DEALER WHERE I WAS CHARGED $100!!!! AND THEY TOLD ME THAT THEY DID NOT KNOW WHAT THE PROBLEM WAS! I WAS SO UPSET! THE NEXT DAY THE LIGHT CAME ON AGIAN AND I WAS FURIOUS! I TOOK THE CAR IN AGAIN AND WAS TOLD IT WAS THE IGNITION COIL AND THEY WANTED TO CHARGE ME $100 AGIAN. I COPMPLAINED AND GOT THE 2ND FEE WAVED. I'M NOT AN EXPERT BUT IT IS VERY RARE FOR AN IGNITION COIL TO FAIL???*AK

NHTSA ID

10088988

Incident

Sep 1, 2004

Mileage

3,405 mi

WHILE DRIVING MY 2001 VW NEW BEETLE THE CAR SUDDENLY LOST POWER AND BEGAN TO SHAKE VIOLENTLY. I IMMEDIATELY SLOWED DOWN BUT THE CAR CONTINUED TO IDLE VERY ROUGHLY. THE ESC AND CHECK ENGINE LIGHTS ILLUMINATED. I PULLED THE CAR OFF THE HIGHWAY AND TURNED OFF THE ENGINE. I WAS ABLE TO RE-START THE ENGINE AND DRIVE THE CAR HOME. I TOOK THE CAR TO THE DEALER AND WAS INFORMED THAT THE O2 SENSOR AND THE THROTTLE BODY HAD FAILED AND REQUIRED REPLACEMENT. THE TOTAL COST WAS $1097.00 AND WAS MY RESPONSIBILITY EVEN THOUGH THE CAR IS A 2001 MODEL WITH JUST OVER 18000 MILES ON THE ODOMETER. A CALL TO THE VOLKSWAGEN "CUSTOMER ADVOCATE" CENTER PROVED HOPELESS AS THEY REFUSED TO PAY FOR THE REPAIR. I WAS TOLD THAT THE 2001 VW BEETLE CAME WITH A 2 YEAR 24000 MILE WARRANTY. THE LACK OF WARRANTY LEADS ME TO BELIEVE THAT VW KNEW THESE CARS WERE OF SUBSTANDARD QUALITY FROM THE DATE OF MANUFACTURER. *JB

NHTSA ID

10058361

Incident

Feb 16, 2004

Mileage

18,500 mi

INSTRUMENT CLUSTER MALFUNCTION: (PURCHASED THIS USED CAR MARCH 1, 2003. STARTED NOTICING PROBLEMS SHORTLY THEREAFTER, DECIDED TO REPORT IT AFTER THE MOST CURRENT INCIDENT AND UNSUCCESSFUL ATTEMPTS AT FIXING). - WHEN TRYING TO START THE CAR, IT WILL START THEN DIE IMMEDIATELY, I HAVE ALMOST BEEN STRANDED A FEW TIMES. I HAD TO KEEP TRYING TO RESTART THE CAR UNTIL THE ENGINE FINALLY STAYED RUNNING (THIS HAS OCCURRED AT LEAST 7 TIMES FROM MARCH 1, 2003 AND IS GETTING PROGRESSIVELY WORSE). COULD THIS POTENTIALLY CAUSE THE ENGINE TO DIE WHILE DRIVING? - THE SEAT BELT WARNING BUZZER HAS NEVER FUNCTIONED DURING MY OWNERSHIP. - THE DOOR BUZZER HAS NEVER FUNCTIONED DURING MY OWNERSHIP, NOT IF THE LIGHTS ARE LEFT ON OR IF THE KEYS ARE STILL IN THE IGNITION. *JB

NHTSA ID

10016996

Incident

May 2, 2003

Mileage

23,000 mi

I STARTED MY CAR ON 1/31 AND THE EPC, CHECK ENGINE AND TRACTION CONTROL LIGHTS CAME ON. THE CAR WOULD DRIVE HOWEVER HAD MUCH LESS POWER AND WAS VERY ROUGH. I BORUGHT IT INTO THE DEALERSHIP ON 2/3 AND THEY STATED IT WAS A COIL. THEY REFUSED TO REPLACE ALL 4 COILS, ONLY THE FAULTY ONE, AND I WAS TOLD THAT ONLY IF THIS POWER FAILURE OCCURS AGAIN AND IT IS DUE TO ANOTHER COIL...THEN THEY WOULD REPLACE ALL FOUR. I AM QUESTIONING THE RELIABILITY OF MY CAR, SINCE IT APPEARS THIS PROBLEM HAS BEEN WIDE SPREAD THROGHOUT THE US. I FEEL VERY UNSAFE IN MY YEAR AND HALF OLD BEETLE THAT WAS BOUGHT BECAUSE OF THE HIGH RELIABILITY RATING AT THE TIME.

NHTSA ID

10005197

Incident

Jan 31, 2003

THE COIL PACK ON MY 2001 VOLKSWAGEN NEW BEETLE BURNED OUT CAUSING ME TO PRACTICALLY STALL ON A VERY BUSY FREEWAY. SO FAR, VW DOESN'T SEEM TO THINK THIS A SAFTEY ISSUE YET AND WILL NOT REQUIRE A RECALL ON THESE PARTS. THESE COILS WILL BURN OUT. NOT IF, BUT WHEN. I WOULD HATE TO BE GOING UP A HILL WHEN ONE OF THESE COIL PACKS GO OUT.

NHTSA ID

10003485

Incident

Jan 27, 2003

Mileage

20,517 mi

COIL PACK FAILURE IIN VW NEW BEETLE WITH 1.8T ENGINE -- LAST WEEK, I HAD MY 2ND COIL PACK FAILURE (THE FIRST BEING IN NOVEMBER 2002) WHILE COMMUTING TO WORK ON THE GEORGE WASHINGTON PARKWAY AT ABOUT 45 MPH. THE CAR SUDDENLY BEGAN TO SHAKE VIOLENTLY, AND I NARROWLY AVERTED AN ACCIDENT WHEN I HAD TO SLOW DOWN TO 30. FORTUNATELY, I WAS ABLE TO EXIT SAFELY, AND I FOLLOWED SURFACE STREETS TO THE DEALER, WITH THE CAR SHUDDERING WHENEVER MY RPM EXCEEDED 2,500. THE DEALER (ALEXANDRIA VW) REPLACED THE COIL PACK THE SAME DAY, BUT, AFTER CHECKING WITH VW OF AMERICA AT MY INSISTENCE, THEY REFUSED TO REPLACE THE REMAINING TWO DEFECTIVE COIL PACKS DESPITE THEIR ADMISSION THAT THE OTHER TWO WOULD ALMOST CERTAINLY FAIL IN THE FUTURE. I CALLED VW'S COMPLAINT LINE THE NEXT DAY AND WAS TOLD THAT VW COULDN'T ISSUE A RECALL BECAUSE OF INSUFFICIENT SUPPLY OF THE REPLACEMENT PARTS. VW DOESN'T, APPARENTLY, CONSIDER THIS A SAFETY ISSUE -- PLEASE SEE THE COMMENTS ATTRIBUTED TO VW'S REPRESENTATIVE IN THIS BOSTON GLOBE STORY FROM YESTERDAY: HTTP://WWW.BOSTON.COM/DAILYGLOBE2/026/AUTO/NO_EASY_FIX_FOR_FAILING_IGNITION_COILS_IN_AUDIS_VWS+.SHTML I WOULD SUBMIT (1) THAT, BASED ON MY PERSONAL EXPERIENCE, THE COIL PACK PROBLEM IS A SERIOUS SAFETY ISSUE AND THAT VW SHOULD BE REQUIRED TO REPLACE ALL DEFECTIVE PARTS WHETHER OR NOT THEY HAVE ALREADY FAILED AND (2) THAT THIS IS AN EPIDEMIC ISSUE, INVOLVING POTENTIALLY 500,000 AUTOMOBILES, WHICH VW CANNOT BE ALLOWED TO CONTINUE TO SWEEP UNDER THE TABLE. PLEASE INVESTIGATE AND FORCE VW TO AMEND ITS IRRESPONSIBLE BEHAVIOR AND TO ISSUE A RECALL.

NHTSA ID

10003451

Incident

Jan 23, 2003

Mileage

7,100 mi

I AM FRUSTRATED AND SCARED BY A PROBLEM VOLKSWAGEN AND AUDI ARE HAVING WITH THE IGNITION SYSTEM ON THEIR TURBOCHARGED FOUR-CYLINDER ENGINES. THE SIBLING AUTOMAKERS, PARTS OF VOLKSWAGEN AG OF GERMANY, ADMIT THERE IS A "HIGHER-THAN-NORMAL" FAILURE RATE OF THE FOUR IGNITION COILS ON 2001 AND 2002 TURBOCHARGED, 1.8-LITER ENGINES USED IN ABOUT 300,000 VEHICLES, INCLUDING THE GOLF, NEW BEETLE, JETTA, PASSAT AND AUDI A4. I HAVE ALREADY HAD ONE COILPAC REPLACED, AND FEAR FOR THE TIME WHEN THE OTHERS WILL GO TOO. I HAVE BEEN TOLD THAT THEY ARE GOING TO FAIL AT SOME POINT. SO WHY DIDNT VW JUST REPLACE ALL OF THE COIL PACKS WITH THE IMPROVED ONES.

NHTSA ID

10003232

Incident

Apr 12, 2002

Mileage

17,000 mi

THE 2001.5, 2002, AND CERTAIN 2003 VW/AUDI 1.8T ENGINES HAVE EXPERIENCED A HIGH RATE OF COILPACK FAILURES. THIS HAS BEEN REPORTED BY THE MEDIA (AUTOWEEK MAGAZINE) AND DETAILED ON INTERNET MESSAGE BOARDS AT VWVORTEX.COM, AUDIWORLD.COM, NEWBEETLE.ORG, AND OTHERS, IN GREAT DETAIL. THE CURRENT PARTS SHORTAGE IS CAUSING OWNERS TO WAIT UP TO 3 WEEKS OR MORE. I WAITED 2 1/2 WEEKS. BECAUSE OF THIS SHORTAGE, ONLY THE FAILED COILPACKS ARE BEING REPLACED AT THIS TIME. THIS LEAVES THE OWNER WITH THE REMAINING POTENTIALLY DEFECTIVE COILPACKS THAT CAN FAIL AT ANY TIME. THIS IS A SERIOUS SAFETY ISSUE THAT WARRANTS A RECALL. THE FAILED UNITS HAVE BEEN ISOLATED TO A CERTAIN PART NUMBER. PREVIOUS 1.8TS THAT USE A COILPACK OF A SLIGHTLY DIFFERENT DESIGN AND PRODUCED BY A DIFFERENT SUPPLIER, HAVE NOT EXPERIENCED THIS HIGH RATE OF FAILURE. DT

NHTSA ID

770734

Incident

Nov 1, 2002

HEADLIGHTS STARTED BROWNING OUT ON DECELERATION AT 100 MILES. DEALER COULD NOT VERIFY. AT 35,000 MILES, HEADLIGHTS FLASHED ALL THE TIME. AT COLD START ENGINE FAN WOULD COME ON, THEN HEADLIGHTS WOULD DIM AND FAN WOULD RUN, THEN HEADLIGHTS WOULD COME BACK NORMAL AND FAN WOULD STOP. THIS HAPPENS AT 3 SECOND INTERVALS. DEALER REPLASED GROUNDS AND HARNESS. FAN STOPPED CYCLING BUT HEADLIGHTS STILL DIMMED, UNTIL ONE MORNING THE COLD LIGHT WENT OUT AND ALSO BLEW A HEADLIGHT. NOW NO DIMMING AND NO FAN TROUBLE. DEALER REPLACED HEADLIGHT BULB AND THE PROBLEM STARTED AGAIN. THIS IS A VERY DANGEROUS SITUATION AS THE FLASHING LIGHTS MEZMORIZE YOU WHEN YOU DRIVE. PROBLEM 2: CAR WILL START AND DIE THREE TIMES , RUNNING ROUGH BEFORE IT WILL STAY RUNNING. DEALER SAYS TO USE 87 OCTANE FUEL. CAR MANUAL SAYS 93 OCTANE AND HAS USED 93 SINCE NEW. DEALER SUGGESTED ADDITIVES AT MY COST!!! SEEMS TO HAPPEN IN LOW TEMPS AND AT HIGH TEMPS, 70 DEGREES IS OK!. I LIVE IN MAINE, NO SUCH LUCK.*AK

NHTSA ID

757733

Incident

Dec 6, 2000

EPC AND CHECK ENGINE LIGHTS COME ON///CAR LOSES POWER......EXTREMELY DANGEROUS AS MOST OF MY DRIVE TO WORK IS ON FREEWAY...HAPPENED 7/4 AND 7/5..TAKEN INTO METRO VW 7/5....TOLD OT PROBLEMS FOUND....HAPPENED AGAIN 7/9 RETURNED TO METRO VW/CHECKED/NOTHING WRONG....HAPPENED AGAIN 7/12/13...ETURNED TO METRO VW....THROTTLE REPLACED....HAPPENED AGAIN 7/12 7/13 AGAIN TO METRO VW THROTTLE BODY REPLACED......HAPPENED AGAIN 7/30 THROTTLE BODY REPLACED.....AGAIN 9/10 9/11...CONTROL MOD. REPLACED AGAIN 9/12...THOUGHT I WAS GOIN TO DIE THIS TIME....WHEN LOST POWER 18 WHEELER WAS TURNIN MY WAY.....AGAIN TO METRO VW.....WORKED ON WIRING OVERLAY....WAITIN TO SEE WHAT HAPPENS NEXT!!!*AK

NHTSA ID

752498