2002 Volkswagen Passat Wagon Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2002 Volkswagen Passat Wagon, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes333.3%
- Engine222.2%
- Airbags111.1%
- Body & structure111.1%
- Fuel system111.1%
- Tires & wheels111.1%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
MOTOR VEHICLE LIGHT: ABS BRAKE LIGHT ON. MECHANICS TELL ME THESE COMPUTER ARE ALWAYS DEFECTIVE. REPAIR COST 750.00. MILEAGE 235,000. LOTS OF COSTLY REPAIRS. LIGHT CANNOT BE RESET SO I HAVE TO PAY THE ABOVE AMOUNT TO FIX IT AND BE ABLE TO RESELL IT. THIS ABS HAS BARELY BEEN USED. COMPANY SHOULD FIX IT [XXX]/ [XXX]@AOL.COM INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6).' *JB
I WAS DRIVING UP SOMEWHAT OF A HILL AND HAD TO SLOW DOWN DUE TO A BIT OF TRAFFIC FLOW. I HAD REALIZED I WAS A LITTLE CLOSER THAN I THOUGHT SO I BRAKED A LITTLE HARDER THAN USUAL. MY BRAKES WERE GRABBING ON TIGHTLY TO THE GROUND LIKE THEY SHOULD BUT THEN SEEMED TO HAVE GIVEN OUT AT THE LAST COUPLE SECONDS. MY CAR HIT THE CAR IN FRONT OF ME, RESULTING IN BOTH MY FRONT AIRBAGS GOING OFF. THE AIRBAG ON THE PASSENGER SIDE AND SWUNG OUT AND HIT MY RIGHT HAND, RESULTING IN SOME MINOR BURNS AND SCRAPES. I THEN STARTED GOING BACKWARDS AFTER THE CAR IN FRONT OF ME WAS HIT. I HIT MY BRAKES TO STOP MY CAR FROM ROLLING AND THERE WAS NOTHING. MY CAR WOULD NOT LET ME BRAKE. SO I WENT TO PUT THE CAR IN PARK, AND THEN THE CAR WOULD NOT PARK. FINALLY THE CAR STOPPED ROLLING BACKWARDS AND WE WENT TO GO MOVE THE CAR OUT OF THE STREET ABOUT 5 MINUTES LATER. THE CAR WOULDN'T MOVE AT THIS POINT, SO I HAD TO TAKE THE CAR OUT OF PARK AND PUT IT IN NEUTRAL. THE BRAKES ARE WORKING FINE NOW FOR THE MOST PART AND THERE HAD BEEN NO PREVIOUS BRAKE PROBLEMS. THERE WAS NEVER A LIGHT INDICATOR THAT SAID THAT MY BRAKES NEEDED TO BE CHECKED NOR HAD THEY FELT DIFFERENT. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
DIDNT EXPLAIN FULLY THE FIRST TIME, SO HERE GOES. MY VW HAS ENGINE FAILURE, VW HAD A LAWSUIT AGAINST THEM SOME YEARS BACK BECAUSE OF A ENGINE SLUDGE PROBLEM. THE ENGINE RAN HOT BECAUSE IT WAS A TURBO POWERED ENGINE, PLUS NOT HAVING ENOUGH OIL TO KEEP IT COOL. CAUSING THE OIL TO BREAKDOWN AND MAKE SLUDGE WHICH CLOGGED UP THE OIL PUMP AND STARVED THE ENGINE OF OIL LEADING TO ENGINE FAILURE. THIS IS WHAT IM EXPERENCING RIGHT NOW, I HAVE ENGINE FAILURE DUE TO SLUDGE. VW LOST THAT LAWSUIT AND STILL WONT ACKNOWLEDGE THE DESIGN FLAW, IM STILL MAKING PAYMENTS ON MY CAR, IT RAN PERFECT. ALL MAINTENANCE RECORDS ARE DOCUMENTED, THE CAR IS IN ALMOST PERFECT CONDITION FOR A 2002. I WANT VW TO FIX WHAT THEY CREATED, I DONT HAVE 3000 DOLLARS TO BUY AN ENGINE FOR IT. ITS NOT MY DESIGN! I WAS DRIVING DOWN ATLANTIC AVE IN RALEIGH NC GOING 45 MPH WHEN MY ENGINE DIED, HAD TO PUSH MY CAR OUT OF TRAFFIC INTO A NEARBY PARKING LOT.
ENGINE FAILURE, CAR WAS DRIVING PERFECT NO PROBLEMS. ALL OF A SUDDEN IT STARTS VIBRATING AND SHAKING OUT OF CONTROL. CALLED MY MECHANIC HE TOLD ME TO BRING IT BY, I STARTED ON MY WAY TO DRIVE TO THE SHOP SO HE COULD TAKE A LOOK. CAR DIED 1 MILE FROM SHOP WHILE I WAS DRIVING IN TRAFFIC. I WAS GOING 45MPH WGEN IT FAILED, I HAD TO GET OUT THE CAR PUSH IT OUT OF TRAFFIC BY MYSELF. A VW PASSAT WAGON! HEAVY? YES VERY MUCH SO. GOT IT TOWED MY MECHANIC LOOKED AT IT AND SAID IT WASNT GETTIN ENOUGH OIL.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
I WAS DRIVING UP SOMEWHAT OF A HILL AND HAD TO SLOW DOWN DUE TO A BIT OF TRAFFIC FLOW. I HAD REALIZED I WAS A LITTLE CLOSER THAN I THOUGHT SO I BRAKED A LITTLE HARDER THAN USUAL. MY BRAKES WERE GRABBING ON TIGHTLY TO THE GROUND LIKE THEY SHOULD BUT THEN SEEMED TO HAVE GIVEN OUT AT THE LAST COUPLE SECONDS. MY CAR HIT THE CAR IN FRONT OF ME, RESULTING IN BOTH MY FRONT AIRBAGS GOING OFF. THE AIRBAG ON THE PASSENGER SIDE AND SWUNG OUT AND HIT MY RIGHT HAND, RESULTING IN SOME MINOR BURNS AND SCRAPES. I THEN STARTED GOING BACKWARDS AFTER THE CAR IN FRONT OF ME WAS HIT. I HIT MY BRAKES TO STOP MY CAR FROM ROLLING AND THERE WAS NOTHING. MY CAR WOULD NOT LET ME BRAKE. SO I WENT TO PUT THE CAR IN PARK, AND THEN THE CAR WOULD NOT PARK. FINALLY THE CAR STOPPED ROLLING BACKWARDS AND WE WENT TO GO MOVE THE CAR OUT OF THE STREET ABOUT 5 MINUTES LATER. THE CAR WOULDN'T MOVE AT THIS POINT, SO I HAD TO TAKE THE CAR OUT OF PARK AND PUT IT IN NEUTRAL. THE BRAKES ARE WORKING FINE NOW FOR THE MOST PART AND THERE HAD BEEN NO PREVIOUS BRAKE PROBLEMS. THERE WAS NEVER A LIGHT INDICATOR THAT SAID THAT MY BRAKES NEEDED TO BE CHECKED NOR HAD THEY FELT DIFFERENT. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
I WAS DRIVING UP SOMEWHAT OF A HILL AND HAD TO SLOW DOWN DUE TO A BIT OF TRAFFIC FLOW. I HAD REALIZED I WAS A LITTLE CLOSER THAN I THOUGHT SO I BRAKED A LITTLE HARDER THAN USUAL. MY BRAKES WERE GRABBING ON TIGHTLY TO THE GROUND LIKE THEY SHOULD BUT THEN SEEMED TO HAVE GIVEN OUT AT THE LAST COUPLE SECONDS. MY CAR HIT THE CAR IN FRONT OF ME, RESULTING IN BOTH MY FRONT AIRBAGS GOING OFF. THE AIRBAG ON THE PASSENGER SIDE AND SWUNG OUT AND HIT MY RIGHT HAND, RESULTING IN SOME MINOR BURNS AND SCRAPES. I THEN STARTED GOING BACKWARDS AFTER THE CAR IN FRONT OF ME WAS HIT. I HIT MY BRAKES TO STOP MY CAR FROM ROLLING AND THERE WAS NOTHING. MY CAR WOULD NOT LET ME BRAKE. SO I WENT TO PUT THE CAR IN PARK, AND THEN THE CAR WOULD NOT PARK. FINALLY THE CAR STOPPED ROLLING BACKWARDS AND WE WENT TO GO MOVE THE CAR OUT OF THE STREET ABOUT 5 MINUTES LATER. THE CAR WOULDN'T MOVE AT THIS POINT, SO I HAD TO TAKE THE CAR OUT OF PARK AND PUT IT IN NEUTRAL. THE BRAKES ARE WORKING FINE NOW FOR THE MOST PART AND THERE HAD BEEN NO PREVIOUS BRAKE PROBLEMS. THERE WAS NEVER A LIGHT INDICATOR THAT SAID THAT MY BRAKES NEEDED TO BE CHECKED NOR HAD THEY FELT DIFFERENT. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
FUEL LEAKING FROM FITTING ON TOP OF TANK NEAR FUEL LEVEL SENDING UNIT.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
LEFT REAR TIRE COMPLETELY SEPARATED AT THE SIDEWALLS , LEAVING 2 RUBBER RINGS AT EACH SIDE OF THE RIM, 3 INCH WIDE. CAR WAS GOING 65 MPH WITH NO LOAD, EXCEPT DRIVER. NO PRIOR PROBLEMS OR VISIBLE CRACKING. AIR PRESSURE WAS CHECKED BEFORE TRIP AND FOUND IN COMPLIANCE WITH CAR SPEC. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .