1994 Volkswagen Passat Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1994 Volkswagen Passat, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine926.5%
- Electrical514.7%
- Brakes411.8%
- Seat belts38.8%
- Transmission38.8%
- Fuel system25.9%
- Visibility25.9%
- Steering25.9%
- Powertrain (other)12.9%
- Driver assistance12.9%
- Body & structure12.9%
- Suspension12.9%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
COOLING FAN HAD TO BE REPLACED NOT ONCE, BUT TWICE WITHIN 5 YEARS. I THINK THE PART WAS COVERED IN A RECALL, BUT VOLKSWAGEN COULD NOT TELL ME ABOUT THE VEHICLE HISTORY.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
THE PASSIVE RESTRAINT SYSTEM CAUSES THE BATTERY TO DRAIN. THE SEAT BELT SWITCH BUILT INTO THE DOOR CAUSES THE SEAT BELT MOTOR TO RUN WHEN THE VEHICLE IS ON OFF. THE SEAT BELT MODULE WAS DISCONNECTED, RENDERING THE VEHICLE WITHOUT SEAT BELTS.*AK
THE CONSUMER PARKED THE VEHICLE AND 45 MINUTES LATER SMOKE BEGAN TO COME FROM UNDER THE HOOD. THE CONSUMER TOOK OUT THE BATTERY TO STOP VEHICLE FROM CATCHING FIRE. THE INSURANCE COMPANY SAID THE SMOKE WAS DUE TO A FAULTY IGNITION SWITCH. *NLM THE IGNITION SWITCH WAS REPAIRED IN DEC. 2002 BUT WAS FAULTY. ONE WEEK LATER THE ELECTRICAL BURNED. A LETTER WAS RECEIVED FROM THE DEALER IN RE TO EXTENDING THE IGNITION SWITCH WARRANTY. SMOKE CONTINUED TO POUR OUT OF THE IGNITION AREA AND FROM IN BETWEEN THE DRIVER AND FRONT PASSENGER SEATS. THE TECHNICIAN FOUND AN ELECTRICAL PART OF THE IGNITION SWITCH BURNT(#15 WIRE). THE ABS LIGHT STAYED ON DUE TO A FAILED ABS PUMP. THE CONSUMER REQUESTED REIMBURSEMENT IN RE TO THE IGNITION PROBLEM. *SC
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
THE CONSUMER PARKED THE VEHICLE AND 45 MINUTES LATER SMOKE BEGAN TO COME FROM UNDER THE HOOD. THE CONSUMER TOOK OUT THE BATTERY TO STOP VEHICLE FROM CATCHING FIRE. THE INSURANCE COMPANY SAID THE SMOKE WAS DUE TO A FAULTY IGNITION SWITCH. *NLM THE IGNITION SWITCH WAS REPAIRED IN DEC. 2002 BUT WAS FAULTY. ONE WEEK LATER THE ELECTRICAL BURNED. A LETTER WAS RECEIVED FROM THE DEALER IN RE TO EXTENDING THE IGNITION SWITCH WARRANTY. SMOKE CONTINUED TO POUR OUT OF THE IGNITION AREA AND FROM IN BETWEEN THE DRIVER AND FRONT PASSENGER SEATS. THE TECHNICIAN FOUND AN ELECTRICAL PART OF THE IGNITION SWITCH BURNT(#15 WIRE). THE ABS LIGHT STAYED ON DUE TO A FAILED ABS PUMP. THE CONSUMER REQUESTED REIMBURSEMENT IN RE TO THE IGNITION PROBLEM. *SC
WHILE TRAVELING AND WITHOUT ANY INDICATION BRAKES WILL FAIL WITHOUT BEING DEPRESSING. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
THE PASSIVE RESTRAINT SYSTEM CAUSES THE BATTERY TO DRAIN. THE SEAT BELT SWITCH BUILT INTO THE DOOR CAUSES THE SEAT BELT MOTOR TO RUN WHEN THE VEHICLE IS ON OFF. THE SEAT BELT MODULE WAS DISCONNECTED, RENDERING THE VEHICLE WITHOUT SEAT BELTS.*AK
AUTOMATIC SEAT BELT ON BOTH DRIVER'S AND PASSENGER'S SIDES WILL RETRACT SUDDENLY, CAUSING LOSS OF PROTECTION IN CASE OF ACCIDENT. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
WITH THE TRANSMSIION FAILING IT COULD BE A SERIOUS PROBLEM, ESPECIALLY AT THE SPEED THAT I WAS GOING AT THE APPROMIMATE TIME OF FAILURE. AN ACCIDENT ALMOST OCCURED DUE TO THE VIOLNET LUNGING BACK AND FORTH FROM THE DEFECTIVE TRANSMISSION. OBVIOUSLY THERE IS A PROBLEM WITH VOLKSWAGENS TRANSMISSIONS. THIS PROBLEM NEEDS TO BE ADDRESSED PROMPTLY BY VOLKSWAGEN BEFORE FATALITIES DO OCCUR. THE TRANSMISSION SHOULD HAVE NOT FAILED AT SUCH AN EARLY TIME.
TRANSMISSION FAILED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
DEFECTIVE FUEL LINE CLAMPS CAUSE UNDERHOOD FUEL LINES TO LEAK ALLOWING FUMES TO ENTER PASSANGER COMPARTMENT.
VEHICLE BURST INTO FLAMES WHILE DRIVING DUE TO GAS TANK FLUID LEAKAGE.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
94 VOLKSWAGEN PASSAT, 110K MILES, EXPERIENCED HEATER CORE FAILURE, LEAKING 200 DEGREE FLUID ONTO FLOOR OF PASSENGER COMPARTMENT NEAR GAS/BRAKE PEDAL AND FOGGING OVER INTERIOR OF WINDSHIELD WITH STICKY ANTI-FREEZE RESIDUE. *NM
WHEN ENGINE GETS HOT STEAM ENTERS INSIDE OF VEHICLE WHICH FOGS UP WINDOWS. CAUSE COULD NOT BE IDENTIFIED. DEALER CONTACTED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
GOING UPHILL, MAKING LEFT TURN AT ABOUT 10 MPH, VEHICLE BECAME INOPERATIVE/STALLED, CAUSING THE STEERING TO LOCK UP, ALMOST RESULTING IN AN ACCIDENT. INTERMITTENT PROBLEM. DEALER CANNOT REPRODUCE DEFECT. *AK
TIE ROD END WORE OUT, CAUSING VEHICLE TO MAKE NOISE WHEN TURNING CORNERS.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
ODOMETER AND SPEEDOMETER DID NOT WORK PROPERLY, CONSUMER DOES NOT OWN THIS VEHICLE ANYMORE. *SLC
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
WITH THE TRANSMSIION FAILING IT COULD BE A SERIOUS PROBLEM, ESPECIALLY AT THE SPEED THAT I WAS GOING AT THE APPROMIMATE TIME OF FAILURE. AN ACCIDENT ALMOST OCCURED DUE TO THE VIOLNET LUNGING BACK AND FORTH FROM THE DEFECTIVE TRANSMISSION. OBVIOUSLY THERE IS A PROBLEM WITH VOLKSWAGENS TRANSMISSIONS. THIS PROBLEM NEEDS TO BE ADDRESSED PROMPTLY BY VOLKSWAGEN BEFORE FATALITIES DO OCCUR. THE TRANSMISSION SHOULD HAVE NOT FAILED AT SUCH AN EARLY TIME.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
STRUCTURE OF VEHICLE CAUSES TIRE DAMAGE/BLOW OUTS.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
STRUCTURE OF VEHICLE CAUSES TIRE DAMAGE/BLOW OUTS.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .