RoadVitals

2005 Volkswagen Touareg Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest Sep 20, 2017
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
2 investigations on file

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

17V583000

FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP

Sep 20, 2017
73,941 units potentially affected
The defect: Volkswagen Group of America, Inc. (Volkswagen) is recalling certain 2004-2007 Touareg vehicles. These gasoline-powered vehicles have a fuel filter flange that may crack, allowing fuel to leak.
The risk: A fuel leak in the presence of an ignition source increases the risk of a fire.
The remedy: Volkswagen will notify owners, and dealers will inspect the fuel filter flange for cracks, replacing the flange if cracks are found. If no cracks are found, a protective cover will be installed onto the filter flange. These repairs will be performed free of charge. The recall began March 9, 2018. Owners may contact Volkswagen customer service at 1-800-893-5298. Volkswagen's number for this recall is 20Ai.
Volkswagen Group of America, Inc.Manufacturer number 20AiView on NHTSA.gov
04V592000

SEAT BELTS

Dec 15, 2004
50,483 units potentially affected
The defect: CERTAIN PASSENGER CARS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 208, "OCCUPANT CRASH PROTECTION." ALL THREE REAR SEAT POSITIONS AND THE FRONT PASSENGER POSITION ARE EQUIPPED WITH SEAT BELT RETRACTORS THAT HAVE A LOCKING FEATURE WHICH CONVERTS THE RETRACTOR FROM AN EMERGENCY LOCKING RETRACTOR (ELR) MODE TO AN AUTOMATIC LOCKING RETRACTOR (ALR) MODE FOR THE PURPOSES OF CHILD RESTRAINT INSTALLATION. THE BELT MAY DEACTIVATE THE ALR MODE WITH CERTAIN CHILD RESTRAINTS.
The risk: WHEN INVOLVED IN A CRASH, THE CHILD RESTRAINTS MAY NOT BE PROPERLY SECURED, INCREASING THE RISK OF INJURIES OR DEATH.
The remedy: DEALERS WILL PERMANENTLY INSTALL A 'CLIP' IN EACH OF THE TWO REAR OUTBOARD SEAT BELTS. THE CLIPS WILL PREVENT UNWANTED DEACTIVATION OF THE ALR MODE WITH CHILD SEAT INSTALLATIONS. THE RECALL BEGAN ON APRIL 11, 2005. OWNERS SHOULD CONTACT VW AT 1-800-822-8987.
VOLKSWAGEN OF AMERICA, INCManufacturer number UYView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE06022ClosedPreliminary Evaluation

SRS WARNING LIGHT ILLUMINATION

Opened Jun 19, 2006
Closed Oct 30, 2006

MY 2004-05 (TO 11/2004) TOUAREG VEHICLES HAVE A POTENTIALLY FAULTY/LOOSE SIDE AIR BAG WIRING CONNECTOR THAT CAN CAUSE THE WIRING CIRCUIT RESISTANCE TO EXCEED THE DESIGN LIMIT AND ILLUMINATE THE SUPPLEMENTAL RESTRAINT SYSTEM (SRS) AIR BAG LIGHT.ON 02/2005, VW ISSUED A TECHNICAL SERVICE BULLETIN (TSB #69-05-02) TO ADDRESS THIS CONDITION BY REPLACING THE CONNECTOR WITH A DIRECT CONNECTION.VW'S TESTING HAS SHOWN THAT PROPER DEPLOYMENT OF THE SIDE AIR BAG IS NOT AFFECTED BY THE CONNECTOR FAULT.HOWEVER, THERE ARE A LARGE NUMBER OF WARRANTY CLAIMS DUE TO AIR BAG LIGHT (ABL) ILLUMINATION.VW IS PLANNING TO INITIATE A TOUAREG SERVICE PACK/ CUSTOMER SATISFACTION CAMPAIGN (CSC) IN DECEMBER 2006.VW WILL REPLACE THE SIDE AIR BAG WIRING CONNECTOR WITH A DIRECT CONNECTION ON ALL REMAINING UNCORRECTED VEHICLES BUILT PRIOR TO 11/2004.IN ADDITION, VW REPORTS THAT A SMALL NUMBER OF VEHICLES BUILT IN OCTOBER AND NOVEMBER 2003, MAY CONTAIN AN INCORRECTLY MANUFACTURED SIDE AIR BAG MODULE.THIS ALSO MAY PRODUCE ABL ILLUMINATION THAT WOULD BECOME EVIDENT SOON AFTER THE VEHICLE IS PUT INTO SERVICE.WARRANTY DATA INDICATES THAT THESE MODULES HAVE BEEN CORRECTED AND NO LONGER PRESENT A RISK.VW HAS NOT RECEIVED ANY ALLEGED SIDE AIR BAG NON-DEPLOYMENT REPORT.ACTION TAKEN BY THE MANUFACTURER IS SUFFICIENT TO RESOLVE THE ISSUE RAISED BY THIS INVESTIGATION.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

AIR BAGS:SIDE/WINDOW
PE05042ClosedPreliminary Evaluation

EXTERIOR DOOR HANDLE MALFUNCTION

Opened Aug 11, 2005
Closed Dec 21, 2005

VW ISSUED A TECHNICAL SERVICE BULLETIN (TSB) DATED JUNE 10, 2005, DESCRIBING A CONDITION OF EXTERIOR DOOR HANDLE STICKS IN THE OPENED POSITION AFTER THE DOOR IS OPENED.VW DESCRIBED THE CAUSE OF THE PROBLEM TO BE A POTENTIAL FOR INCREASED FRICTION BETWEEN THE DOOR HANDLE AND THE LOCK CYLINDER HOUSING . . . BECAUSE SOME GUIDE NUBS THAT WERE MOLDED INTO THE PLASTIC DOOR HANDLE . . . WERE SLIGHTLY HIGHER THAN SPECIFIED.IN ADDITION TO THE TSB, VW HAS INTRODUCED PRODUCTION CHANGES (LUBRICATION, DELETION OF THE GUIDE NUBS, INTRODUCTION OF A LOW FRICTION GUIDE SURFACE ON THE LOCK CYLINDER HOUSING) TO ADDRESS THE PROBLEM.VW REPORTS THAT THE FAILURE OCCURS PREDOMINANTLY IN THE VERY EARLY LIFE STAGE OF THE VEHICLE.ODI EXAMINATION OF VW'S WARRANTY DATA SHOWS FEWER CLAIMS AS THE VEHICLE AGES.THE ONE INJURY RESULTED WHEN THE UNLATCHED DOOR HIT THE OCCUPANT'S HAND.A SAFETY DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.ODI WILL CONTINUE TO MONITOR COMPLAINTS ANDRESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

LATCHES/LOCKS/LINKAGES:DOORS:LATCH

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .