1985 Volvo 240 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1985 Volvo 240, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical233.3%
- Brakes116.7%
- Driver assistance116.7%
- Engine116.7%
- Transmission116.7%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
FOLLOWING MULTIPLE BREAKDOWNS FAILED INSULATION ON EXPOSED ELECTRICAL WIRES IN CLOSE PROXIMITY TO THE FUEL INJECTION SYSTEM AND ALTERNATOR WERE FOUND. I BELIEVE THIS TO BE A DANGEROUS SITUATION WHICH COULD LEAD TO FIRE AND HAVE TAKEN THE CAR OFF THE ROAD PENDING REPAIR. I SEARCHED GOOGLE FOR VOLVO BAD WIRING AND CAME UP WITH MANY HITS. THIS APPEARS TO BE A SAFETY RELATED DESIGN FAULT RELATED TO THE TYPE OF WIRE USED ONLY IN CERTAIN YEARS IN THE EARLY 1980'S. EARLIER AND LATER CARS SEEM TO BE OK. IT SEEMS THE WIRE IS NOT HEAT RESISTENT.
POOR WIRE INSULATION FOR ENGINE WIRE HARNESS CRUMBLES AWAY.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
RADIATOR FAILURE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
WHILE BACKING OUT, WITH FOOT APPLIED TO BRAKE, WITHOUT PRESSING GAS, SUDDENLY ENGINE SURGED THEN ACCELERATED OUT OF CONTROL, HITTING A HOUSE, IN REVERSE. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
RADIATOR FAILURE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
RADIATOR FAILURE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .