1986 Volvo 240 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1986 Volvo 240, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical417.4%
- Exterior lighting313.0%
- Powertrain (other)28.7%
- Brakes28.7%
- Driver assistance28.7%
- Interior & seats28.7%
- Tires & wheels14.3%
- Body & structure14.3%
- Visibility14.3%
- Heating & air conditioning14.3%
- Engine14.3%
- Fuel system14.3%
- Other / unspecified14.3%
- Seat belts14.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
WIRING HARNESS HAS DETERIORATED. MANUFACTURER HAS BEEN NOTIFIED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
I OWNED A 1986 240 GL VOLVO 4 DOOR SEDAN. ONE NIGHT LAST MONTH MY WIFE WAS DRIVING HOME AND WITHIN A BLOCK OF OUR HOUSE SHE NOTICED A FIRE ON THE BACK OF THE CAR. THE DRIVER'S SIDE TAIL LIGHT WAS ON FIRE. I CONTACTED VOLVO USA AND ABOUT A MONTH LATER THEY HAD AN "EXPERT" INSPECT OUR CAR. THEY WILL NOT GIVE ME A WRITTEN REPORT. THE EXECUTIVE, JOSEPH ([email protected]) CALLED ME AND LEFT A MESSAGE SAYING THAT WE HAD TOO LARGE OF A FUSE IN THE FUSE BLOCK AND THIS IS WHAT CAUSED THE FIRE. I'VE TRIED REPEATEDLY TO TELL THEM THAT TOO LARGE OF A FUSE DIDN'T CAUSE THE DEAD SHORT FIRE ON OUR TAIL LIGHT. I GOOGLED TAIL LIGHT FIRES ON VOLVO'S AND FOUND SEVERAL PAGES. I'VE HAD TO SCRAP THE CAR. THE TOW TRUCK DRIVER WASN'T SHOCKED TO SEE THE MELTED TAIL LIGHT ON MY VOLVO. HE TOLD ME HE HAD A 1984 VOLVO JUST LIKE MINE AS HIS FIRST CAR. HE SAID HIS TOO HAD THE SAME MELTED TAIL LIGHT FIRE AS MINE.
NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
CRUISE CONTROL/SPEEDOMETER AND ODOMETER/AIR INTAKE SENSOR/GLOVE BOX DOOR HINGE HEATER/AIR CONDITIONER INDOOR FAN/ RADIO ANTENNA/INSIDE REAR VIEW MIRROR/DOME LIGHT, TAIL LIGHT LENSE/CATALITIC CONVERTER/WATER PUMP/TIMING BELT/PLASTIC COVER UNDER ENGINE/WHEEL STUDS/THROTTLE CABLE/BRACKETS THAT HOLD SUNVISOR/ROCKER PANEL TRIM MOLDING AROUND WHEEL WELLS/VENT LINE FOR GAS TANK, AND ALTERNATOR FAILED.
SPEEDOMETER DOESN'T WORK . *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
WHEN APPLYING BRAKES BRAKE PEDAL PROCEEDED TO THE FLOOR AFTER DRIVING AT LEAST 12 MILES. DEALER NOTIFIED. *AK
SEAT ON THE DRIVER SIDE ISN'T FIXED AND THE FRAME IS RUSTED. ALSO BRAKE PEDAL IS CORRODED. THE CONSUMER IS CONCERNED ABOUT THE BRAKES AND THE SEAT. THE SEAT MIGHT BRAKE AWAY FROM THE FRAME IF THE CONSUMER WAS TO GET INVOLVED IN AN ACCIDENT. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
CRUISE CONTROL/SPEEDOMETER AND ODOMETER/AIR INTAKE SENSOR/GLOVE BOX DOOR HINGE HEATER/AIR CONDITIONER INDOOR FAN/ RADIO ANTENNA/INSIDE REAR VIEW MIRROR/DOME LIGHT, TAIL LIGHT LENSE/CATALITIC CONVERTER/WATER PUMP/TIMING BELT/PLASTIC COVER UNDER ENGINE/WHEEL STUDS/THROTTLE CABLE/BRACKETS THAT HOLD SUNVISOR/ROCKER PANEL TRIM MOLDING AROUND WHEEL WELLS/VENT LINE FOR GAS TANK, AND ALTERNATOR FAILED.
SUDDEN AND UNINTENDED ACCELERATION, RESULTING IN AN ACCIDENT/INJURIES AFTER RECALL (86V-129). *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
CRUISE CONTROL/SPEEDOMETER AND ODOMETER/AIR INTAKE SENSOR/GLOVE BOX DOOR HINGE HEATER/AIR CONDITIONER INDOOR FAN/ RADIO ANTENNA/INSIDE REAR VIEW MIRROR/DOME LIGHT, TAIL LIGHT LENSE/CATALITIC CONVERTER/WATER PUMP/TIMING BELT/PLASTIC COVER UNDER ENGINE/WHEEL STUDS/THROTTLE CABLE/BRACKETS THAT HOLD SUNVISOR/ROCKER PANEL TRIM MOLDING AROUND WHEEL WELLS/VENT LINE FOR GAS TANK, AND ALTERNATOR FAILED.
SEAT ON THE DRIVER SIDE ISN'T FIXED AND THE FRAME IS RUSTED. ALSO BRAKE PEDAL IS CORRODED. THE CONSUMER IS CONCERNED ABOUT THE BRAKES AND THE SEAT. THE SEAT MIGHT BRAKE AWAY FROM THE FRAME IF THE CONSUMER WAS TO GET INVOLVED IN AN ACCIDENT. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
WHILE DRIVING, THE RIGHT REAR TIRE BLEW OUT, CAUSING CONSUMER TO LOSE CONTROL OF VEHICLE, CONSUMER SUFFERED MINOR INJURIES.(NO TIRE INFO GIVEN.(OHIO CRASH TRAFFIC REPORT)*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
CRUISE CONTROL/SPEEDOMETER AND ODOMETER/AIR INTAKE SENSOR/GLOVE BOX DOOR HINGE HEATER/AIR CONDITIONER INDOOR FAN/ RADIO ANTENNA/INSIDE REAR VIEW MIRROR/DOME LIGHT, TAIL LIGHT LENSE/CATALITIC CONVERTER/WATER PUMP/TIMING BELT/PLASTIC COVER UNDER ENGINE/WHEEL STUDS/THROTTLE CABLE/BRACKETS THAT HOLD SUNVISOR/ROCKER PANEL TRIM MOLDING AROUND WHEEL WELLS/VENT LINE FOR GAS TANK, AND ALTERNATOR FAILED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
CRUISE CONTROL/SPEEDOMETER AND ODOMETER/AIR INTAKE SENSOR/GLOVE BOX DOOR HINGE HEATER/AIR CONDITIONER INDOOR FAN/ RADIO ANTENNA/INSIDE REAR VIEW MIRROR/DOME LIGHT, TAIL LIGHT LENSE/CATALITIC CONVERTER/WATER PUMP/TIMING BELT/PLASTIC COVER UNDER ENGINE/WHEEL STUDS/THROTTLE CABLE/BRACKETS THAT HOLD SUNVISOR/ROCKER PANEL TRIM MOLDING AROUND WHEEL WELLS/VENT LINE FOR GAS TANK, AND ALTERNATOR FAILED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Heating & air conditioning
Reports naming the heating, ventilation and air-conditioning system.
From owner reports, verbatim
UPON DEPRESSING DRIVER'S SEAT WARMER BUTTON, DRIVER SMELLED BURNING ODOR FOLLOWED BY FLAMES BELOW DRIVER'S SEAT, VEHICLE TOTALLY DESTROYED, INJURY TO CONSUMER.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
CRUISE CONTROL/SPEEDOMETER AND ODOMETER/AIR INTAKE SENSOR/GLOVE BOX DOOR HINGE HEATER/AIR CONDITIONER INDOOR FAN/ RADIO ANTENNA/INSIDE REAR VIEW MIRROR/DOME LIGHT, TAIL LIGHT LENSE/CATALITIC CONVERTER/WATER PUMP/TIMING BELT/PLASTIC COVER UNDER ENGINE/WHEEL STUDS/THROTTLE CABLE/BRACKETS THAT HOLD SUNVISOR/ROCKER PANEL TRIM MOLDING AROUND WHEEL WELLS/VENT LINE FOR GAS TANK, AND ALTERNATOR FAILED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
CRUISE CONTROL/SPEEDOMETER AND ODOMETER/AIR INTAKE SENSOR/GLOVE BOX DOOR HINGE HEATER/AIR CONDITIONER INDOOR FAN/ RADIO ANTENNA/INSIDE REAR VIEW MIRROR/DOME LIGHT, TAIL LIGHT LENSE/CATALITIC CONVERTER/WATER PUMP/TIMING BELT/PLASTIC COVER UNDER ENGINE/WHEEL STUDS/THROTTLE CABLE/BRACKETS THAT HOLD SUNVISOR/ROCKER PANEL TRIM MOLDING AROUND WHEEL WELLS/VENT LINE FOR GAS TANK, AND ALTERNATOR FAILED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
CRUISE CONTROL/SPEEDOMETER AND ODOMETER/AIR INTAKE SENSOR/GLOVE BOX DOOR HINGE HEATER/AIR CONDITIONER INDOOR FAN/ RADIO ANTENNA/INSIDE REAR VIEW MIRROR/DOME LIGHT, TAIL LIGHT LENSE/CATALITIC CONVERTER/WATER PUMP/TIMING BELT/PLASTIC COVER UNDER ENGINE/WHEEL STUDS/THROTTLE CABLE/BRACKETS THAT HOLD SUNVISOR/ROCKER PANEL TRIM MOLDING AROUND WHEEL WELLS/VENT LINE FOR GAS TANK, AND ALTERNATOR FAILED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
ALL FOUR SHOULDER SEAT BELTS JAM IN RETRACTOR AREA W/DRIVERS BELT BEING REPLACED. OTHER THREE STILL HAVE NOT BEEN REPLACED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .