2000 Volvo 660 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2000 Volvo 660, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Suspension418.2%
- Visibility313.6%
- Steering313.6%
- Engine313.6%
- Body & structure29.1%
- Electrical29.1%
- Interior & seats29.1%
- Transmission29.1%
- Powertrain (other)14.5%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
CONSUMER STATED THE VEHICLE IS EXPERIENCING EXCESSIVE TIRE WEAR, MANUFACTURER INFORMED CONSUMER TO HAVE AN ALIGNMENT PERFORMED EVERY 10,000 MILES.*YD
CONSUMER EXPERIENCING PROBLEMS WITH THE STEER TIRES. *SLC
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
CONSUMER STATED THE VEHICLE IS EXPERIENCING EXCESSIVE TIRE WEAR, MANUFACTURER INFORMED CONSUMER TO HAVE AN ALIGNMENT PERFORMED EVERY 10,000 MILES.*YD
CONSUMER STATED THAT WINDOWS IN THE TRUCK CRACKED OR BLEW OUT. *YD
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
WHILE DRIVING RIGHT SIDE STEER TIRE CAME OFF VEHICLE. DEALER CONTACTED. *AK
THE CONSUMER EXPERIENCED PROBLEMS WITH THE SHACKLES, FRONT END, AND TIE RODS. *TT *SCC
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
VEHICLE KEEPS CUTTING OFF AT ANY SPEED, CONSUMER TOOK VEHICLE TO DEALER, AND THEY REPLACED DASHBOARD/ ENGINE HEAD, BUT PROBLEM STILL OCCURS.*AK *JB
CONSUMER STATED THE VEHICLE IS EXPERIENCING EXCESSIVE TIRE WEAR, MANUFACTURER INFORMED CONSUMER TO HAVE AN ALIGNMENT PERFORMED EVERY 10,000 MILES.*YD
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
THE CONSUMER HAS EXPERIENCED THE FOLLOWING PROBLEMS: DASH/READOUT MODULE, STEERING/UNLESS THE VIBRATION IS BAD WHEN THE TIRES ARE CUPPED, THE WINDSHIELD SEEM TO CRACK EASILY-REPLACED 3 TIMES, THE UNIVERSAL JOINT HAS BEEN REPLACED 2 TIMES, AND ON ONE OCCASION THE TRUCK SUDDENLY BOUNCED WHEN GOING DOWN THE HIGHWAY AND CHANGED LANES. (THE HOOD LATCH WAS REPLACED) SCC
WHEN FULLY FUELED VEHICLE EXCEEDS 12700 ON THE FRONT STEER AXLE, DEALER ADDED EQUIPMENT WHICH MADE MADE THE VEHICLE OVERWEIGHT ON THE FRONT AXLE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
CONSUMER STATES THAT THE ALTERNATOR IS NOT GETTING ENOUGH VOLTS CAUSING VEHICLE TO STALL. NLM
CONSUMER STATES TRUCK IS EXPEREINCING STEER TIRE WEAR.*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
THE CONSUMER HAS EXPERIENCED THE FOLLOWING PROBLEMS: DASH/READOUT MODULE, STEERING/UNLESS THE VIBRATION IS BAD WHEN THE TIRES ARE CUPPED, THE WINDSHIELD SEEM TO CRACK EASILY-REPLACED 3 TIMES, THE UNIVERSAL JOINT HAS BEEN REPLACED 2 TIMES, AND ON ONE OCCASION THE TRUCK SUDDENLY BOUNCED WHEN GOING DOWN THE HIGHWAY AND CHANGED LANES. (THE HOOD LATCH WAS REPLACED) SCC
WIRING HARNESS IN THE CONTROL PANEL IN SLEEPER BERTH SHORTED RESULTING IN VEHICLE FIRE. VOLVO FIRED THEIR OWN INVESTIGATOR WHO CLAIMED PROBLEM CAME FROM CONTROL PANEL. *MJS
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
CONSUMER HEARD A NOISE. TRANSMISSION WENT OUT DUETO TRANSMISSION COOLING UNIT HOSE BUSTING. CONTACTED DEALER. *AK
CONSUMER STATED THE VEHICLE IS EXPERIENCING EXCESSIVE TIRE WEAR, MANUFACTURER INFORMED CONSUMER TO HAVE AN ALIGNMENT PERFORMED EVERY 10,000 MILES.*YD
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
THE CONSUMER HAS EXPERIENCED THE FOLLOWING PROBLEMS: DASH/READOUT MODULE, STEERING/UNLESS THE VIBRATION IS BAD WHEN THE TIRES ARE CUPPED, THE WINDSHIELD SEEM TO CRACK EASILY-REPLACED 3 TIMES, THE UNIVERSAL JOINT HAS BEEN REPLACED 2 TIMES, AND ON ONE OCCASION THE TRUCK SUDDENLY BOUNCED WHEN GOING DOWN THE HIGHWAY AND CHANGED LANES. (THE HOOD LATCH WAS REPLACED) SCC
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .