2005 Volvo 660 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2005 Volvo 660, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Exterior lighting133.3%
- Other / unspecified133.3%
- Steering133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Exterior lighting
Reports naming headlights, tail lights, turn signals and other exterior lighting.
From owner reports, verbatim
THE HEADLIGHTS ON THIS CLASS 8 TRUCK ARE DANGEROUS, VERY LOW LIGHT, YOU HAVE TO RUN WITH HIGH BEAM ALL THE TIME. I DON'T KNOW HOW VOLVO SLIP THIS BY DOT NEED TO BE RECALLED. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
M RELOCATION, INC WAS MOVING AN INDIVIDUAL WITH AN 18 WHEELER ONTO THE APARTMENT COMMUNITY THAT I MANAGE. WHILE DRIVING ON MY PROPERTY, THE DRIVER DESTROYED A SECTION OF LANDSCAPING AND THE SPRINKLER SYSTEM. THE DRIVER REFUSED TO GIVE INSURANCE INFORMATION. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
TL*THE CONTACT OWNS A 2005 (NA) VOLVO 660. WHILE DRIVING 65 MPH, THE CONTACT SUDDENLY LOST ALL STEERING CONTROL. HE COULD NOT TURN THE STEERING WHEEL LEFT OR RIGHT. THE CONTACT EXAMINED THE VEHICLE AND NOTICED THAT THE STEERING DRAG LINK HAD SEPARATED FROM THE FRONT AXLE. THE CONTACT DID NOT NOTICE ANY DIFFERENCES IN THE VEHICLE PRIOR TO THE FAILURE. THE VEHICLE WAS TOWED TO THE DEALER AND REPAIRED. THE CURRENT AND FAILURE MILEAGES WERE 479,522.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .