RoadVitals

1993 Volvo 850 Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Newest Aug 20, 1996
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
2 investigations on file

Recall campaigns

1 campaign cover this model year — what the defect is, what it could cause, and what the remedy is

96E025000

ENGINE AND ENGINE COOLING:ENGINE:GASOLINE

Aug 20, 1996
400 units potentially affected
The defect: ENGINE BLOCK HEATERS INSTALLED AS ACCESSORIES. THE BLOCK HEATER CONTACT SURFACE DOES NOT MATCH CORRECTLY WITH THE ENGINE BLOCK AS INTENDED. THE BLOCK HEATER COULD COME LOOSE FROM THE ENGINE BLOCK, AND IF BEING USED, COULD POSSIBLY OVERHEAT CAUSING DAMAGE IF IT COMES IN CONTACT WITH OTHER ENGINE COMPARTMENT COMPONENTS.
The risk: ENGINE COMPARTMENT DAMAGE COULD OCCUR INCREASING THE RISK OF A VEHICLE ACCIDENT.
The remedy: DEALERS WILL INSPECT THE BLOCK HEATER AND SECURE THE BOLTS USED TO INSTALL THE HEATER. IN SOME CASES, THE SURFACE TOLERANCES MAY BE SO INAPPROPRIATE THAT THE HEATER WOULD NEED TO BE REPLACED WITH A HEATER OF A MODIFIED DESIGN.
VOLVO CARS OF NA, INC.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

EA03008ClosedEngineering Analysis

FUEL TANK LEAKS

Opened Jun 11, 2003
Closed Jul 28, 2004

THIS ENGINEERING ANALYSIS WAS OPENED ON JUNE 11, 2003, BASED ON 54 REPORTS OF FUEL TANK LEAKS.THE SUBJECT VEHICLES WERE 1993 THROUGH 1996 MODEL YEAR (MY) 850 VEHICLES. MODEL 850 WAS ALSO PRODUCED IN MY 1997 AND WAS INCLUDED IN THIS INVESTIGATION. ANALYSIS OF THE DATA REVEALS TWO DISTINCT ISSUES. FIRST, THE 1994 THROUGH 1997 MY VEHICLES STAND OUT BY ACCOUNTING FOR 95 PERCENT OF THE REPORTED LEAKS.THESE VEHICLES SHARE THE SAME FUEL TANK DESIGN (PN 9142618). THE 1993 MY VEHICLE USES A DIFFERENT FUEL TANK DESIGN (PN 9141101).SECONDLY, THE FAILURES OCCURRED PREDOMINANTLY IN HOT CLIMATES, E.G., CALIFORNIA, ARIZONA, TEXAS, FLORIDA, GEORGIA, LOUISIANA, ETC.TESTING OF FUEL TANKS FROM CONSUMER VEHICLES AT THE VEHICLE RESEARCH AND TEST CENTER CONFIRMED LEAKS THROUGH CRACKS IN THE FUEL TANK WALL AT A HEAT SHIELD MOUNTING ATTACHMENT IN THE 1994 THROUGH 1997 MY FUEL TANKS (PN9142618). DETAILS OF THE TESTS ARE AVAILABLE IN TEST REPORT VRTC-DCD3060.VOLVO WILL CONDUCT A SAFETY RECALL ON ALL MY 1994 THROUGH 1997 VEHICLES ORIGINALLY SOLD OR REGISTERED IN THE FOLLOWING 17 HOT STATES: CA, AZ, NM, TX, LA, MS, AL, GA, SC, FL, NC, TN, AR, OK, UT, NV, AND HI.ALL 1994 THROUGH 1997 MY VEHICLES IN ALL OTHER STATES WILL BE REMEDIED UNDER A SERVICE CAMPAIGN.THE REMEDY FOR BOTH THE RECALL AND SERVICE CAMPAIGN IS TO INSTALL A NEW BUSHING AT EACH HEAT SHIELD ATTACHMENT POINT (3 PER TANK).ALSO, ALL TANKS (VEHICLES IN ALL STATES) WILL BE INSPECTED FOR FUEL SEEPAGE AT THE HEAT SHIELD ATTACHMENT POINTS AND VOLVO WILL REPLACE ANY TANK SHOWING SIGNS OF FUEL SEEPAGE.THE NEW BUSHINGS WILL PREVENT HEAT SHIELD STRESSES FROM BEING TRANSFERRED TO THE THREE HEAT SHIELD MOUNTING ATTACHMENTS ON THE FUEL TANK.THE SAFETY RECALL IS FILED UNDER NHTSA SAFETY RECALL NUMBER 04V368.THIS INVESTIGATION IS CLOSED.

FUEL SYSTEM, GASOLINE:STORAGELed to recall 04V368000
PE03003ClosedPreliminary Evaluation

FUEL TANK LEAKS

Opened Jan 16, 2003
Closed Jun 11, 2003

THE OFFICE OF DEFECTS INVESTIGATION OPENED THISINVESTIGATION ON JANUARY 16, 2003.THE BASIS FOR OPENING THE INVESTIGATION WAS 15 CONSUMER REPORTS ALLEGING GASOLINE LEAKING FROM THE FUEL STORAGE TANK.VOLVO PROVIDED 43 ADDITIONAL REPORTS IN ITS RESPONSE TO THE PRELIMINARY EVALUATION, 4 OF WHICH WERE DUPLICATES OF THE 15 ODI REPORTS. THIS INVESTIGATION HAS BEEN UPGRADED FOR FURTHER STUDY.

FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .