Owner-reported complaints naming the body or structure system, filed with NHTSA
Data refreshed
Reports naming the vehicle structure, frame, body panels, doors, hood and trim. Every record below is an owner-reported complaint about the 1996 Volvo 850 submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 10 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
CUSTOMER STATES THAT SHE BEGAN TO DETECT CREAKING SOUNDS EVERY TIME SHE OPENED AND CLOSED THE FRONT DOOR ON THE DRIVER' SIDE**CC THE CONSUMER WAS INFORMED THERE WAS A CRACK IN THE FRAME OF THE DOOR. *JB
1996 VOLVO 850 WAGON TAILGATE HYDRAULIC HINGE JACK. JACK REPEATEDLY FAILED TO HOLD UP THE TAILGATE WHEN TEMPERSTURE DROPS BELOW 52 DEGREE, OR WHILE PARKED IN UPHILL POSITION. ON DECEMBER 18, 2003, IT ALMOST FELL ON MY 5 AND 3 YEARS OLD; I AM THANKFUL THAT I STILL HAD A TALL LARGE BOX IN THE WAY WHEN THAT HAPPENED. I COULD SEEN SERVE INJURIES OR FATALITIES MAY OCCUR TO THE LITTLE ONES JUST HAPPEN TO STAND IN THE WAY. IT LANDED ON ME SEVERAL TIMES AFTERWARD, THUS MY TRACKING OF THE TAILGATE OPERATION. NOTICE SHOULD BE SEND TO PARENTS TO NOT ALLOW THEIR LITTLE ONES STANDING BEHIND THE CAR WHILE THE GATE IS UP.
THE DASHBOARD IS SEPARATING FROM THE FRAME. CONSUMER IS CONCERNED THAT THE AIR BAG WILL DEPLOY INADVERTENTLY.*AK
DRIVER'S SIDE DOOR HINGE MADE NOISES. TOOK VEHICLE TO SHOP & WAS INFORMED THAT HINGES WOULD NEED TO BE WELDED BACK ON. *LA
FRONT DOOR STAY ATTACHING LUGS (6817408) BREAK WELD. WEAK DESIGN, DOOMED TO FAIL. SERVICE BULLETIN (881807) IN 1995. NEWER CARS SAME PROBLEM BODY SHOP REPAIR $150/DOOR. VOLVO SHOULD REPAIR. *AK
A CRACK DEVELOPED ON THE "HIGH STRENGTH STEEL SAFETY CAGE" ADJACENT TO THE AREA WHERE THE DRIVER'S DOOR STOP IS WELDED TO IT. I HAVE REQUESTED THAT THE CRACKED DOOR PILLAR PORTION OF THE "HIGH STRENGTH STEEL SAFETY CAGE" BE REPLACED. VOLVO CARS OF NORTH AMERICA, INC.'S RESPONSE HAS BEEN THAT IT IS NOT THEIR PROBLEM. I HAVE ALSO REQUESTED THAT IT BE COVERED BY THE EXTENDED WARRANTY I PURCHASED, BUT THEY HAVE MADE SEVERAL ATTEMPTS TO CALL THE CRACKED AREA THINGS THAT WOULD NOT BE COVERED BY THEIR LIBERAL BETWEEN THE LINES INTERPRETATION OF THE CONTRACT WHICH IS ALSO WITH VOLVO CARS OF NORTH AMERICA, INC. THEIR FINAL RESPONSE WAS, "WHILE WE REGRET YOU MAY NOT CONCUR, VOLVO CARS OF NORTH AMERICA, INC., WILL NOT RESPOND OR CONSIDER THIS MATTER FURTHER". THE DEALER BODY SHOP ADVISOR ESTIMATED THE REPAIR AT OVER $1,200.00. REPLACEMENT REQUIRES REMOVAL OF THE DRIVER'S DOOR, WINSHIELD, AND DASHBOARD.*AK
DOOR HINGE SECTION FASTENED TO SHEET METAL HAS FAILED ON DRIVERS SIDE. FAILURE IS STRUCTURAL TEAR CAUSING MOVEMENT OF DOOR CONTROL COMPONENT OF DRIVERS DOOR HINGE (BETWEEN TWO MAJOR HINGES). COMPONENT MOVES FLEXING SECTION OF DOOR FRAME ABOUT 1 1/2 INCHES LONG AS DOOR IS OPENING AND CLOSING, CAUSING EXPANSION OF METAL TEAR. *AK
DRIVER'S SIDE DOOR HINGE WOULD MAKE NOISES. TOOK VEHICLE TO BODY SHOP & WAS INFORMED THAT HINGES WOULD NEED TO BE REWELDED BACK ON. *AK
POWER STEERING LEAK, CAUSING POOR STEERING, AND THE PUMP MAKES A LOUD NOISE WHEN TURNING. ALSO, DRIVER'S DOOR HINGE BROKE, CAUSING THE DOOR TO SWING BACK ON ITS OWN WHEN OPENING. THE DEALER HAS BEEN CONTACTED. *AK
GAS LINE AND BRAKE LINE PROTECTIVE STRIP AT THE BOTTOM OF VEHICLE FELL OFF PARTIALLY.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .