RoadVitals

1994 Volvo 854 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Apr 11, 2008
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 1994 Volvo 854, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Fuel system2100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Fuel system

Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.

2
reports

From owner reports, verbatim

TL*THE CONTACT OWNS A 1994 VOLVO 854. AFTER THE CONTACT INSERTED GASOLINE INTO THE VEHICLE, HE NOTICED A LEAK NEAR THE EXTERIOR OF THE FUEL TANK. THE DEALER STATED THAT ALTHOUGH HE WAS EXPERIENCING THE SAME FAILURE REFERENCED IN NHTSA CAMPAIGN ID NUMBER 04V368000 (FUEL SYSTEM, GASOLINE:STORAGE), HIS VIN WAS NOT INCLUDED IN THE RECALL. THE CONTACT WOULD HAVE TO PAY FOR THE REPAIRS. THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE UNKNOWN.

NHTSA ID 10224193 · filed Apr 11, 2008

HISTORY OF FUEL ODOR IN AND AROUND VEHICLE AFTER FILLING TANK.USUALLY DISSIPATED UPON DRIVING AND WAS ATTRIBUTED TO SPILLAGE. IN JULY 2000 THE VEHICLE WAS PARKED OVERNITE FOLLOWING FUELING AND A LARGE AMOUNT OFF GASOLINE, POSSIBLY OVER 1 LITER FORMED A POOL UNDER THE CAR. AN ACTIVE LEAK WAS NOTED. AFTER DRIVING 50= MILES THE LEAK STOPPED. I ASSUMED THE AUTO SHUT OFF ON THE SERVICE STATION PUMP HAD FAILED AND TOOK CARE NOT TO FILL TANK COMPLETELYON SUBSEQUENT FUELING. AGAININ SEPT 2000 THE PROBLEM RECURRED IN MY GARAGE. I TOOK THE CAR TO MY LOCAL VOLVO DEALER. THEY FOUND THAT THE TANK LEAKED AT A SEAM WHERE THE FUEL OUTLET PIPE ATTACHED TO THE TOP OF THE FUEL TANK. THIS IS A PROTECTED LOCATION AND THERE WAS NO SIGN OF PHYSICAL DAMAGE NOR HAD THE VEHICLE BEEN IN A COLLISION. THE LEAK IS PROBABLY DUE TO A LATENT DEFECT IN THE TANK AT MANUFACTURE. THE TANK WAS REPLACED AND I HAVE IT AVAILABLE FOR INSPECTION.

NHTSA ID 732085 · filed Sep 21, 2000

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .