1992 Volvo 960 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1992 Volvo 960, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine1463.6%
- Electrical522.7%
- Airbags14.5%
- Steering14.5%
- Tires & wheels14.5%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
1992 960 STALLS WHILE DRIVING. *TS THE DEALER ATTEMPTED TO REMEDY THE PROBLEM. THE VEHICLE CONTINUED TO STALL WHILE DRIVING AT HIGH SPEEDS. THE VEHICLE WOULD MAKE A JERKING MOTION BEFORE SHUTTING OFF. THE VEHICLE WOULD ALSO STALL WHILE PARKING. THE POWER WINDOWS AND DOOR LOCKS MALFUNCTIONED. THE BATTERY DIED IF THE VEHICLE WAS PARKED FOR 1 DAY. THE VEHICLE WAS TAKEN TO THE DEALER AND IT WAS DETERMINED THAT THERE WAS AN ELECTRICAL DRAIN ON THE CIRCUIT FOR THE POWER WINDOWS AND SHIFTLOCK CIRCUIT. *NM
TIMING BELT FAILED, DEALER REPLACED THE TIMING BELT, DRIVE BELT, CAMSHAFT SENSOR AND HAD TO REBUILD THE CYLINDER HEAD WITH NEW VALVES. *SLC *MJ *DT PH (DAUGHTER LUCY PICARDI ON BEHALF OF MOTHER) *JB *CB
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
1992 VOLVO 960 SERIES STALLED WHILE DRIVING AT HIGH SPEEDS. THE POWER WINDOWS AND LOCKS ALSO CEASED FUNCTIONING WHEN THE VEHICLE STALLED. *KB THE VEHICLE JERKED PRIOR TO STALLING. THE VEHICLE BATTERY WOULD GO DEAD IF PARKED ONE DAY. THE VEHICLE WAS TAKEN TO THE DEALER TWICE BUT THEY WERE UNABLE TO CORRECT THE PROBLEM. *NM
1992 960 STALLS WHILE DRIVING. *TS THE DEALER ATTEMPTED TO REMEDY THE PROBLEM. THE VEHICLE CONTINUED TO STALL WHILE DRIVING AT HIGH SPEEDS. THE VEHICLE WOULD MAKE A JERKING MOTION BEFORE SHUTTING OFF. THE VEHICLE WOULD ALSO STALL WHILE PARKING. THE POWER WINDOWS AND DOOR LOCKS MALFUNCTIONED. THE BATTERY DIED IF THE VEHICLE WAS PARKED FOR 1 DAY. THE VEHICLE WAS TAKEN TO THE DEALER AND IT WAS DETERMINED THAT THERE WAS AN ELECTRICAL DRAIN ON THE CIRCUIT FOR THE POWER WINDOWS AND SHIFTLOCK CIRCUIT. *NM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
AIR BAG WARNING LIGHT REMAINS ILLUMINATED, INDICATING MALFUNCTION WITHIN THE SYSTEM. CAUSE UNKNOWN. DEALER CANNOT IDENTIFY THE PROBLEM. PLEASE GIVE ANY FURTHER DETAILS. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
WHILE DRIVING THE VEHICLE SUDDENLY SWERVED AND RESULTED IN COLLISION WITH THE ROAD BARRIER. *MJS
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
PROBLEM CONSISTED OF TREAD SEPARATION DESPITE PROPER INFLATION OF 40 PSI AND MAINTAINING 50 MPH MAXIMUM SPEED LIMIT. IN CONTACTING LOCAL FIRESTONE / BRIDGESTONE DEALER TO CLAIM A REPLACEMENT BY MANUFACTURER WARRANTY FOR THIS VEHICLE SAFETY ITEM, I WAS INFORMED THAT THE OFFICIAL DECISION FROM 'HEADQUARTERS' WAS THAT MY WARRANTY CLAIM WOULD NOT BE HONORED DUE TO THE TIRE BEING "IN A HOT TRUNK FOR TEN YEARS". IF THIS IS THE OFFICIAL STANCE OF FIRESTONE / BRIDGESTONE THEY SHOULD PROVIDE A WRITTEN NOTICE TO ALL AFFECTED EARLY MODEL VOLVO OWNERS WITH THIS SPARE TIRE THAT THEIR TIRES HAVE A 'SHELF LIFE' AND NEED TO BE DISCARDED AFTER A PERIOD OF TIME DESPITE NO OUTWARD SIGNS TO THE CONTRARY. THIS SPARE TIRE HAS SEEN LIMITED USE AS CAN BE SEEN BY THE DEPTH OF THE TREAD AND IS NOT SHOWING ANY SIGNS OF 'DRY ROT'. IN FACT, IT APPEARS TO HAVE BEEN COATED WITH A PRESERVATIVE THAT HAS LEFT THE TIRE'S EXTERIOR FLEXIBLE AND FREE OF ANY CRACKS OR OUTWARD SIGNS OF AGING. FOR YOUR REFERENCE, THE ENTIRE DOT CODE ON THE TIRE'S SIDE WALL IS WF P7 B2E T441 AND THERE IS A NOTATION THAT THE TIRE WAS MADE IN SPAIN. I CAN ALSO PROVIDE NHTSA WITH PHOTOS OF THE TIRE IN QUESTION VIA E-MAIL OR SHIP YOU THE ACTUAL TIRE FOR YOUR INDEPTH EXAMINATION IF PROVIDED A FED-EX OR UPS ACCOUNT NUMBER AND A SHIPPING ADDRESS. PLEASE FEEL FREE TO CONTACT ME IF I CAN PROVIDE YOU WITH ANY ADDITONAL INFORMATION OR ANSWER ANY QUESTIONS YOU MAY HAVE. I WILL BE E-MAILING THE NHTSA WEBMASTER A TRANSCRIPT OF THE E-MAIL COMMUNICATION THAT HAS BEEN CIRCULATED BETWEEN FIRESTONE / BRIDGESTONE, VOLVO CUSTOMER SERVICE AND I.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .