2011 Volvo C30 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2011 Volvo C30, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Visibility735.0%
- Body & structure315.0%
- Steering210.0%
- Suspension210.0%
- Tires & wheels210.0%
- Other / unspecified15.0%
- Electrical15.0%
- Engine15.0%
- Airbags15.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
The top of the windshield no longer adheres to the body of the vehicle. My searches of the internet have found multiple instances of the Volvos where the top part of the windshield is no longer attached to the vehicle. Here is a link to the Auto Glass Safety Council describes the issue (https://agsc.org/volvo-glass-bonding-issue/). Volvo Car USA LLC recently issued a statement that all windshield replacements on Volvo vehicles must be performed “according to Volvo standards at an authorized facility, using only Volvo Genuine Windshields and adhesives.” Their reasoning for this statement is, “The Volvo windshield is an integral part of our vehicles. Not only does it provide an undistorted view, it serves as a critical structure component on the vehicle." Since Volvo is claiming there is a safety component to the windshield and only Volvo can fix it, they should recall and repair all vehicles with this known issue.
The entire top edge of the windshield is no longer sealed to the car. Water gets in. If all of the windows are closed, the windshield briefly pops out a little bit as the door is closed.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
Windshield seal bond at top failed resulting in loose front windshield not being attached to the body. This is leaking water and leading to poor visibility that is dangerous but more concerning is the detachment of the window from the body. This would be extremely dangerous in a collision. The car is parked at this time due to being dangerous to drive.
THE WINDSHIELDS ON THESE CARS MAZDA 3 AND THE FORD FOCUS ALL SAME PLATFORM ARE KNOWN TO HAVE A BONDING DEFECT WHEN THEY WERE BUILT. THIS SHOULD HAVE BEEN A RECALL FOR SAFETY.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
TL* THE CONTACT OWNED A 2011 VOLVO C30. THE CONTACT STATED THAT WHILE DRIVING AT 35 MPH, THE STEERING WHEEL FAILED WHILE MAKING A LEFT TURN. THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO A CURB. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES SUSTAINED. THE VEHICLE WAS DESTROYED AND TOWED TO ROCKO'S AUTO REPAIR OF BLACKWOOD, NEW JERSEY. THE DEALER WAS NOT CONTACTED ABOUT THE ISSUE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS UNKNOWN.
TIRES WERE SHAKY WHEN I BOUGHT A BRAND NEW C30 VOLVO. ASKED DEALER TO FIX-SALES MANAGER SAID NOTHING WAS WRONG (FT. MEYERS, FL VOLVO). AND HE WOULD TELL VOLVO I WAS CRAZY. TIRES WERE DESTROYED AT 10,000. WENT TO DIFFERENT VOLVO DEALER IN SARASOTA AND ST. PETE-NOTHING IS WRONG. DEALER REPLACED TIRES AT 10,000. CAR STILL SHAKING. NOW I AM ON MY 3RD SET OF TIRES AT 50,000. SOMETHING IS VERY WRONG WITH THIS CAR-DO NOT BUY ONE VOLVO WILL NOT FIX. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
TIRES WERE SHAKY WHEN I BOUGHT A BRAND NEW C30 VOLVO. ASKED DEALER TO FIX-SALES MANAGER SAID NOTHING WAS WRONG (FT. MEYERS, FL VOLVO). AND HE WOULD TELL VOLVO I WAS CRAZY. TIRES WERE DESTROYED AT 10,000. WENT TO DIFFERENT VOLVO DEALER IN SARASOTA AND ST. PETE-NOTHING IS WRONG. DEALER REPLACED TIRES AT 10,000. CAR STILL SHAKING. NOW I AM ON MY 3RD SET OF TIRES AT 50,000. SOMETHING IS VERY WRONG WITH THIS CAR-DO NOT BUY ONE VOLVO WILL NOT FIX. *TR
REAR TIRES WORN OUT ON THE INSIDE AFTER 21000 MILES. 1/32 INSIDE AND 5/32 OUTSIDE TREAD DEPTH. UNACCEPTABLE TIRE WEAR AS FRONT TIRES HAVE 4 TO 5/32 TREAD DEPTH ACROSS THE TIRE. NOTE THAT THIS CAR IS ALSO A FRONT WHEEL DRIVE VEHICLE! AUTHORIZED VOLVO DEALER HAS ALIGNED VEHICLE AT LEAST 2 TIMES! ALIGNMENT SAID TO BE WITHIN SPEC BOTH TIMES! I HAVE FACTS SUPPORTING THIS TO BE COMMON OCCURRENCE ON VOLVO C-30 MODELS AS WITNESSED BY OWNERS ON INTERNET FORUMS. EXCESSIVE TIRE WEAR BY UNSUSPECTING DRIVER CAN AND WILL LEAD TO UNEXPECTED TIRE BLOW OUT CAUSING DAMAGE TO VEHICLE AND/OR INJURY OR DEATH. SIMILAR INCIDENTS HAVE HAPPENED AS POINTED OUT IN THE FORD EXPLORER ACCIDENTS IN THE 1990S! *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
TIRES WERE SHAKY WHEN I BOUGHT A BRAND NEW C30 VOLVO. ASKED DEALER TO FIX-SALES MANAGER SAID NOTHING WAS WRONG (FT. MEYERS, FL VOLVO). AND HE WOULD TELL VOLVO I WAS CRAZY. TIRES WERE DESTROYED AT 10,000. WENT TO DIFFERENT VOLVO DEALER IN SARASOTA AND ST. PETE-NOTHING IS WRONG. DEALER REPLACED TIRES AT 10,000. CAR STILL SHAKING. NOW I AM ON MY 3RD SET OF TIRES AT 50,000. SOMETHING IS VERY WRONG WITH THIS CAR-DO NOT BUY ONE VOLVO WILL NOT FIX. *TR
REAR TIRES WORN OUT ON THE INSIDE AFTER 21000 MILES. 1/32 INSIDE AND 5/32 OUTSIDE TREAD DEPTH. UNACCEPTABLE TIRE WEAR AS FRONT TIRES HAVE 4 TO 5/32 TREAD DEPTH ACROSS THE TIRE. NOTE THAT THIS CAR IS ALSO A FRONT WHEEL DRIVE VEHICLE! AUTHORIZED VOLVO DEALER HAS ALIGNED VEHICLE AT LEAST 2 TIMES! ALIGNMENT SAID TO BE WITHIN SPEC BOTH TIMES! I HAVE FACTS SUPPORTING THIS TO BE COMMON OCCURRENCE ON VOLVO C-30 MODELS AS WITNESSED BY OWNERS ON INTERNET FORUMS. EXCESSIVE TIRE WEAR BY UNSUSPECTING DRIVER CAN AND WILL LEAD TO UNEXPECTED TIRE BLOW OUT CAUSING DAMAGE TO VEHICLE AND/OR INJURY OR DEATH. SIMILAR INCIDENTS HAVE HAPPENED AS POINTED OUT IN THE FORD EXPLORER ACCIDENTS IN THE 1990S! *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
TIRES WERE SHAKY WHEN I BOUGHT A BRAND NEW C30 VOLVO. ASKED DEALER TO FIX-SALES MANAGER SAID NOTHING WAS WRONG (FT. MEYERS, FL VOLVO). AND HE WOULD TELL VOLVO I WAS CRAZY. TIRES WERE DESTROYED AT 10,000. WENT TO DIFFERENT VOLVO DEALER IN SARASOTA AND ST. PETE-NOTHING IS WRONG. DEALER REPLACED TIRES AT 10,000. CAR STILL SHAKING. NOW I AM ON MY 3RD SET OF TIRES AT 50,000. SOMETHING IS VERY WRONG WITH THIS CAR-DO NOT BUY ONE VOLVO WILL NOT FIX. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
WHILE DRIVING AT ABOUT 65 MPH IN HEAVY TRAFFIC ON I-87, THE CAR SUDDENLY LOST ALL POWER, INCLUDING ALL ELECTRICAL INSTRUMENTS AND ACCESSORIES. IT ROLLED TO A STOP AND COULD NOT BE STARTED BY PUSHING (THE CAR HAS A MANUAL TRANSMISSION).
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
WHILE DRIVING AT ABOUT 65 MPH IN HEAVY TRAFFIC ON I-87, THE CAR SUDDENLY LOST ALL POWER, INCLUDING ALL ELECTRICAL INSTRUMENTS AND ACCESSORIES. IT ROLLED TO A STOP AND COULD NOT BE STARTED BY PUSHING (THE CAR HAS A MANUAL TRANSMISSION).
Too few reports in this category for a page of its own — they appear in the full complaint list.
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
TL* THE CONTACT OWNED A 2011 VOLVO C30. THE CONTACT STATED THAT WHILE DRIVING AT 35 MPH, THE STEERING WHEEL FAILED WHILE MAKING A LEFT TURN. THE CONTACT LOST CONTROL OF THE VEHICLE AND CRASHED INTO A CURB. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES SUSTAINED. THE VEHICLE WAS DESTROYED AND TOWED TO ROCKO'S AUTO REPAIR OF BLACKWOOD, NEW JERSEY. THE DEALER WAS NOT CONTACTED ABOUT THE ISSUE. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS UNKNOWN.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .