2025 Volvo EX40 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2025 Volvo EX40, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes120.0%
- Electrical120.0%
- Engine120.0%
- Powertrain (other)120.0%
- Steering120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
Applied the brake while approaching a crosswalk and suddenly multiple warning notifications appeared on dashboard (brake failure, collision avoidance system not functioning, etc) and every warning light started flashing. Lost power steering and brakes. Had to swerve to avoid a pedestrian. Once stopped could not change the gear, engage the parking brake, or turn the car off. I was on a hill and needed to keep my foot on the brake pedal forcefully to avoid rolling down the hill into cross traffic. Firefighters chocked the wheels but could not disable the car. Car was towed to the dealership.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
1st incident vehicle lost power while operating. No way to operate hazard lights, steering and control goes dead and wipers come on continuously. 2nd incident car was returned from dealership. 15 minutes into the drive on a busy highway in Minneapolis car began to replicate similar issues. No power, no hazard lights, SOS call button is inoperable as well.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
1st incident vehicle lost power while operating. No way to operate hazard lights, steering and control goes dead and wipers come on continuously. 2nd incident car was returned from dealership. 15 minutes into the drive on a busy highway in Minneapolis car began to replicate similar issues. No power, no hazard lights, SOS call button is inoperable as well.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
1st incident vehicle lost power while operating. No way to operate hazard lights, steering and control goes dead and wipers come on continuously. 2nd incident car was returned from dealership. 15 minutes into the drive on a busy highway in Minneapolis car began to replicate similar issues. No power, no hazard lights, SOS call button is inoperable as well.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
Applied the brake while approaching a crosswalk and suddenly multiple warning notifications appeared on dashboard (brake failure, collision avoidance system not functioning, etc) and every warning light started flashing. Lost power steering and brakes. Had to swerve to avoid a pedestrian. Once stopped could not change the gear, engage the parking brake, or turn the car off. I was on a hill and needed to keep my foot on the brake pedal forcefully to avoid rolling down the hill into cross traffic. Firefighters chocked the wheels but could not disable the car. Car was towed to the dealership.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .