2005 Volvo S40 Owner Complaints

The contact's wife owns a 2005 Volvo S40. The contact stated the vehicle was difficult to start for several days. Eventually, the failure progressed and the vehicle was not able to start. The check engine warning light was illuminated. The vehicle was repaired by the contact, a previous Volvo technician. The contact stated the failure was due to the pump electrical module being located out of the vehicle. The contact spoke with the dealer. The contact referenced The manufacturer was made aware of the failure. The approximate failure mileage was 170,000.

NHTSA ID

11578530

Incident

Feb 21, 2024

Mileage

170,000 mi

The drivers seat belt does not lock/latch in properly. Everytime I enter the vehicle I reach for my seat belt and buckle myself, well so I thought I did. When I insert the belt it seems as though its buckles however once I start to drive the belt comes un done and it i always have to pull over to put it back on becsuse it locks the seat belt so I'm not able to just buckle back in.

NHTSA ID

11546212

Incident

Apr 3, 2023

TL* THE CONTACT OWNS A 2005 VOLVO S40. THE CONTACT STATED THAT WHILE DRIVING AT AN UNDISCLOSED SPEED, THE VEHICLE STALLED WITHOUT WARNING. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE FUEL PUMP ELECTRONIC MODULE HAD FAILED DUE TO RUSTING AND CORROSION. THE FUEL PUMP ELECTRONIC MODULE WAS REPLACED AND THE FAILURE WAS REMEDIED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND THE CONTACT WAS INFORMED THAT THE VEHICLE WAS NOT INCLUDED IN THE NHTSA CAMPAIGN NUMBER 08V033000 (FUEL SYSTEM, GASOLINE). THE CONTACT STATED THAT THE VEHICLE HAD EXPERIENCED THE FAILURE LISTED IN THE RECALL. ADDITIONALLY, THE VEHICLE WAS ORIGINALLY SOLD IN THE STATE OF CALIFORNIA AND HAD BEEN DRIVEN IN THE STATE OF MICHIGAN THE PAST 6 YEARS. THE FAILURE MILEAGE WAS 147,000.

NHTSA ID

11403711

Incident

Mar 15, 2021

Mileage

147,000 mi

I WAS TOLD BY SHOP THAT WORK ON MY CAR THAT WERE A RECALL ON THE PVC VAUL ON THE 2005 VOLV S40 2.4. *TR

NHTSA ID

11329021

Incident

Jun 14, 2020

Mileage

84,000 mi

MY VEHICLE SHUTS OFF WHILE IM DRIVING IT. I TOOK IT TO A MECHANIC 3 TIMES AND WAS ADVISED ITS AN ISSUE WITH THE FUEL PUMP. I WAS ALSO ADVISED THIS IS AN KNOWN ISSUE WITH THIS PARTICULAR VEHICLE AND WAS PROVIDED A NHTSA CAMPAIGN ID # 08V033000. *TR

NHTSA ID

11327540

Incident

Jun 4, 2020

Mileage

168,505 mi

2005 VOLVO S40 ENGINE AIR CONDITIONING MALFUNCTIONED. WHEN THE PROBLEM FIRST BEGUN THE CAR WOULD BE COOL AT START THEN GET WARM UNTIL ONE DAY THE AIR CONDITIONING JUST QUIT WORKING. I READ ON THIS FORUM AUTHORIZED VOLVO DEALERSHIP ADMITS THIS IS A COMMON PROBLEM IN THIS YEAR/MAKE/MODEL. THE COMPRESSOR CLUTCH OR COMPRESSOR OR BOTH REQUIRED REPLACING. IN A CLASS ACTION LAWSUIT [FILED 2018] HTTP://WWW.AUTOPARTSCLASS.COM/INDEX.PHP INCLUDES THE 2005 VOLVO S40 AIR CONDITIONING UNIT: [SEE BELOW] CONGRATULATIONS! YOUR 2005 VOLVO S40 IS INCLUDED IN THE FOLLOWING AUTO PARTS CASES: IN RE: INSTRUMENT PANEL CLUSTERS IN RE: AIR CONDITIONING SYSTEMS IN RE: ALTERNATORS IN RE: WINDSHIELD WIPER SYSTEMS

NHTSA ID

11246021

Incident

Jun 1, 2017

Mileage

86,000 mi

TL* THE CONTACT OWNS A 2005 VOLVO S40. THE CONTACT STATED THAT THE REAR PASSENGER SIDE CARPET WAS SATURATED WITH WATER AFTER A RAIN STORM. THE CAUSE OF THE FAILURE WAS NOT DETERMINED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE LOCAL DEALER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 45,506. *BF CONSUMER STATED THE FOAM IN ROOF OF CAR IS CRUMBLING AND ROOF SEAMS ARE NO LONGER INTACT.*JB

NHTSA ID

11194589

Incident

Mar 1, 2019

Mileage

45,506 mi

THE CAR STARTS MISSING THEN STALLS OUT AFTER ABOUT 30MILES OF DRIVING IT STALLED IN THE MIDDLE OF CROSSING A 4 LANE AND WAS ABOUT HIT.IT IS THE PEM THEY HAD RECALLS ON THEM BUT NOT MY CAR FOR SOME REASON

NHTSA ID

11111793

Incident

May 10, 2018

Mileage

205,000 mi

EVERY TIME I DRIVE THE CAR IT MISSES A LITTLE THEN IT JUST SHUTS DOWN LIKE IT'S NOT GETTING ANY FUEL THE CAR DON'T DIE JUST WON'T PULL OUT I TRIED TO CROSS A 4 LANE AND IT STALLED IN THE FIRST LANE AND I ABOUT GOT HIT IN THE SIDE IT ALSO DID IT ON THE INTERSTATE.IT IS VERY DANGEROUS I WAS TOLD IT'S THE ELECTRONIC FUEL MODULE,OR PEN AND WAS TOLD THERE WAS A RECALL ON THAT PART ALL OVER THE INTERNET BUT VOLVO SAID THERE WASN'T WHICH I DON'T BELIEVE WHY WOULD THE INTERNET SAY THERE WAS ON LIKE 5OR NOTRE WEBSITES

NHTSA ID

11111408

Incident

May 12, 2018

Mileage

200,011 mi

TL* THE CONTACT OWNS A 2005 VOLVO S40. WHEN THE VEHICLE WAS STARTED, THERE WAS AN ABNORMAL VIBRATION COMING FROM THE VEHICLE. UPON OPENING THE HOOD AND CHECKING THE ENGINE, THE CONTACT NOTICED THAT THE PASSENGER SIDE OF THE ENGINE WAS FRACTURED. THE CONTACT STATED THAT THE FRACTURE WAS ALONG THE TOP SIDE OF THE ENGINE. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED. A DEALER WAS NOT CONTACTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 43,000.

NHTSA ID

11057910

Incident

Dec 31, 2017

Mileage

43,000 mi

CAR LOOSING POWER AND ENGINE MISSING AT HIGHWAY SPEEDS. ENGINE LIGHT WENT ON. FAILURE OF FUEL PRESSURE MONITOR.

NHTSA ID

11054027

Incident

Oct 6, 2013

Mileage

62,000 mi

CAR IS ALL OF A SUDDEN ACCELERATING ON ITS OWN. IT HAS HAPPENED A HANDFUL OF TIMES WITHIN THE LAST MONTH. I WILL MAKE A TURN, LET OFF THE GAS PEDDLE AND THEN THE CAR WILL JUST JERK FORWARD REVVING UP THE RPMS AND ACCELERATING ON ITS OWN.

NHTSA ID

11041947

Incident

Oct 28, 2017

Mileage

122,115 mi

FUEL PUMP CONTROL MODULE (PEM) FAILS DURING WET CONDITIONS. CAR WILL CRANK LIKE NORMAL BUT WILL NOT START. LET CAR DRY OUT FOR A FEW DAYS AND THEN THE CAR WILL RUN NORMAL AGAIN.

NHTSA ID

10985089

Incident

May 12, 2017

Mileage

156,000 mi

TAKATA RECALL. I HAD ENGINE STUTTERING AT HIGH SPEED. MY FUEL PRESSURE SENSOR FAILED AND WAS REPLACED. I QUESTION WHY IT IS NOT COVERED UNDER THE NHTSA CAMPAIGN I.D. # 07V226000 WHICH IS FOR THE SAME PART IN THE SAME ENGINE BUT IN 2004 S60 MODELS.

NHTSA ID

10955043

Incident

Feb 15, 2017

Mileage

95,000 mi

TL* THE CONTACT OWNS A 2005 VOLVO S40. THE CONTACT STATED THAT THE KEY WAS UNABLE TO TURN AND PREVENTED THE VEHICLE FROM STARTING. THE BATTERY WAS TESTED BY AN INDEPENDENT MECHANIC WHO WAS UNABLE TO DETERMINE THE CAUSE OF THE FAILURE. THE VEHICLE WAS TO BE TAKEN TO A DEALER FOR DIAGNOSTIC TESTING. THE VEHICLE WAS UNABLE TO BE DRIVEN. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.

NHTSA ID

10954466

Incident

Nov 28, 2016

[THIS IS A PREVENTATIVE COMPLAINT. NO INJURY SUSTAINED.] THIS CAR HAS A FAILED PASSENGER SEAT SENSOR THAT WHEN DEPRESSED ACTIVATES THE PASSENGER SIDE AIR BAG. THIS VEHICLE ALSO HAS A DRIVER SIDE SEAT BELT THAT CLICKS AND THEN CAN BE PULLED OUT OF THE LOCKING HARNESS. THESE ITEMS ARE NOT RECALLED BY THE MANUFACTURE BUT, IN MY OPINION, SHOULD BE FOR CUSTOMER SAFETY.

NHTSA ID

10944096

Incident

Jan 1, 2013

Mileage

80,000 mi

TL* THE CONTACT OWNS A 2005 VOLVO S40. THE CONTACT STATED THAT WHILE DRIVING AT 55 MPH, THE STEERING WHEEL AND ENTIRE VEHICLE BEGAN TO SHAKE AS THERE WAS AN ABNORMAL NOISE. IN ADDITION, THE AIR CONDITIONER, RADIO, HORN AND SUN ROOF FAILED TO FUNCTION WHEN ACTIVATED. THE SRS WARNING LIGHT ILLUMINATED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE ECM, FRONT AXLES AND STRUTS NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 194,000.

NHTSA ID

10861933

Incident

Apr 27, 2016

Mileage

194,000 mi

TL* THE CONTACT OWNS A 2005 VOLVO S40. WHILE DRIVING APPROXIMATELY 40 MPH, THE BRAKE PEDAL TRAVELED TO THE FLOORBOARD AND FAILED TO STOP THE VEHICLE WHEN IT WAS DEPRESSED. THE VEHICLE SHOOK VIOLENTLY WITHOUT WARNING. THE CONTACT LET THE VEHICLE DECELERATE AND THEN SLOWLY DROVE THE VEHICLE TO THE DEALER. THE DEALER DIAGNOSED THAT THE BRAKE VACUUM PUMP FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND INFORMED THE CONTACT THAT THE VIN WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 03V474000 (SERVICE BRAKES, HYDRAULIC). THE APPROXIMATE FAILURE MILEAGE WAS 70,000.

NHTSA ID

10821737

Incident

Jan 1, 2016

Mileage

70,000 mi

TL* THE CONTACT OWNS A 2005 VOLVO S40. WHILE DRIVING VARIOUS SPEEDS ON SEVERAL OCCASIONS, THE CHECK ENGINE WARNING LIGHT ILLUMINATED AND THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE FUEL PUMP ELECTRONIC MODULE NEEDED TO BE REPLACED. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 08V033000 (FUEL SYSTEM, GASOLINE). THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 40,000.

NHTSA ID

10816978

Incident

Jul 2, 2014

Mileage

40,000 mi

INSERTED KEY IN IGNITION AND NOTHING HAPPENED. COMPUTER READS KEY ERROR TRY AGAIN. KEPT TRYING AND FINALLY STARTED. NEXT DAY SAME THING HAPPENED.

NHTSA ID

10721259

Incident

May 22, 2015

Mileage

90,000 mi

2005 VOLVO S40 FAULTY WIRE IN IGNITION SWITCH. CAR FAILS TO START. NO MESSAGES INITIALLY, THEN IMMOBILIZER LIGHT INDICATED. UNSURE OF EQUIPMENT MODEL. ORIGINAL TO FACTORY INSTALLED. *TR

NHTSA ID

10691394

Incident

Feb 15, 2015

OFTEN, THE HEADLAMPS BULBS FAIL, AFTER A FEW YEARS CHANGING BULBS, I FOUND OUT THAT DUE TO CONTACT BETWEEN DETACHMENT OF THE WIRING HARNESS COVER IS THE CAUSE OF THE FAILURE BULBS IN RIGHT AND LEFT HEADLAMPS. THE WIRING HARNESS INSTALLED BY THE MANUFACTURER DO NOT RESIST VOLTAGE AND HEAT. *TR

NHTSA ID

10621166

Incident

Dec 15, 2011

Mileage

37,000 mi

(S40 2.4I) INITIAL CAR MESSAGE: "BRAKE FAILURE, PULL OVER SAFELY." I CONTINUED TO DRIVE HOME SINCE I WAS A FEW BLOCKS AWAY. MESSAGE CHANGED TO "ANTI SKID SERVICE REQUIRED" THEN BACK TO BRAKE FAILURE AGAIN. DIFFICULTY ACCELERATING AFTER STOPPING, FELT LIKE THE PARKING BRAKE WAS ON BUT DROVE OK ONCE ACCELERATED. ATTEMPTED TO TURN OFF CAR BUT MESSAGE CHANGED TO "IMMOBILIZER, CHECK MANUAL" AND COULD NOT TURN KEY TO OFF POSITION. FROM WHAT I READ IN THE MANUAL, IT APPEARED THAT THE CARD DIDN'T RECOGNIZE IT WAS IN PARK. TURNED PARKING BRAKE ON AND OFF A FEW TIMES AND WAS ABLE TO TURN OFF CAR. BROUGHT TO LOCAL MECHANIC WHO REPLACED BRAKE PAD SENSOR AND ANTI-STOP SWITCH. --IN AND OUT OF AUTO REPAIR SHOP 4X OVER THE PAST MONTH W/THE SAME ISSUES AND NEW SYMPTOMS: WIPERS TURNED ON AUTOMATICALLY AND DON'T SHUT OFF AND NEW MESSAGE: ENGINE SYSTEM SERVICE URGENT. --MECHANIC REPLACED SOME RUSTED WIRES, BROUGHT TO A VOLVO DEALER WHO RESET COMPUTER AND DID NOT FIND ANY PROBLEMS. --STILL HAVING SAME ISSUES. CANNOT PUT CAR INTO DRIVE OR TURN OFF CAR WHEN BRAKE FAILURE OR ANTI-SKID MESSAGE APPEAR BUT IF I WAIT A FEW MINUTES, I CAN TURN THE CAR OFF AND ON A COUPLE OF TIMES TO GET TO THE ENGINE SYSTEM SERVICE URGENT MESSAGE AND I CAN THEN PUT IT INTO DRIVE. SOMETIMES ALL MESSAGES GO AWAY AND IT IS FINE FOR A FEW DAYS BUT THEN THE CAR JERKS FORWARD AS IF SOMEONE BUMPED THE CAR AND ALL MESSAGES APPEAR AGAIN. NEW MESSAGE: POWER STEERING MESSAGE FLASHED BRIEFLY .. ALTHOUGH THERE WAS NO PROBLEM W/THE STEERING. BRINGING TO ANOTHER VOLVO DEALER.. THE SAGA CONTINUES. --I READ PRIOR CONSUMER COMPLAINTS ON THIS SITE AND I ALSO HAD THE SUNROOF LEAKAGE PROBLEM IN 2013. ENTIRE FLOOR OF CAR WAS SOAKED, ESPECIALLY PASSENGER SIDE. TOOK 3 VISITS, WEEKS AND $900 TO GET IT FIXED. VOLVO FIRST CLEANED OUT THE CLOGGED LINE BUT CARPETS WERE WET AGAIN SO THEY THEN REPLACED THE ENTIRE LINE. *JS

NHTSA ID

10598364

Incident

May 2, 2014

Mileage

62,700 mi

CAR STALLS WITH OUT WARNING WHEN TRAVEL AT SPEEDS OF 0-65 MPH VERY DANGEROUS!! THERE ARE RECALLS RE: FUEL PRESSURE SENSORS FOR NEARLY ALL VOLVO MAKES EXCEPT THE S40 2005 THIS PART IS TRULY A DEFECTIVE ITEM AND NEEDS TO BE RECALLED BEFORE A DEATH OCCURS ON THE HIGHWAY!! I THOUGHT VOLVO WAS A SAFE RELIABLE CAR BUT I CAN HONESTLY SAY THIS CAR IS THE BIGGEST PIECE OF JUNK I HAVE EVER SPENT A LOT OF MONEY ON. THE TIRES BLEW OUT ON THE SIDES WHICH ALSO PUT ME IN DANGER THE INTERIOR HEADLINER FELL OFF AS WELL AS ALL OTHER MATERIAL ON THE DOORS ALL LEATHER IS LOOSE GEAR SHIFTER COVER FELL APART. GAS CAP BROKE GAS BUILDS TOO MUCH PRESSURE LOOSENING THE GAS CAP FREQUENTLY THESE ARE JUST SOME OF THE ISSUES I HAVE. VERY DISAPPOINTED IN THIS VEHICLE I KEEP MY CAR IN THE GARAGE. ONLY DRIVE TO AND FROM GROCERY SHOPPING AND DR APPTS PLEASE CONSIDER RECALLS ON THE IMPORTANT PARTS OF THE VEHICLE THAT CAN SAVE LIVES! *JS

NHTSA ID

10592271

Incident

Dec 6, 2012

Mileage

20,500 mi

3 OF THE 4 DOOR LOCK ACTUATORS ON MY CAR HAVE STOPPED WORKING. THIS HAPPENED RIGHT AFTER THE WARRANTY EXPIRED. THE LOCKS WILL NOT LONGER LOCK OR UNLOCK. THIS IS A SAFETY ISSUE. PLEASE LOOK AT REQUIRING VOLVO TO FIX THIS ISSUE. IT IS A KNOW ISSUE DUE TO FAULTY PARTS. *TR

NHTSA ID

10578969

Incident

Apr 17, 2009

Mileage

40,000 mi