2020 Volvo S60 Owner Complaints

See attached document for complaint.

NHTSA ID

11742020

Incident

Mar 22, 2026

The car has “detected” a crash many times and automatically stopped even on the highway. It jerks and to slam on the brakes and then keeps going. It’s very dangerous and I have a strong theory it’s the model in general and not an isolated situation with my car.

NHTSA ID

11638095

Incident

Jan 7, 2025

The contact owns a 2020 Volvo S60. The contact stated that while at a stop light, the vehicle erroneously drove forward and crashed into a second vehicle. The contact indicate that during the crash the collision avoidance feature did not activate. No injuries were reported. A police report was taken at the scene and the vehicle was towed away. The cause of the failure was not determined. The manufacturer and local dealer were notified of the incident. The failure mileage was 16,000.

NHTSA ID

11633726

Incident

Dec 28, 2021

Mileage

16,000 mi

It is unknown what caused this issue but ever since I bought my vehicle on April 5, 2021, I have been experiencing vibration issues when driving between 65-75 MPH. I have had my vehicle inspected at multiple Volvo Service Centers across Texas and no one can seem to figure out what is causing the vibration issues. My front rotors have been replaced 3 TIMES, my rear rotors have been replaced once, I have had multiple tire rotations, alignments and balancing from Volvo Service Centers and even from Discount Tire. With all of these items serviced/repaired/replaced, the vibration is still present in the steering wheel traveling at highway speeds. I went on a test drive today, 6/22/22, with a Volvo Service Technician and he confirmed that the vibration is valid. He also stated that the only thing left to do is to replace all 4 tires, at my cost, to see if the vibration goes away. He advised that when new cars are on the lot parked waiting to be sold, dealerships typically inflate the tires to about 50 PSI so as to avoid any "flat spots" on the tires. He also stated that many dealers also typically do not inflate tires on their new fleet due to the rough ride it causes. I have contacted Volvo regarding this issue without any remedy or advice. Additionally, my Volvo dealer cannot say for sure that they will reimburse me for tires, if I do choose to replace my current ones, even though this issue has been present since day 1.

NHTSA ID

11470504

Incident

Apr 5, 2021

Ongoing Problem as mentioned in Volvo's Technical Journal "Speed Dependent Vibrations at Highway Speeds" Ref No: TJ 20803.20.0 . At any speed of 75 mph and above the front continuously vibrates. The tires have been replaced two times in less than 2 weeks and road forced balanced by the dealership twice. The vibration does not go away. The dealership does not want to address the issue. The car is NEW.

NHTSA ID

11443977

Incident

Apr 1, 2021

I turned the car on and got an error message that said the turn indicator system failed. After trying to clear the message from the dash using the button on the steering wheel, I discovered that nothing on the steering wheel was working, including the windshield wipers or any buttons on the steering wheel. I called the manufacturer and they told me not to drive it and they towed it to the dealer. The dealer said they had see this before as either a software issue or electrical issue and would need to replace the stalks and buttons.

NHTSA ID

11421793

Incident

Jun 20, 2021

2020 VOLVO S60 T-6 R WENT IN FOR SERVICE AT VOLVO DEALER, 5/12/21, MILEAGE 24,018. TECHNICIAN NOTED REAR BRAKES LESS THAN 2MM & ROTORS GROOVED, NEEDS TO BE REPLACED. I WAS TOLD THIS IS NOT UNDER WARRANTY, IT'S NORMAL WEAR. THIS VEHICLE HAD SERVICE AT THE SAME DEALER ON 12/8/20, MILEAGE 16,952 THE SERVICE REPORT STATED, "BRAKES IN THE GREEN 7MM OR MORE". THE VEHICLE IS DRIVEN HIGHWAY MILES MAINLY, REGARDLESS OF THAT FACT, BRAKE PADS DON'T NOT WEAR DOWN 5MM IN 7,000 MILES ON A NEW CAR UNLESS THERE'S AN UNDERLYING PROBLEM, THERE HAS ALREADY BEEN A RECALL ON THE REAR AUTOMATIC PARK BRAKE, SEEMS LIKELY THAT THERE'S ADDITIONAL PROBLEMS WITH THE REAR BRAKES. THE REPLACEMENT COST ME $888.00

NHTSA ID

11416437

Incident

May 12, 2021

Mileage

24,018 mi

MY 2020 S60 T5 R-DESIGN HAD 3 BROKEN SENSORS, A SAFETY RECALL, MALFUNCTIONING BRAKES WHICH CAUSED THE CAR TO VEER, AND MOST RECENTLY A LEAKING A/C HOSE. ALL PROBLEMS FROM THE FACTORY (OUT OF THIN AIR) WITHIN THE FIRST 12 MONTHS OF MY LEASE. AFTER NUMEROUS COMPLAINTS TO VOLVO CAR USA, I WAS OFFERED A GENERIC AND DISMISSIVE ANSWER THAT VOLVO 'IS NOT IN THE POSITION' TO OFFER A TRADE ASSIST OR ANY HELP. NO EXPLANATION TO A LOYAL VOLVO CUSTOMER. THEY'RE SIMPLY 'SORRY' THAT I HAD TO TAKE OFF WORK TO SERVICE THEIR CAR AND WAS TOLD TO UBER HOME (NO COURTESY LOANER). AFTER THE MOST RECENT SERVICE VISIT, I DEMANDED VOLVO EITHER REPLACE THE CAR OR TERMINATE THE LEASE, BUT THE AGENT THOUGHT SERVICING THE VEHICLE 5 TIMES (BECAUSE PARTS WERE BREAKING) WAS ABSOLUTELY NORMAL. SHE WAS STUNNED I DO NOT HAVE A POSITIVE ATTITUDE NOW THAT MY CAR WAS FIXED. I DEMANDED CONTACT TO THE REGIONAL MANAGER, BUT MY AGENT (WHO TURNED OUT TO BE SUPERVISOR) REFUSED TO FORWARD ANY INFORMATION. MY CAR WOULD GO THROUGH A REVIEW PROCESS WITH 'SPECIAL PARAMETERS', BUT THE SUPERVISOR OF THE HEADQUARTERS OF VOLVO CARS USA WAS INCAPABLE OF ANSWERING WHAT THE PARAMETERS WERE, WHEN THIS REVIEW WOULD TAKE PLACE, OR WHO IS REVIEWING MY CASE' NOTHING WAS TRANSPARENT, AND FOR ALL I KNOW, THIS REVIEW COULD HAVE BEEN ARBITRARY. AS EXPECTED, 'VOLVO IS NOT IN THE POSITION'' VOLVO SENT AN AUTOMATED CUSTOMER SATISFACTION SURVEY, TO WHICH I PROVIDED FEEDBACK OF MY AWFUL EXPERIENCE. SADLY, THE SAME AGENT HANDLING MY CASE RESPONDED 'THANK YOU' AND THAT WAS IT. I GUESS MY FEEDBACK AND PROBLEMS CAUSED BY VOLVO DO NOT REALLY INTEREST VOLVO? SO BY VOLVO 'PARAMETERS,' A CAR BREAKING 5 TIMES IS NORMAL, THERE IS NO QUALITY CONTROL OF THEIR CARS, AND CUSTOMER SERVICE IS INEXISTENT (3 OR 4 'PROFESSIONALS' IN HEADQUARTERS SERVING NORTH AMERICA IS INEXISTENT).

NHTSA ID

11394308

Incident

Feb 1, 2021

Mileage

7,500 mi

2020 VOLVO S60. CONSUMER WRITES IN REGARDS TO DISSATISFACTION WITH TIRE PRESSURE MONITORING SYSTEM. *LD *JS

NHTSA ID

11388041

Incident

Jan 12, 2021

'THE BRAKE FLUID IS LOW STOP SAFELY' MESSAGE CAME ON AT LESS THAN 87 MILES ON THE ODOMETER WHILE THE ENGINE WAS RUNNING ON MY DRIVEWAY. A VOLVO DEALER STATED THE FOLLOWING: FLUID WAS LOW NO EXTERNAL LEAK FOUND TOPPED OFF BRAKE FLUID TO FULL MARK 'THE BRAKE FLUID IS LOW STOP SAFELY' MESSAGE CAME ON AGAIN AT LESS THAN 191 MILES ON THE ODOMETER WHILE I WAS DRIVING ON A LOCAL ROAD AT ABOUT 35 MILES AN HOUR SPEED.

NHTSA ID

11297043

Incident

Jan 3, 2020

Mileage

190 mi