1999 Volvo S70 Engine Problems

TL* THE CONTACT OWNS A 1999 VOLVO S70. WHILE APPROACHING A STOP AT A LOW SPEED, THE VEHICLE STALLED. THE CONTACT WAS ABLE TO RESTART THE VEHICLE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC. THE MECHANIC WAS UNABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VEHICLE WAS PREVIOUSLY REPAIRED UNDER NHTSA CAMPAIGN NUMBER: 06V441000 (VEHICLE SPEED CONTROL). THE FAILURE MILEAGE WAS UNKNOWN.

NHTSA ID

10704156

Incident

May 1, 2003

TWICE, WITHIN 50 METRES OF THE SAME SPOT EACH TIME, MY CAR HAS SUFFERED EXTREME ACCELERATION WHILST I WAS BRAKING AS HARD AS I COULD. FIRST TIME, MY MECHANIC CHECKED ALL COMPUTER DIAGNOSTICS USING TWO DIFFERENT COMPUTER TESTING DEVICES BUT THERE WERE NO FAULT CODES. NOW, AS WELL AS HAPPENING TWICE WITHIN 50 METRES OF THE SAME SPOT, I WAS AT THE SAME SET OF TRAFFIC LIGHTS, WHICH I DO NOT SUSPECT AS BEING THE PROBLEM, BUT ALSO NEXT TO A MAJOR HOSPITAL WITH AN ADJACENT HELIPAD. MY BEST GUESS AFTER 57 YEARS IN ELECTRONICS AND 40+ IN COMPUTERS IS THAT SOME SORT OF RF INTERFERENCE IS UPSETTING MY VEHICLE. I KNOW VOLVO CHECK ALL ACCIDENTS INVOLVING THEIR CARS IN SWEDEN AND WONDER WHETHER THEY HAVE EVER COME ACROSS MY PROBLEM. BOTH TIMES THE ENGINE SCREAMED ITS HEAD OFF ALTHOUGH I HAD NO TIME TO WORRY ABOUT THE TACHOMETER READING. THE NOISE ITSELF WAS ADEQUATE WARNING AND THE LACK OF BRAKING MEANT THAT I HAD TO KILL THE IGNITION TO RECOVER MINE AND THE VEHICLES COMPOSURE. SWITCHING ON THE IGNITION AGAIN BOTH TIMES, THE VEHICLE ONCE AGAIN IDLED NORMALLY AND OPERATED AS IT SHOULD. *TR

NHTSA ID

10471485

Incident

Mar 15, 2012

Mileage

78,000 mi

BOUGHT THE CAR ABOUT ONE WEEK PRIOR TO THE FIRST STALLING EPISODE AND ETS LIGHT ON. CALLED VOLVO DUE TO A REPLACEMENT/EXTENDED WARRANTY ON AFFECTED PART. WAS TOLD THAT THE PART WAS NOT REPLACED AND THE WARRANTY WAS NO LONGER COVERING CAR (10 YEARS/200000 MILES). AS A RECENT PURCHASER OF THIS CAR I HAD NO CLUE OF THE REPLACEMENT NOT PREVIOUSLY DONE OR EVEN NEEDED. ALL WAS NEW TO ME AND THEY REFUSED. MOVING FORWARD ONE YEAR AND CAR STALLED IN TRAFFIC, ALMOST HIT FROM BEHIND, NO DASH LIGHTS AND COMPLETE FAILURE OF ETM. CAR WON'T STAY RUNNING AT ALL, TERRIFIED TO DRIVE THE CAR HOME AFTER THIS INCIDENT. NO WARRANTY ON PART, NO REPLACEMENT AND NOW I HAVE $ 4000 BOAT ANCHOR THAT WILL COST A FORTUNE TO FIX DUE TO NO WARRANTY ON THE PART THAT SHOULD HAVE BEEN REPLACED YEARS AGO BY VOLVO. *JB

NHTSA ID

10463108

Incident

Jul 11, 2011

Mileage

115,000 mi

TL* THE CONTACT OWNS A 1999 VOLVO S70. WHILE TRAVELING 45 MPH, THE CONTACT NOTICED THAT THE ETS WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC WHERE THE CONTACT WAS INFORMED THAT THE COMPUTER SOFTWARE NEEDED TO BE UPGRADED. THE VEHICLE WAS NEITHER DIAGNOSED NOR REPAIRED. THE CURRENT AND THE FAILURE MILEAGES WERE 133,000. UPDATED 04/11/12 *BF THE CONSUMER STATED THE CAMSHAFT SEAL, IDLER PULLEY, TENSIONER AND WATER PUMP NEEDED TO BE REPLACED.

NHTSA ID

10450293

Incident

Feb 17, 2012

Mileage

133,000 mi

TL* THE CONTACT OWNS A 1999 VOLVO S70. THE CONTACT STATED THAT HE HEARD A LOUD KNOCKING COMING FROM THE ENGINE UPON STARTING THE VEHICLE. THE CONTACT BEGAN TO DRIVE, BUT THE VEHICLE WOULD NOT ACCELERATE BEYOND 25 MPH. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 101,000. THE VIN WAS UNAVAILABLE.

NHTSA ID

10443493

Incident

Dec 19, 2011

Mileage

101,000 mi

TL*THE CONTACT OWNS A 1999 VOLVO S70. THE CONTACT STATED THE VEHICLE WOULD INTERMITTENTLY STALL WHILE DRIVING AT VARIOUS SPEEDS. UPON RESTART THE VEHICLE WOULD OPERATE AS NORMAL. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER ON NUMEROUS OCCASIONS; HOWEVER, THEY WERE UNABLE TO DIAGNOSE THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE CONTACT STATED THE VEHICLE WAS TAKEN TO VARIOUS AUTHORIZED DEALERS APPROXIMATELY SIXTEEN TIMES FOR THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 65,000 AND THE CURRENT MILEAGE WAS 90,263.

NHTSA ID

10404016

Incident

Jan 1, 2005

Mileage

65,000 mi

VEHICLE SURGES AFTER I HAD THE SOFTWARE DOWNLOAD RECALL. THEY KEEP TELLING ME IT IS A DIRTY THROTTLE BODY, BUT IT HAS BEEN CLEANED A THOUSAND TIMES. THEY NEVER REPLACED MY TCM. JUST THE SOFTWARE. THIS NEEDS TO STOP. I FEEL UNSAFE IN THIS CAR. NEED A RECALL. *TR

NHTSA ID

10390184

Incident

Mar 14, 2011

Mileage

70,000 mi

1999 VOLVO S70. CONSUMER STATES MECHANICAL PROBLEMS *TGW THE CONSUMER STATED THE VEHICLE WOULD SUDDENLY STALL WITH NO WARNING, USUALLY IN RUSH HOUR TRAFFIC. THE CONSUMER WAS ABLE TO RESTART THE VEHICLE, BUT OFTEN IT WOULD GO NO MORE THAN 20-30 MPH. ALSO, SOME OF THE LIGHTS ON THE DASH WOULD COME ON AND GO OFF. THE CONSUMER HAS TAKEN THE VEHICLE TO THE DEALER AT LEAST SIXTEEN TIMES. *JB UPDATED 10/28/10. *JB THE VEHICLE WOULD HESITATE UPON ACCELERATION. UPDATED 11/12/10*JB

NHTSA ID

10342233

Incident

Feb 23, 2005

Mileage

45,669 mi

1999 VOLVO S70 ETS LIGHT CAME ON AND CAR STALLS . CAR IS BUCKING AND SPEEDING UP CAR SHUTS DOWN ALL OVER THE ROAD AND HIGHWAYS AND WILL NOT START. *TR

NHTSA ID

10325555

Incident

Mar 10, 2010

Mileage

120 mi

ONGOING PROBLEMS SINCE AUGUST 2008: ENGINE STALLS, DECELERATES, WON'T START, SOMETIMES ENGINE SURGES BADLY, ENGINE LIGHTS GO ON, THROTTLE GETS DIRTY EVEN WITH NEW PART ETM PROBLEMS ARE OCCURRING AND NOW VEHICLE WILL NOT START OR DRIVE AT ALL. *TR

NHTSA ID

10314854

Incident

Aug 26, 2008

Mileage

106,472 mi

IN MID-DECEMBER THE CAR STARTED BUT RAN ROUGH AND LACKED POWER. PREVIOUS TO THAT IT RAN FINE; SINCE THEN IT HAS HAD VARIOUS INTERMITTENT PROBLEMS RELATED TO ACCELERATION. SOMETIMES THE ENGINE RUNS ROUGH AND LACKS POWER. OTHER TIMES THE ENGINE RUNS FINE BUT THE CAR DOES NOT RESPOND TO ACCELERATOR INPUT TO INCREASE SPEED. SOMETIMES THE CAR STUMBLES BUT ACCELERATES ADEQUATELY. MORE OFTEN THE CAR WILL ACCELERATE TO ABOUT 20 MPH AND NOT INCREASE SPEED BEYOND THAT IRRESPECTIVE OF ACCELERATOR PEDAL PRESSURE. AFTER A FEW SECONDS THE CAR WILL SUDDENLY ACCELERATE NORMALLY. REPLACING THE THROTTLE BODY MODULE CORRECTED THE PROBLEM. THIS PART IS SUBJECT TO A NHTSA AGREEMENT WITH VOLVO THAT REQUIRES VOLVO TO REPLACE THE UNIT FREE BUT THE DEALER REFUSED TO DO THAT AND CHARGED ME FOR THE REPAIR. *TR

NHTSA ID

10306423

Incident

Dec 20, 2009

Mileage

109,000 mi

TL*THE CONTACT OWNS A 1999 VOLVO S70. THE CONTACT STATED THAT INTERMITTENTLY THE ENGINE AND THE CSR WARNING LIGHT ILLUMINATED ON THE INSTRUMENT CONTROL PANEL; THEN THE VEHICLE STALLED. THE VEHICLE WAS TOWED TO A LOCAL REPAIR FACILITY AND A MECHANIC REPLACED THE AIR MASS METER. AFTER THE REPAIR, THE FAILURE RESURFACED. THE VEHICLE WAS TOWED TO A DEALER, IN WHICH THE TECHNICIAN CHARGED $1065.00 FOR DIAGNOSTIC TESTING; HOWEVER, THE TECHNICIAN WAS NOT ABLE TO IDENTIFY THE CAUSE OF THE FAILURE. THE FAILURE HAS NOT BEEN REMEDIED. THE FAILURE MILEAGE WAS 157000 AND THE CURRENT MILEAGE WAS 158000.

NHTSA ID

10284152

Incident

Jul 7, 2009

Mileage

157,000 mi

MY 1999 VOLVO S-70 RECEIVED SOFTWARE UPGRADE CODE #155 IN 2006 SUBJECT TO RECALL AND IN AUGUST 2009 STARTED TO EXPERIENCE RANDOM THROTTLE SURGING AND LOSS OF POWER ,ESPECIALLY ON HIGHWAY DRIVING CONDITIONS(I-95), MAKING VEHICLE UNSAFE TO OPERATE,ALONG WITH INTERMITTENT ETS LIGHT COMING ON. I AM NOW TOLD BY DEALER THAT CAUSE IS DUE TO FAILURE OF ELECTRONIC THROTTLE MODULE & NOT COVERED BY 10 YEAR OR 200,000 MILE WARRANTY AS "IN-SERVICE" DATE ON MY VEHICLE WAS FEB. 2009 AND THEREFORE PAST 10 YEAR WARRANTY PERIOD. HAVING RESEARCHED YOUR DATA BASE INVOLVING SAFETY ISSUES & ACCIDENTS CAUSED DIRECTLY FROM THIS TYPE OF PART FAILURE, I AM AT A LOSS AS TO WHY A FULL RECALL HAS NOT BEEN ISSUED BY VOLVO TO REPLACE ALL ETM'S ON THESE MODEL VEHICLES. I AM NOW OUT-OF-POCKET $1200.00 FOR SOMETHING THAT VOLVO HAS NEGLECTED TO FIX. STATISTICALLY, IT APPEARS THAT MORE OF THESE ETM'S WILL FAIL OUTSIDE OF THE VOLVO WARRANTY PERIOD.

NHTSA ID

10282388

Incident

Aug 10, 2009

Mileage

113,000 mi

TL*THE CONTACT OWNS A 1999 VOLVO S70. IN 2001, THE SPEEDOMETER FAILED AND DISPLAYED ZERO WHEN THE VEHICLE WAS TRAVELING 10 MPH. EVENTUALLY, THE VEHICLE BEGAN TO SHUT OFF IN TRAFFIC AND WHILE DRIVING BETWEEN 60-65 MPH. THE DEALER REPLACED THE SENSORS SEVERAL TIMES. THE CONTACT TOOK THE VEHICLE TO A REPAIR SHOP AND THE SENSORS WERE REPLACED AGAIN. SHE WAS UNSURE ABOUT THE NAME OF THE SENSOR; HOWEVER, THE FAILURES CONTINUED AND THE VEHICLE WAS UNABLE TO BE RESTARTED. RECENTLY, IN JUNE OF 2009, THE VEHICLE SHUT OFF AND WAS TOWED TO THE DEALER. THEY STATED THAT THE ELECTRONIC THROTTLE MODULE FAILED AND THE BATTERY CABLE WAS CORRODED. THE REPAIR COST WAS ESTIMATED AT $1,021. THE FAILURE MILEAGE WAS 79,842 AND CURRENT MILEAGE WAS 189,000.

NHTSA ID

10274313

Incident

Nov 1, 2001

Mileage

79,842 mi

AT APPROXIMATELY 206,000 MILES MY CAR WOULDN'T DRIVE OVER 40 MPH, THE ENGINE WOULD REV UP ON ITS OWN AND SPUTTERED THROUGHOUT THE REDUCED RPM RANGE. RPMS WOULD NOT GO OVER ABOUT 3500. CHECK ENGINE LIGHT CAME ON. DROVE IT TO VOLVO DEALER AND THEY REPLACED THE THROTTLE BODY AT AN OUT OF POCKET COST TO ME OF APPROXIMATELY $1,000. THEY STATED THAT IT WOULD HAVE BEEN COVERED UP TO 200,000 MILES AS THIS PART HAD A RECALL. I DO NOT FEEL THAT I WAS ADEQUATELY NOTIFIED OF THE RECALL. I RECEIVED A LETTER ABOUT A RECALL LAST YEAR AND CALLED THE DEALER TO ASK WHAT IT ALL MEANT SINCE I DID NOT UNDERSTAND IT. THE DEALER SAID IT WAS JUST A SOFTWARE UPGRADE AND WOULD ONLY TAKE ABOUT FIVE MINUTES. I TOOK THE VEHICLE IN FOR THAT SOFTWARE UPGRADE IN MARCH OF 2007 WITH LESS THAN 200,000 MILES ON THE VEHICLE AND THEY DID NOT SAY ANYTHING ABOUT THE ETM / THROTTLE BODY ISSUE. IT SHOULD HAVE BEEN REPLACED AT THAT TIME. *TR

NHTSA ID

10231286

Incident

Jun 9, 2008

Mileage

206,000 mi

TL*THE CONTACT OWNS A 1999 VOLVO S70. WHILE DRIVING 55 MPH, THE VEHICLE LOST POWER AND STALLED, BUT NEVER COMPLETELY SHUT OFF. THE FAILURE OCCURS DURING ACCELERATION AND WHEN STARTING THE VEHICLE. NO OTHER SYSTEMS OF THE VEHICLE WERE AFFECTED AND NO WARNING LIGHTS ILLUMINATED. THE DEALER WAS UNABLE TO DETERMINE THE CAUSE OF FAILURE. THE VIN AND DEALER INFORMATION WERE UNAVAILABLE. THE CURRENT MILEAGE WAS 104,736 AND FAILURE MILEAGE WAS 104,000.

NHTSA ID

10197832

Incident

Jul 18, 2007

Mileage

104,000 mi

MY 1999 VOLVO S70 HAS BEEN STALLING ON A DAILY BASIS FOR SOME TIME NOW. I STALL ON MY WAY TO WORK; A SEVEN MILE DRIVE. I HAVE TRIED TO GET IT IN FOR SERVICE AT A LOCAL VOLVO DEALERSHIP, BUT THEY ARE "BOOKED UP". I HAVE NO OTHER MEANS OF TRANSPORTATION BESIDE THIS DEATH TRAP. I PRAY ALL THE WAY TO WORK. TODAY IT REFUSED TO IDLE UP TO A NORMAL SPEED (35) AND STUCK SOMEWHERE AT 15, SO I COASTED IN UNTIL IT FINALLY STALLED IN THE PARKING LOT. THIS IS A DAILY OCCURRENCE. *JB

NHTSA ID

10147988

Incident

Jan 18, 2006

Mileage

120,000 mi

1999 VOLVO S70'S ETM (THROTTLE) HAD ACTED UP IN JUNE/JULY 2004, PAID AROUND $900 IN JULY 2004 TO HAVE IT FIXED. THE THROTTLE CAUSED THE CAR TO GO DEAD MULTIPLE TIMES & STRONGLY REV ITSELF OCCASIONALLY. THIS WOULD OCCUR WHEN SLOWING DOWN OR WHEN STOPPED. I WOULD OCCASIONALLY HAVE TO KEEP FOOT ON THE GAS TO KEEP THE CAR FROM GOING DEAD. ***NOW LESS THAN A YEAR AND A HALF AFTER HAVING THE PROBLEM "FIXED" (REPLACED UNIT) - THE PROBLEM IS BACK. THE CAR HAS GONE BACK TO SAME ISSUES. THIS PROBLEM DOES NOT OCCUR SLOWLY, FROM GOOD PERFORMANCE TO BAD, IT TOOK ONLY ONE WEEK FOR IT TO RECCUR. *JB

NHTSA ID

10144887

Incident

Jun 1, 2004

Mileage

109,141 mi

SINCE OWNING THIS VEHICLE THE CHECK ENGINE LIGHT HAS ILLUMINATED ON NUMEROUS OCCASIONS AND FAULT CODES FOR THE ENGINE HAVE BEEN ENTERED. I EVEN HAD THE MASS AIR FLOW SENSOR REPLACED DURING ONE OF THESE EPISODES. BUT DURING THE PAST 7 MONTHS I'VE HAD ENGINE PROBLEMS THAT HAVE AFFECTED THE DRIVEABILITY OF THE VEHICLE. PERIODICALLY, AFTER THE ENGINE HAS BEEN RUNNING FOR 30+ MINUTES, THE VEHICLE WILL HAVE PROBLEMS IDLING (FEELS LIKE IT WILL STALL) AND THEN BLACK SMOKE WILL START EMITTING FROM THE EXHAUST. THE CHECK ENGINE LIGHT DOES NOT COME ON DURING THIS PROCESS BUT ONLY WHEN THE CAR IS ONCE AGAIN RUNNING NORMAL. THIS PROBLEM IS AN INTERMITTENT ONE. THE VEHICLE WILL RUN FINE FOR 2 WEEKS AND THEN SUDDENLY THE PROBLEM WILL REAPPEAR. SINCE THIS PROBLEM BEGAN, I'VE HAD THE MASS AIR FLOW SENSOR REPLACED (TWICE--THREE TIMES IN TOTAL SINCE OWING THIS CAR), O2 SENSOR REPLACED (TWICE), CLEANING OF INTAKE AND THROTTLE PLATE, THROTTLE BODY REPLACED, UPGRADED SOFTWARE FOR THE ELECTRONIC THROTTLE CONTROL (ETC) AND SPARK PLUG REPLACEMENT. NONE OF THESE HAVE FIXED THE PROBLEM. THE DEALERSHIP HAS HAD MY CAR FOR DAYS AT A TIME. THEY HAVE RECENTLY BEEN ABLE TO RECREATE THE PROBLEM BUT THE COMPUTER READINGS ARE NOT SHOWING ANY PROBLEMS WITH THE ENGINE COMPONENTS. MY CAR IS STILL AT THE DEALERSHIP AND THE PROBLEM STILL HAS NOT BEEN SOLVED. *JB

NHTSA ID

10141212

Incident

Apr 14, 2005

DT: THE CONTACT STATED THAT 1999 VOLVO S70 EXPERIENCED THE SAME PROBLEM WITH STALLING WHILE DRIVING UNDER 40 MPH. THE ENGINE LIGHT WAS COMING ON AND THE CAR WAS UNCONTROLLABLE. THE CAR WOULD SHAKE AND JERK, SPEED AHEAD AND SLOW DOWN. T THE CONTACT TOOK VEHICLE TO THE DEALERSHIP AND THEY REPLACED THE FUEL THROTTLE BODY, PUT IN NEW SPARK PLUGS, AND REPROGRAMMED THE COMPUTER. THE CAR HAS SINCE THEN RAN WELL. THE CONTACT STATED THAT THIS HAPPENED A YEAR AGO. THE REPAIR COST FOR THE CONTACT WAS ALMOST $1,000.00. THE CONTACT HAS BEEN IN TOUCH WITH VOLVO DEALERSHIP, AND THEY TOLD HIM THAT THEY HAVE NOT HEARD ANYTHING ABOUT RECALL. THE VOLVO MANUFACTURER SAID THAT THERE WAS AN INVESTIGATION ON THE CAR, AND TO CALL THE NHTSA. THE CONTACT HAS ALSO FILED A COMPLAINT WITH VOLVO.*AK

NHTSA ID

10139848

Incident

Oct 26, 2004

Mileage

105,442 mi

I HAVE HAD MULTIPLE PROBLEMS WITH THIS CAR: 1) ENGINE/THROTTLE SYSTEM: A) INTERMITTENTLY, THE CAR WILL NOT START WHEN THE ENGINE IS WARM, WHETHER FROM DRIVING OR IT IS A HOT DAY. I HAD IT TOWED TO THE VOLVO DEALER FROM MY GARAGE WHEN IT HAD <20K MILES AND WAS TOLD THAT I WAS NOT DRIVING IT HARD ENOUGH. THEY ADVISED THAT THE ENGINE HAD TO BE BLOWN OUT AND SUGGESTED THAT I REV-UP THE ENGINE WHILE THE CAR WAS IN PARK TO CLEAN IT OUT. THAT DID NOT HELP. I HAVE HAD THE CAR SERVICED MULTIPLE TIMES. THE PROBLEM HAD GOTTEN SO BAD, THAT THE CAR BEGAN STALLING WHILE I WAS DRIVING IT, PARTICULARLY, IF I STOPPED FOR A TRAFFIC LIGHT OR TURNED A CORNER. I PAID $1,500 IN JANUARY 2005 TO HAVE IT REPAIRED AGAIN, AND NOW THE PROBLEM IS BACK. THE VOLVO DEALER IS USELESS. B) THE ENGINE EITHER LEAKS OR BURNS OIL. I WILL INTERMITTENTLY HEAR A CLICKING NOISE TO FIND OUT THAT ALL OF THE OIL IS GONE. THE OIL LIGHT DOES NOT COME ON. I ROUTINELY HAVE TO ADD 3-4 QUARTS OF OIL. 2) SAFETY FEATURES: THE REARVIEW MIRROR BROKE OFF IN MY HAND AND I WAS TOLD BY THE DEALER THAT IT WAS A SAFETY FEATURE. WHEN IT BROKE OFF, IT LEFT A METAL SPIKE STICKING OUT THAT WOULD HAVE DONE FAR MORE DAMAGE IN AN ACCIDENT THAN THE MIRROR. THE CHILD LOCK ON THE REAR CENTER SEAT BELT FAILED. I TOOK IT TO THE DEALER AND WAS TOLD THAT I WAS PULLING THE BELT TOO TIGHT AND IT WAS SUPPOSED TO HAVE SOME "GIVE". OF COURSE, I KNOW THAT THE CHILD SEAT IS NOT SUPPOSED TO WIGGLE AROUND IN THE BACK SEAT, SO I INSISTED THAT IT BE REPLACED. BODY: THE MECHANISMS TO HOLD UP THE TRUNK LID NO LONGER FUNCTION. THE LATCH TO RELEASE THE HOOD HAS HAD TO BE REPLACED. *NM

NHTSA ID

10136772

Incident

Sep 16, 2005

Mileage

15,000 mi

MY S70 VOLVO, STALLED ON FREEWAY A NUMBER OF TIMES WITHIN A ONE DAY PERIOD, WOULD RESTART AND GOT IT TO VOLVO OF ESCONDIDO CA, HAD MY CAR FOR 3 DAYS AND I RENTED ( I AM A SINGLE MOM AND CANNOT AFFORD THIS OR TO BE WITHOUT A CAR) RECEIVED MY CAR& BILL $457.69 TO CLEAN THE THROTTLE BODY. ON 7/ 18 I RETURNED IT TO VOLVO BECAUSE IT BEGAN DOING IT AGAIN ON SEVERAL OCCASIONS. THAT TIME VOLVO HAD IT FOR 1 DAY AND SAID THERE WAS NOTHING WRONG WITH MY CAR AND TO COME GET IT. ON JULY 19TH IT HAPPENED AGAIN AND THEY HAD MY CAR FROM 7/ 19TH - 27TH BECAUSE THEY COULD NOT FIND A PROBLEM. ON THE 27TH, $160 FOR LABOR AND PARTS.(SPARK PLUGS) I REFUSED TO PAY FOR LABOR. MY CAR NEVER RAN THE SAME AND IT SEEMED TO BE SLUGGISH. I THEN RETURNED TO WORKING STRICTLY WITH MY OWN CERTIFIED VOLVO MECHANIC. HE HAS DONE ALL OF MY TUNE UPS, OIL CHANGES AND MINOR MAINTENANCE. (PRIOR TO THIS STALLING PROBLEM) LAST WEEK I HEARD A HORRIBLE AND SUDDEN NOISE AND ALTHOUGH NO LIGHTS OR WARNING INDICATORS APPEARED I TOOK IT TO HIM IMMEDIATELY. HE HAS FOUND THAT IT HAS A CRACK IN THE LOWER BLOCK WHICH HAS NOW LEFT ME WITH A SHELL OF A CAR AND NO ENGINE. MY REGULAR MECHANIC SAID THAT HE HAS NEVER SEEN THIS ON A CAR AS WELL KEPT AND MAINTAINED AS MINE. HE BELIEVES IT IS POSSIBLE THAT THE FAULTY STALLING PROBLEM THAT IS STILL A MYSTERY TO VOLVO COULD BE THE REASONING. I PUT A LOT OF TIME, MONEY AND ENERGY OUT AS A RESULT OF THIS CAR AND MOST IMPORTANTLY RISKED THE LIVES OF MY CHILDREN AND MYSELF WITH THIS PROBLEM. I NEED TO KNOW WHAT THE NHTSA IS DOING TO RESOLVE THIS AND HAS ANYONE ELSE HAD A CRACK LOWER BLOCK AS AN END RESULT?. I FEEL VOLVO SHOULD HAVE TO REPLACE MY ENGINE. TIME, LOSS OF WORK AND COSTS HAVE RESULTED IN A MAJOR HARDSHIP FOR ME. I CRINGE AT THE FACT THAT IT COULD HAVE BEEN SUCH A TRAGIC ENDING AS AN ACCIDENT OR DEATH. PLEASE LET ME KNOW WHAT THE NEXT STEP IS OR HOW I PURSUE VOLVO. THANK YOU, [XXX]. *NM INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10136504

Incident

Jun 21, 2005

Mileage

12,000 mi

THE ENGINE THROTTLE CONTROL LIGHT ACTIVATED SPORADICALLY BEGINNING IN JULY, 2005. I NOTICED THAT THE CAR WAS NOT PERFORMING ADEQUATELY WHEN GOING UPHILL OR IN SEVERE HEAT. MY HUSBAND CONTACTED THE VOLVO DEALERSHIP IN ALLENTOWN, PA WHERE WE PURCHASED THE VEHICLE. HE WAS TOLD THAT THE COST TO REPAIR SAME WOULD BE OVER $800. WE DECIDED TO PASS ON THIS REPAIR DUE TO THE COST AND THOUGHT THAT ANOTHER AUTO SERVICE MECHANIC COULD PERFORM THE REPAIRS AT A LESSER PRICE. APPROXIMATELY 3 WEEKS LATER, THE ETS LIGHT WAS ACTIVATED ON EVERY OCCASION THAT THE VEHICLE WAS USED. SINCE A SECOND MECHANIC (NOT AFFILIATED WITH VOLVO) STATED THAT HE WAS UNABLE TO DO THE REPAIRS, WE DECIDED TO CONTACT ANOTHER VOVLO DEALERSHIP. THE REPAIR OF THE THROTTLE BODY AND ETM "RELOAD" WAS PERFORMED BY A VOLVO OF FORT WASHTINGTON, PA AT A COST OF OVER $800 ON AUGUST 17, 2005. AFTER READING THE NUMBER OF COMPLAINTS THAT NHTSA RECEIVED ON THIS VERY SAME PROBLEM AND THE POTENTIAL FOR INJURY, WE DECIDED TO HAVE THE REPAIR PERFORMED. WE DID CONTACT VOLVO IN ROCKLEIGH, NJ VIA EMAIL AND RECEIVED AN INITIAL RESPONSE FROM A MR. JOHN WILLETS REQUESTING INFORMATION ON OUR VIN NUMBER AND MILEAGE. WE SUPPLIED SAID INFORMATION ON THE SAME DATE (AUGUST 10, 2005). WE DID NOT HEAR BACK FROM HIM DESPITE REPEATED REQUESTS VIA EMAIL. WE HAD TO PAY THIS EXPENSIVE REPAIR BILL TO ENSURE THE SAFETY OF OUR FAMILY.

NHTSA ID

10133751

Incident

Jul 5, 2005

Mileage

87,000 mi

CAR HESITATES AND/OR STALLS ON ACCELERATION FOR PAST 20,000 MILES. INITIAL DIAGNOSIS FROM VOLVO DEALER SHOWED "NO FAULT CODES STORED, UNABLE TO DIAGNOSE." FINALLY, TODAY I STALLED WHILE MAKING A TURN AND ALMOST GOT BROADSIDED. JUST AFTER THAT AN ETS LIGHT CAME ON. I CALLED THE DEALER AND WAS TOLD "IT WILL COST UP TO $1000 TO REPLACE THE PART." THIS IS A MAJOR SAFETY HAZARD AND TO THINK THAT VOLVO KNOWS ABOUT THIS PROBLEM (I SURFED THE INTERNET AND FOUND RIGHT AWAY THAT THIS IS A COMMON PROBLEM) AND LET ME TAKE THE CAR OUT WITH THIS ISSUE KNOWN. (REGARDLESS OF A FAULT CODE STORED)*JB

NHTSA ID

10133090

Incident

Aug 16, 2005

Mileage

94,000 mi

CAR STARTED MISSING, LOSING POWER, ETS LIGHT CAME ON, TOOK TO DEALER REPLACED EGR MODULE ?, COST ABOUT $1000 ALTOGETHER. *JB

NHTSA ID

10131963

Incident

Apr 1, 2005

Mileage

100,000 mi