2000 Volvo V40 Problems

BRAKES FAILED COMING INTO MY DRIVEWAY. ABLE TO STOP CAR BY USING EMERGENCY BRAKE. COULD HAVE CAUSED A CRASH. BROUGHT TO BE SERVICED. MECHANIC REPORTED THAT IT WAS FAILED LEFT FRONT BRAKE HOSE DUE TO SPRING SUPPORT RUBBING THROUGH. THIS HOSE HAS BEEN REPLACED AND THE OLD PART IS AVAILABLE. MECHANIC ALSO REPORTED THAT RIGHT FRONT BRAKE HOSE NEEDS TO BE REPLACED BECAUSE OF SAME REASON. AN APPOINTMENT FOR THIS HAS BEEN SCHEDULED AND PART WILL BE AVAILABLE. HE FEELS THIS WILL BE A DESIGN ISSUE. *TR

DT*: THE CONTACT STATED WHILE DRIVING AT 55 MPH THE BRAKES FAILED RESULTING IN A CRASH. A POLICE REPORT WAS FILED AT THE SCENE AND THE DRIVER AND PASSENGER SUSTAINED MINOR INJURIES. THE DEALERSHIP DETERMINED ON CERTAIN VEHICLES WATER CAN ENTER THE ELECTRICAL BRAKE VACUUM PUMP, CAUSING THE PUMP TO FAIL. THERE IS A NHTSA RECALL, # 03V474000, REGARDING THE SERVICE BRAKES HYDRAULIC POWER ASSIST VACUUM. THE VIN WAS NOT INCLUDED IN THE RECALL.

2000 VOLVO V40 - VERY WELL MAINTAINED, 2ND OWNER, APPROXIMATELY 83,000 MILES. I STARTED NOTICING THAT THE CAR WOULD SURGE ON THE HIGHWAY WITH THE A/C ON AND WHEN I HAD STEADY PRESSURE ON THE ACCELERATOR (I.E. ICRUISING AT A STEADY SPEED). THE SURGE IN RPM'S WOULD BE RHYTHMIC, VERY SUBTLE (100-200 RPMS) AND CONTINUE INDEFINITELY UNTIL I TURN THE A/C OFF - AT WHICH TIME THEY WOULD CEASE. THEY WOULD SOMETIMES RESUME WHEN I TURNED THE A/C COMPRESSOR BACK ON. THIS HAPPENED INFREQUENTLY OVER THE PAST MONTH (IT'S JUNE IN CT, MY STATE OF RESIDENCE) AND WOULD NOT HAPPEN EVERY TIME I RAN THE A/C - BUT ONLY OCCURRED WHEN THE A/C COMPRESSOR WAS RUNNING. THEN A REMARKABLE THING HAPPENED TODAY - WHILE CRUISING ON THE HIGHWAY AND WITH THE A/C COMPRESSOR ON - THE CARE SUDDENLY AND VIOLENTLY SURGED IN A WAY THAT IT HAD NEVER DONE PREVIOUSLY. THE INCREASE IN RPM'S WAS SIGNIFICANT ENOUGH TO CAUSE THE AUTOMATIC TRANSMISSION TO DOWNSHIFT INTO THE NEXT LOWEST GEAR. FORTUNATELY, I HAD ENOUGH SPACE BETWEEN MY CAR AND THE CAR IN FRONT OF ME TO ALLOW ME TIME TO RESPOND WITHOUT HAVING AND ACCIDENT. I IMMEDIATELY PUT THE CAR IN NEUTRAL AND THE RPM'S STARTED SPIKING TO ALMOST 4,000 THEN QUICKLY BACK DOWN TO 1,000. THE RPM'S CONTINUED TO THIS RAPID BACK AND FORTH SPIKING AND DIPPING FOR ALMOST 30 SECONDS. I TURNED OFF THE A/C/ BUT THAT DIDN'T HAVE AN IMMEDIATE AFFECT (AS WAS THE CASE IN THE PREVIOUSLY MENTIONED EPISODES WHEN THE SPIKES AND DIPS WERE MUCH MORE SUBTLE). WHEN TURNING OFF THE A/C DIDN'T DO THE TRICK ((AS IT HAD IN THE PAST) I THEN IMMEDIATELY CHECKED THE CRUISE CONTROL - IT WAS OFF. I THEN STABBED AT THE ACCELERATOR WITH MY FOOT SEVERAL TIMES BEFORE IT FINALLY SETTLED DOWN. AND I HAVE THE FACTORY VOLVO RUBBER MATS THAT ARE SECURED TO THE FLOOR BY A POSITIONING PIN (I'M METICULOUS ABOUT MY CAR THE MAT WAS NO WHERE NEAR THE ACCELERATOR). I AM NATURALLY VERY WARY OF THIS CAR NOW, ESPECIALLY AFTER READING THE MANY COMPLAINTS ABOUT UNINTENDED ACCELERATION FOR THIS MODEL. WHY NO RECALL? *TR

EVER SINCE I BOUGHT THE 2000 VOLVO V40 STATIONWAGON FROM A PRIVATE DEALERSHIP I'VE HAD NOTHING BUT PROBLEMS TRYING TO START THE CAR. WHEN TRYING TO CRANK UP VEHICLE IT TAKES A COUPLE OF SECONDS BEFORE THE CAR ACTUALLY STARTS AND IT SMELLS LIKE GAS AFTERWARDS. I'VE TAKEN IT TO THE MECHANICS AND THEY HAVE GIVEN IT A FULL TUNE UP AND REPLACED THE INJECTORS BUT STILL I HAVE THE SAME PROBLEM. *TR

FAILURE OF UPPER STRUT MOUNT BUSHINGS CAUSING LOSS OF SUSPENSION / STEERING. REPLACED FOR THE THIRD TIME ON 2000 V-40 VOLVO. RECENTLY VOLVO OFFERED A NEWLY DESIGNED HEAVY DUTY MOUNT AT THREE TIME THE REPLACEMENT COST DEMONSTRATING THAT ORIGINAL EQUIPMENT MOUNT WAS SEVERELY UNDER DESIGNED. *TR

WE PURCHASED OUR 2000 V40 FROM THE ORIGINAL OWNER AT 81K. WE NEEDED BOTH REAR SPRINGS REPLACED RIGHT AWAY. THIS WAS THE SECOND TIME THEY WERE REPLACED. DEALER SAID A COMMON FLAW WITH THE V40. WE ARE ALSO NOTICING A SHAKING IN THE FRONT END WHEN ACCELERATING BETWEEN 50-60MPH. NOT SURE WHAT THIS IS. ALSO NOTICING THAT THERE IS A SHAKE IN THE BRAKE PEDAL AND TOLD NEED NEW BRAKE PADS AND ROTORS. THEY WERE JUST REPLACED BEFORE WE GOT THE CAR AT 75K AND NOW CAR HAS 100K WHICH IS A ALL HIGHWAY MILES. WE HAVE ALSO NOTICED DIFFICULTY WITH THE BRAKING SYSTEM, SOMETIMES TROUBLE STOPPING AND BRAKES SQUEAL AFTER SITTING FOR A COUPLE OF DAYS. HEAD LIGHTS AND TAIL LIGHTS ALSO HAVE BURNT OUT QUITE FREQUENTLY. THERE ALSO SEEMS TO BE SOME MAJOR DEFECT WITH THE EXTERIOR PAINT. RUSTING IN MANY PLACES AND PAINT SEEMS TO BE RUBBING OFF AT THE TOUCH. LUCKILY NONE OF THESE HAVE CAUSED ANY ACCIDENTS OR CLOSE CALLS, HOWEVER NOT VERY SATISFIED WITH THIS VOLVO. *TR

2000 VOLVO V40 - VERY WELL MAINTAINED, 2ND OWNER, APPROXIMATELY 83,000 MILES. I STARTED NOTICING THAT THE CAR WOULD SURGE ON THE HIGHWAY WITH THE A/C ON AND WHEN I HAD STEADY PRESSURE ON THE ACCELERATOR (I.E. ICRUISING AT A STEADY SPEED). THE SURGE IN RPM'S WOULD BE RHYTHMIC, VERY SUBTLE (100-200 RPMS) AND CONTINUE INDEFINITELY UNTIL I TURN THE A/C OFF - AT WHICH TIME THEY WOULD CEASE. THEY WOULD SOMETIMES RESUME WHEN I TURNED THE A/C COMPRESSOR BACK ON. THIS HAPPENED INFREQUENTLY OVER THE PAST MONTH (IT'S JUNE IN CT, MY STATE OF RESIDENCE) AND WOULD NOT HAPPEN EVERY TIME I RAN THE A/C - BUT ONLY OCCURRED WHEN THE A/C COMPRESSOR WAS RUNNING. THEN A REMARKABLE THING HAPPENED TODAY - WHILE CRUISING ON THE HIGHWAY AND WITH THE A/C COMPRESSOR ON - THE CARE SUDDENLY AND VIOLENTLY SURGED IN A WAY THAT IT HAD NEVER DONE PREVIOUSLY. THE INCREASE IN RPM'S WAS SIGNIFICANT ENOUGH TO CAUSE THE AUTOMATIC TRANSMISSION TO DOWNSHIFT INTO THE NEXT LOWEST GEAR. FORTUNATELY, I HAD ENOUGH SPACE BETWEEN MY CAR AND THE CAR IN FRONT OF ME TO ALLOW ME TIME TO RESPOND WITHOUT HAVING AND ACCIDENT. I IMMEDIATELY PUT THE CAR IN NEUTRAL AND THE RPM'S STARTED SPIKING TO ALMOST 4,000 THEN QUICKLY BACK DOWN TO 1,000. THE RPM'S CONTINUED TO THIS RAPID BACK AND FORTH SPIKING AND DIPPING FOR ALMOST 30 SECONDS. I TURNED OFF THE A/C/ BUT THAT DIDN'T HAVE AN IMMEDIATE AFFECT (AS WAS THE CASE IN THE PREVIOUSLY MENTIONED EPISODES WHEN THE SPIKES AND DIPS WERE MUCH MORE SUBTLE). WHEN TURNING OFF THE A/C DIDN'T DO THE TRICK ((AS IT HAD IN THE PAST) I THEN IMMEDIATELY CHECKED THE CRUISE CONTROL - IT WAS OFF. I THEN STABBED AT THE ACCELERATOR WITH MY FOOT SEVERAL TIMES BEFORE IT FINALLY SETTLED DOWN. AND I HAVE THE FACTORY VOLVO RUBBER MATS THAT ARE SECURED TO THE FLOOR BY A POSITIONING PIN (I'M METICULOUS ABOUT MY CAR THE MAT WAS NO WHERE NEAR THE ACCELERATOR). I AM NATURALLY VERY WARY OF THIS CAR NOW, ESPECIALLY AFTER READING THE MANY COMPLAINTS ABOUT UNINTENDED ACCELERATION FOR THIS MODEL. WHY NO RECALL? *TR

WHEN THE VEHICLE WAS TURNED OFF THE KEY BECAME STUCK IN THE IGNITION . *NLM

TL* THE CONTACT OWNS A 2000 VOLVO V40. THE CONTACT SHIFTED INTO REVERSE WITH THE BRAKE PEDAL ENGAGED WHEN THE VEHICLE UNINTENTIONALLY ACCELERATED AND DROVE OVER A PLASTIC TRASH RECEPTACLE, CERAMIC POT AND THEN CRASHED INTO THE SIDE OF A NEARBY HOUSE. THERE WAS NO PERSONAL INJURY AND THE EXTERIOR SIDE OF THE HOUSE SUSTAINED MINOR DAMAGE. A POLICE REPORT WAS NOT FILED. THE REAR BUMPER COMPLETELY DETACHED AND THE VEHICLE WAS IN THE PROCESS OF BEING TOWED TO A COLLISION CENTER. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNAVAILABLE. UPDATED 10/04/11*LJ UPDATED 3/22/12 *CN

2000 VOLVO V40 - VERY WELL MAINTAINED, 2ND OWNER, APPROXIMATELY 83,000 MILES. I STARTED NOTICING THAT THE CAR WOULD SURGE ON THE HIGHWAY WITH THE A/C ON AND WHEN I HAD STEADY PRESSURE ON THE ACCELERATOR (I.E. ICRUISING AT A STEADY SPEED). THE SURGE IN RPM'S WOULD BE RHYTHMIC, VERY SUBTLE (100-200 RPMS) AND CONTINUE INDEFINITELY UNTIL I TURN THE A/C OFF - AT WHICH TIME THEY WOULD CEASE. THEY WOULD SOMETIMES RESUME WHEN I TURNED THE A/C COMPRESSOR BACK ON. THIS HAPPENED INFREQUENTLY OVER THE PAST MONTH (IT'S JUNE IN CT, MY STATE OF RESIDENCE) AND WOULD NOT HAPPEN EVERY TIME I RAN THE A/C - BUT ONLY OCCURRED WHEN THE A/C COMPRESSOR WAS RUNNING. THEN A REMARKABLE THING HAPPENED TODAY - WHILE CRUISING ON THE HIGHWAY AND WITH THE A/C COMPRESSOR ON - THE CARE SUDDENLY AND VIOLENTLY SURGED IN A WAY THAT IT HAD NEVER DONE PREVIOUSLY. THE INCREASE IN RPM'S WAS SIGNIFICANT ENOUGH TO CAUSE THE AUTOMATIC TRANSMISSION TO DOWNSHIFT INTO THE NEXT LOWEST GEAR. FORTUNATELY, I HAD ENOUGH SPACE BETWEEN MY CAR AND THE CAR IN FRONT OF ME TO ALLOW ME TIME TO RESPOND WITHOUT HAVING AND ACCIDENT. I IMMEDIATELY PUT THE CAR IN NEUTRAL AND THE RPM'S STARTED SPIKING TO ALMOST 4,000 THEN QUICKLY BACK DOWN TO 1,000. THE RPM'S CONTINUED TO THIS RAPID BACK AND FORTH SPIKING AND DIPPING FOR ALMOST 30 SECONDS. I TURNED OFF THE A/C/ BUT THAT DIDN'T HAVE AN IMMEDIATE AFFECT (AS WAS THE CASE IN THE PREVIOUSLY MENTIONED EPISODES WHEN THE SPIKES AND DIPS WERE MUCH MORE SUBTLE). WHEN TURNING OFF THE A/C DIDN'T DO THE TRICK ((AS IT HAD IN THE PAST) I THEN IMMEDIATELY CHECKED THE CRUISE CONTROL - IT WAS OFF. I THEN STABBED AT THE ACCELERATOR WITH MY FOOT SEVERAL TIMES BEFORE IT FINALLY SETTLED DOWN. AND I HAVE THE FACTORY VOLVO RUBBER MATS THAT ARE SECURED TO THE FLOOR BY A POSITIONING PIN (I'M METICULOUS ABOUT MY CAR THE MAT WAS NO WHERE NEAR THE ACCELERATOR). I AM NATURALLY VERY WARY OF THIS CAR NOW, ESPECIALLY AFTER READING THE MANY COMPLAINTS ABOUT UNINTENDED ACCELERATION FOR THIS MODEL. WHY NO RECALL? *TR

WHILE DRIVING THE VEHICLE AT NIGHT THE HEADLIGHTS WOULD SHUT OFF WITH NO WARNING. DEALER NOTIFIED. *NLM

WHILE DRIVING THE DRIVER'S SEAT BACK MOVES BACKWARD, SOMETIMES CAUSING THE DRIVER TO LOSE CONTROL OF THE VEHICLE. THE CONSOLE CONTROLS FOR THE WINDOW WERE POSITIONED AT THE CENTER INSTEAD OF AT THE DASHBOARD AND WERE INCONVENIENT BOTH FOR THE DRIVER AND PASSENGER. PLACING AN OBJECT ON THE CENTER CONSOLE ALSO CHANGES THE CONTROL OF THE SIDE VIEW MIRRORS. *YH

THE REAR HATCH DID NOT CLOSE. *NLM

WHILE DRIVING THE DRIVER'S SEAT BACK MOVES BACKWARD, SOMETIMES CAUSING THE DRIVER TO LOSE CONTROL OF THE VEHICLE. THE CONSOLE CONTROLS FOR THE WINDOW WERE POSITIONED AT THE CENTER INSTEAD OF AT THE DASHBOARD AND WERE INCONVENIENT BOTH FOR THE DRIVER AND PASSENGER. PLACING AN OBJECT ON THE CENTER CONSOLE ALSO CHANGES THE CONTROL OF THE SIDE VIEW MIRRORS. *YH

2000 VOLVO V40 FRONT WHEELS BECOME LOOSE. (1) CAR WAS TAKEN TO DEALERSHIP FOR RECALL ON BRAKING SYSTEM. (2) DEPARTING DEALERSHIP, RUMBLE FROM FRONT WAS NOTED. TWO MILES FROM DEALERSHIP, EXTREME VIBRATION CAUSED ME TO STOP. THE PASSENGER FRONT WHEEL HAD NEARLY COME OFF. (3) CAR WAS RETURNED TO DEALERSHIP. I WAS INFORMED THE LUGS: NUTS MUST HAVE BECOME LOOSE. I POINTED OUT THAT TECHNICIAN HAD TAKEN THE WHEEL OFF AND MUST HAVE FORGOTTEN TO TIGHTEN IT. SERVICE MANAGER SAID THIS WAS NOT POSSIBLE. A WEEK AFTER MY COMPLAINT THE DEALER AGREE TO INSPECT THE CAR FOR PROBLEMS. SERVICE MANAGER SAID NO PROBLEMS WERE FOUND. AFTER LEAVING THE DEALERSHIP THE WHEEL BECAME LOOSE AGAIN AFTER 75 MILES OF TRAVEL. I RETIGHENED THE FRONT PASSENGER WHEEL. ALSO, LOOSE WERE THE FRONT DRIVER WHEEL AND THE REAR PASSENGER WHEEL. IS THERE A PROBLEM WITH THE LUGS: NUTS ON THE V40 SERIES? THERE ARE ONLY 4 PER WHEEL. I REGULARLY MUST CHECK ALL LUGS: NUTS. IS THE DEALERSHIP USING INCORRECT METHODS/TOOLS TO ENSURE PROPER TORQUE ON WHEELS? THEY DENY ANY WRONG DOING. *AK

THE DRIVER SIDE WHEEL WAS LOOSE, WHICH CAUSED A NOISE.*JB

FAILURE OF UPPER STRUT MOUNT BUSHINGS CAUSING LOSS OF SUSPENSION / STEERING. REPLACED FOR THE THIRD TIME ON 2000 V-40 VOLVO. RECENTLY VOLVO OFFERED A NEWLY DESIGNED HEAVY DUTY MOUNT AT THREE TIME THE REPLACEMENT COST DEMONSTRATING THAT ORIGINAL EQUIPMENT MOUNT WAS SEVERELY UNDER DESIGNED. *TR

WHILE DRIVING HOME FROM WORK AND TRYING TO PULL INTO THE COMMUNITY DEVELOPMENT, WENT TO APPLY BRAKES, AND THEY DEPRESSED ABOUT 1 INCH. WAS NOT ABLE TO STOP. HAD TO TAKE FOOT OFF BRAKES, THEN SLAMMED ON THEM, AND VEHICLE STOPPED. ALSO, STEERING WHEEL BECAME VERY STIFF, AND ENGINE DIED FOR A BRIEF MOMENT, AND THEN FUNCTIONED NORMALLY. *AK

ELECTRICAL SYSTEM HAS TOTAL FAILURE AND SHORTED WITHIN ONE WEEK OF PURCHASE, UNRESOLVED PROBLEMS WITH BRAKE AND DSM WARNING LIGHTS ON DASHBOARD FLASHING ON AND OFF

WHILE DRIVING THE DRIVER'S SEAT BACK MOVES BACKWARD, SOMETIMES CAUSING THE DRIVER TO LOSE CONTROL OF THE VEHICLE. THE CONSOLE CONTROLS FOR THE WINDOW WERE POSITIONED AT THE CENTER INSTEAD OF AT THE DASHBOARD AND WERE INCONVENIENT BOTH FOR THE DRIVER AND PASSENGER. PLACING AN OBJECT ON THE CENTER CONSOLE ALSO CHANGES THE CONTROL OF THE SIDE VIEW MIRRORS. *YH

WHILE DRIVING THE DRIVER'S SEAT BACK MOVES BACKWARD, SOMETIMES CAUSING THE DRIVER TO LOSE CONTROL OF THE VEHICLE. THE CONSOLE CONTROLS FOR THE WINDOW WERE POSITIONED AT THE CENTER INSTEAD OF AT THE DASHBOARD AND WERE INCONVENIENT BOTH FOR THE DRIVER AND PASSENGER. PLACING AN OBJECT ON THE CENTER CONSOLE ALSO CHANGES THE CONTROL OF THE SIDE VIEW MIRRORS. *YH

WHILE DRIVING THE TRANSMISSION LOCKED UP LOCKING THE REAR TIRES WHICH MADE IT DIFFICULT TO CONTROL THE VEHICLE. *NLM

2000 VOLVO V40 - VERY WELL MAINTAINED, 2ND OWNER, APPROXIMATELY 83,000 MILES. I STARTED NOTICING THAT THE CAR WOULD SURGE ON THE HIGHWAY WITH THE A/C ON AND WHEN I HAD STEADY PRESSURE ON THE ACCELERATOR (I.E. ICRUISING AT A STEADY SPEED). THE SURGE IN RPM'S WOULD BE RHYTHMIC, VERY SUBTLE (100-200 RPMS) AND CONTINUE INDEFINITELY UNTIL I TURN THE A/C OFF - AT WHICH TIME THEY WOULD CEASE. THEY WOULD SOMETIMES RESUME WHEN I TURNED THE A/C COMPRESSOR BACK ON. THIS HAPPENED INFREQUENTLY OVER THE PAST MONTH (IT'S JUNE IN CT, MY STATE OF RESIDENCE) AND WOULD NOT HAPPEN EVERY TIME I RAN THE A/C - BUT ONLY OCCURRED WHEN THE A/C COMPRESSOR WAS RUNNING. THEN A REMARKABLE THING HAPPENED TODAY - WHILE CRUISING ON THE HIGHWAY AND WITH THE A/C COMPRESSOR ON - THE CARE SUDDENLY AND VIOLENTLY SURGED IN A WAY THAT IT HAD NEVER DONE PREVIOUSLY. THE INCREASE IN RPM'S WAS SIGNIFICANT ENOUGH TO CAUSE THE AUTOMATIC TRANSMISSION TO DOWNSHIFT INTO THE NEXT LOWEST GEAR. FORTUNATELY, I HAD ENOUGH SPACE BETWEEN MY CAR AND THE CAR IN FRONT OF ME TO ALLOW ME TIME TO RESPOND WITHOUT HAVING AND ACCIDENT. I IMMEDIATELY PUT THE CAR IN NEUTRAL AND THE RPM'S STARTED SPIKING TO ALMOST 4,000 THEN QUICKLY BACK DOWN TO 1,000. THE RPM'S CONTINUED TO THIS RAPID BACK AND FORTH SPIKING AND DIPPING FOR ALMOST 30 SECONDS. I TURNED OFF THE A/C/ BUT THAT DIDN'T HAVE AN IMMEDIATE AFFECT (AS WAS THE CASE IN THE PREVIOUSLY MENTIONED EPISODES WHEN THE SPIKES AND DIPS WERE MUCH MORE SUBTLE). WHEN TURNING OFF THE A/C DIDN'T DO THE TRICK ((AS IT HAD IN THE PAST) I THEN IMMEDIATELY CHECKED THE CRUISE CONTROL - IT WAS OFF. I THEN STABBED AT THE ACCELERATOR WITH MY FOOT SEVERAL TIMES BEFORE IT FINALLY SETTLED DOWN. AND I HAVE THE FACTORY VOLVO RUBBER MATS THAT ARE SECURED TO THE FLOOR BY A POSITIONING PIN (I'M METICULOUS ABOUT MY CAR THE MAT WAS NO WHERE NEAR THE ACCELERATOR). I AM NATURALLY VERY WARY OF THIS CAR NOW, ESPECIALLY AFTER READING THE MANY COMPLAINTS ABOUT UNINTENDED ACCELERATION FOR THIS MODEL. WHY NO RECALL? *TR