RoadVitals

2003 Volvo V40 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest May 18, 2010
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2003 Volvo V40, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes150.0%
  • Seat belts150.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

1
report

From owner reports, verbatim

"2003 VOLVO V40 COLD START BRAKE FAILURE" ON COLD WINTER MORNINGS, WHEN TEMPERATURE IS BELOW FREEZING, AFTER THE ENGINE IS STARTED AND AS I BACK OUT OF MY GARAGE, THE BRAKE IS SO WEAK THAT I CANNOT EFFECTIVELY STOP THE VEHICLE. I WOULD NEED TO PRESS THE BRAKE PEDAL AS HARD AS I CAN AND THE CAR WOULD STOP IN ABOUT A FULL CAR'S LENGTH. IT'S QUITE SCARY. THE PROBLEM ALWAYS GOES AWAY IN ABOUT 1 TO 2 MINUTES. THIS ONLY HAPPENS OCCASIONALLY, ABOUT 2 TO 3 TIMES A MONTH IN THE WINTER, BUT I AM NOT ABLE TO PREDICT WHEN IT HAPPENS. I HAVE COMPLAINED TO MY VOLVO DEALERSHIP AND LEFT MY CAR THERE OVERNIGHT. BUT THEY WERE NOT ABLE TO REPRODUCED THE FAILURE. THEY SUGGESTED ME TO REPLACE THE BRAKE VACUUM BOOSTER PUMP. SO I DID AND PAID FOR A NEW BRAKE VACUUM BOOSTER PUMP. HOWEVER THE PROBLEM WAS NOT SOLVED OR ALLEVIATED. KNOWING THIS COULD HAPPEN ANY TIME, I AVOID USING MY VOLVO IN THE WINTER AND USE EXTRA CAUTION DURING OTHER TIMES. *TR

NHTSA ID 10331101 · filed May 18, 2010

Too few reports in this category for a page of its own — they appear in the full complaint list.

Seat belts

Reports naming seat belts, buckles, retractors and pretensioners.

1
report

From owner reports, verbatim

SEAT BELTS ARE DEFECTIVE. WHEN PULLING ON THE SEAT BELTS THEY WILL NOT REACH THE BUCKLE. THUS, MAKING IT IMPOSSIBLE TO ATTACH AND RIDE. CONSUMER INDICATES THAT THIS DEFECT WAS REPAIRED BY THE DEALERSHIP IN MAY 2004. CURRENTLY, THEY LOCKED UP AGAIN. *AK

NHTSA ID 10075770 · filed Jun 7, 2004

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .