RoadVitals

2001 Volvo Vn Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest Sep 17, 2004
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
1 investigation on file

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

04V457000

VISIBILITY:WINDSHIELD WIPER/WASHER:MOTOR

Sep 17, 2004
56,154 units potentially affected
The defect: ON CERTAIN TRUCKS EQUIPPED WITH VALEO WIPER SYSTEMS, THE WIPER MOTOR MAY BE SUSCEPTIVE TO SALT INTRUSION THAT COULD POSSIBLY LEAD TO A CONDITION WHERE THE CONNECTOR OVERHEATS TO A POINT WHERE THE CONNECTOR COULD IGNITE.
The risk: IF THIS OCCURS, EXCESSIVE HEAT AND SMOKE COULD RESULT IN AN UNDER HOOD FIRE.
The remedy: DEALERS WILL INSPECT AND REPLACE THE CONNECTOR PLATE ON THE WINDSHIELD WIPER MOTOR. PHASE 2 OF THE RECALL BEGAN ON NOVEMBER 1, 2004. OWNERS SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
VOLVO TRUCKS NORTH AMERICA, INC.Manufacturer number RVXX0406View on NHTSA.gov
02V036000

POWER TRAIN:AXLE ASSEMBLY

Feb 5, 2002
215 units potentially affected
The defect: ON CERTAIN HEAVY DUTY CLASS 8 TRUCKS, THE FORWARD AND/OR REAR DRIVE AXLE UPPER AXLE SEAT CAN BREAK ALLOWING THE AXLE TO SHIFT OUT OF ALIGNMENT.
The risk: THIS COULD RESULT IN A LOSS OF AXLE STABILITY INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL INSPECT THE UPPER AXLE SEAT FOR A CERTAIN DATE CODE THAT IS STAMPED ON THE PART, AND THOSE AXLES WILL BE REPLACED. OWNER NOTIFICATION BEGAN MARCH 15, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
VOLVO TRUCKS NORTH AMERICA INCView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

PE05058ClosedPreliminary Evaluation

HOOD STRUT FAILURE

Opened Nov 3, 2005
Closed Feb 24, 2006

VOLVO REPORTED FOUR FIELD REPORTS AND 62 WARRANTY CLAIMS RELATED TO HOOD STRUT FAILURE ON THE SUBJECT TRUCK/TRACTORS. THE HOOD STRUTS ARE A SINGLE ACTING OIL SHOCK THAT CONTROLS THE RATE OF THE OPENING OF THE HOOD. THERE ARE TWO STRUTS ATTACHED TO THE HOOD ASSEMBLY, ONE ON EACH SIDE. ODI'S CONCERN WAS THAT A FAILED HOOD STRUT WOULD ALLOW THE HOOD TO DROP ON ONE SIDE, POSSIBLY INJURING SOMEONE WORKING ON THE ENGINE. IN EXAMINING THE LIFE CYCLE OF HOOD STRUTS IN BOTH TRUCK AND PASSENGER CAR APPLICATIONS, ODI FOUND THATALL HOOD STRUTS REQUIRE PERIODIC REPLACEMENT DUE TO NORMAL ?WEAR-OUT.?DURING THE INVESTIGATION, ODI DISCOVERED THAT WHEN THE STRUTS WERE REPLACED, THE PROBLEM STARTED TO OCCUR ON THE SUBJECT TRUCKS.THE FAILURES RESULTED FROM THE IMPROPER INSTALLATION OF THE HOOD STRUT.THIS FINDING WAS SUBSTANTIATED BY FLEETS CONTACTED FROM INFORMATION SUPPLIED BY VOLVO, AS WELL AS VISITS TO LOCAL DEALERS. DURING THISINVESTIGATION, ODI PERFORMED THE FOLLOWING ACTIONS:A.REVIEWED WARRANTY/ENGINEERING DATA PROVIDED BY VOLVO;B.CONTACTED THE TWO INITIAL COMPLAINANTS TO GATHER MOREINFORMATION;C.CONDUCTED FIELD TRIPS TO AREA DEALERS TO INSPECT SUBJECTVEHICLES;D.CONTACTED TWO FLEETS FROM OUTSIDE THE WASHINGTON D.C. AREA TO DISCUSS THEIR EXPERIENCE WITH THESE HOOD STRUTS;ANDE.REVIEWED THE APPROPRIATE SERVICE MANUALS.BASED ON THE DATA PROVIDED BY VOLVO AND THE INFORMATION GATHERED BY ODI, IT IS APPARENT THAT SOME DEALERS AND OWNERS MAY HAVE BEENINSTALLINGREPLACEMENT STRUTS INCORRECTLY.DEPENDING ON WHICH MODEL TRUCK IS BEING WORKED ON, THERE ARE TWO DISTINCT WAYS TO MOUNT THE REPLACEMENT STRUT TO THE FRAME RAILS.FLEETS CONTACTED DURING THIS INVESTIGATION REPORTED NO FURTHER ISSUES WITH THE STRUTS ONCE PROPER INSTALLATION INSTRUCTIONS WERE PROVIDED TO THEM FROM VOLVO. ODI HAS DISCUSSED THE MATTER WITH VOLVO AND THEY HAVE DECIDED TO REVISE THE SERVICE MANUALS FOR THESE TRUCKS TO INCLUDE PICTURES OF BOTH HOOD STRUT MOUNTING ARRANGEMENTS IN EVERY SERVICE MANUAL, REGARDLESS OF TRUCK MODEL.THEREFORE,IF SOMEONE WAS USING THE INCORRECT MANUAL, THEY WOULD STILL BE ABLE TO VIEWALL THE POSSIBLE STRUT MOUNTINGARRANGEMENTS, REGARDLESS OF MODEL.THIS INVESTIGATION IS CLOSED, AS A SAFETY RELATED DEFECT WITH THE HOOD STRUTS HAS NOT BEEN IDENTIFIED AT THIS TIME. FURTHER USE OF THE AGENCY?S RESOURCES ARE NOT CURRENTLY WARRANTED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION ON THE VEHICLES IF WARRANTED BY NEW CIRCUMSTANCES.ODI WILL CONTINUE TO MONITOR FIELD REPORTS AND TAKE APPROPRIATE ACTION IF INDICATED.

STRUCTURE:BODY:HOOD:HINGE AND ATTACHMENTS

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .