RoadVitals

1998 Volvo Vnl Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
5
Newest May 28, 2003
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
3 investigations on file

Recall campaigns

5 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

03V199000

SUSPENSION:FRONT

May 28, 2003
433 units potentially affected
The defect: ON CERTAIN TRUCKS EQUIPPED WITH TRUCK HUB UNITS MANUFACTURED BY SKF EXCLUSIVELY FOR USE ON ARVINMERITOR'S FF98X SERIES NON-DRIVE STEER AXLES, THE HUB UNIT BEARINGS CAN WEAR PREMATURELY.
The risk: SEIZURE OF THE BEARINGS CAN CAUSE WHEEL SEPARATION OR WHEEL END FIRE.
The remedy: DEALERS WILL REPLACE ALL FRONT AXLE HUBS. AN INTERIM NOTICE TO OWNERS WAS MAILED ON JUNE 25, 2003. FINAL OWNER NOTIFICATION BEGAN ON OCTOBER 6, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO AT 1-800-528-6586.
VOLVO TRUCKS NORTH AMERICA INCManufacturer number RVXX0304View on NHTSA.gov
02V238000

EXTERIOR LIGHTING:TAIL LIGHTS:SWITCH

Sep 9, 2002
5,532 units potentially affected
The defect: CERTAIN HEAVY DUTY CLASS 8 TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THE TWO TAIL LAMPS, BACK-UP LAMP,AND LICENSE TAG LAMP WERE MOUNTED ON INSUFFICIENTLY RIGID MOUNTS.
The risk: IT MAY NOT ALLOW THE DRIVER OF A REARWARD APPROACHING VEHICLE TO HAVE FULL VIEW OF THE LAMPS.
The remedy: DEALERS WILL ATTACH THE TWO TAIL LAMPS, BACK-UP LAMP, AND THE LICENSE TAP LAMP ON STIFFER BRACKETS. OWNER NOTIFICATION BEGAN OCTOBER 31, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
VOLVO TRUCKS NORTH AMERICA INCView on NHTSA.gov
02V110000

SERVICE BRAKES, AIR:ANTILOCK

Apr 11, 2002
208 units potentially affected
The defect: CERTAIN HEAVY DUTY CLASS 8 VEHICLES FAIL TO COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS", S5.1.6.3, "ANTILOCK POWER FOR TOWED VEHICLES." ELECTRICAL POWER FOR THE TRAILER ANTI-LOCK BRAKING SYSTEM (ABS) CAN BE DISRUPTED WHEN A SWITCH LOCATED ON THE VEHICLE INSTRUMENT PANEL IS ACTIVATED TO CONTROL LIGHTING WITHIN THE TRAILER.
The risk: IF THIS CONDITION OCCURS, THE DRIVER CAN LOSE OF THE TOWED VEHICLE, POSSIBLY RESULTING IN A VEHICLE CRASH.
The remedy: DEALERS WILL INSTALL A WIRING HARNESS WHICH WILL PROVIDE CONTINUOUS ELECTRICAL POWER TO THE TRAILER ABS WHENEVER THE IGNITION SWITCH IS IN THE ON OR RUN POSITION. OWNER NOTIFICATION BEGAN APRIL 29, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT VOLVO TRUCKS AT 1-800-528-6586.
VOLVO TRUCKS NORTH AMERICA INCView on NHTSA.gov
00V232003

SERVICE BRAKES, AIR:ANTILOCK

Aug 22, 2000
18,362 units potentially affected
The defect: VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS BUILT WITH BENDIX AIR ABS WITH AN EC-17 1030R ELECTRONIC CONTROL UNIT (ECU), THERE HAVE BEEN REPORTS OF UNWANTED ABS ACTIVATION AT LOW SPEEDS CAUSED BY 1) CHAFED ABS WHEEL SPEED SENSOR WIRES ON ROTATING PARTS OR 2) A DAMAGED COMPONENT AT THE WHEEL END THAT GENERATES A CERTAIN TYPE OF ERRATIC SENSOR SIGNAL.
The risk: THIS CONDITION COULD CAUSE THE ABS ECU TO EXHAUST THE AIR AT THE AIR BRAKE MODULATORS FOR ONE OR MORE OF THE WHEELS. THIS COULD RESULT IN EXTENDED BRAKING DISTANCES AND A POSSIBLE CRASH.
The remedy: DEALERS WILL REPLACE THE ABS ECU.
VOLVO TRUCKS NORTH AMERICA INCView on NHTSA.gov
99V296001

TIRES:BEAD

Oct 26, 1999
20 units potentially affected
The defect: VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS EQUIPPED WITH CONTINENTAL GENERAL S380A 295/75R22.5 LR G TIRES, SERIAL NOS. A3371E5488 THROUGH A3371E5089. THESE TIRES HAVE BEEN OVERCURED.
The risk: THIS CONDITION CAN CAUSE TIRE FAILURE.
The remedy: CONTINENTAL GENERAL IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. DEALERS WILL EXCHANGE THE TIRE FOR AN IDENTICAL OR REASONABLY EQUIVALENT TIRE.
VOLVO TRUCKS NORTH AMERICA INCView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

EA09003ClosedEngineering Analysis

Drag Link Failure

Opened Jan 15, 2009
Closed Jul 6, 2010

EA09-003 is closed with the submission of Volvo's recall 10V-282 recalling approximately 111,034 Model Year (MY) 1998 through 2005 VN and VNL class 8 trucks.Volvo announced recall 10V-282 in response to NHTSA's recall request letter dated June 3, 2010 (available at NHTSA's web site www.safercar.gov). NHTSA found that these vehicles were designed and manufactured with a TRW ball joint that does not meet the combined performance requirements and foreseeable inspection practices of the U.S. market.The ball joint in the steering system that connects the driver's side steering arm/knuckle to the drag link can fail resulting in a total loss of steering on the vehicle.Volvo changed the size and supplier of the ball joint used on these vehicles starting with the 2006 MY vehicles.The failure rates on the vehicles manufactured with the larger ball joint are significantly less than the subject vehicles.The closing of this investigation does not constitute a finding by ODI that no safety defect exists in the vehicles that are not included in Volvo's recall.ODI will continue to monitor the incidence of drag link failures in other MY Volvo trucks.Note:The recall request letter dated June 3, 2010 associated with this investigation describes 49 incidents of ball joint separation.After a comprehensive review of the data it was discovered that the number of separations that NHTSA was aware of was 41 with a failure rate of 36.9 R/100K.The 41 separations resulted in 23 crash allegations.

STEERING:GEAR BOX:SHAFT PITMANLed to recall 10V282000
PE04014ClosedPreliminary Evaluation

STEERING BINDING

Opened Feb 5, 2004
Closed Jun 24, 2004

ODI'S PRELIMINARY EVALUATION FOCUSED ON THE POTENTIAL FOR A BROKEN, BENT, DEFORMED, FRAGMENTED OR DISPLACED TURN SIGNAL CANCELING RING (TSCR), VTNA PART NUMBER 1607363, TO RESTRICT THEVEHICLE OPERATOR'S ABILITY TO TURN THE STEERING WHEEL.THE PE IDENTIFIED THIRTEEN VTNA WARRANTY CLAIMS THAT ALLEGE THAT THE TSCR HAD FAILED AND THAT THE VEHICLE STEERING EFFORT HAD BEEN ADVERSELY AFFECTED.TO DATE, ODI HAS NOT FOUND ANY SAMPLES OF A FAILED TSCR AND HAS NOT BEEN ABLE TO DEFINITIVELY ESTABLISH WHETHER A FAILED TSCR CAN OR CANNOT CONTRIBUTE TO INCREASED STEERING EFFORT.ODI BELIEVES THAT IT IS APPROPRIATE TO CONDUCT FURTHER INVESTIGATION(EA LEVEL) TO BETTER UNDERSTAND THE CHARACTERISTICS OF TSCR FAILURES AND TO ASSESS THE EFFECT, IF ANY, THAT THESE TYPES OF FAILURES COULD HAVE ON VEHICLE STEERING EFFORT.

STEERING
PE02095ClosedPreliminary Evaluation

INTEGRAL HUB AND BEARING ASSEMBLY

Opened Dec 11, 2002
Closed May 30, 2003

THE COMPANIES INVOLVED IN THIS MATTER ARE: SKF (HUB MFR), ARVINMERITOR (FRONT AXLE MFR), AND VOLVO (MANUFACTURER OF CLASS VIII TRACTOR/TRUCKS).SKF IDENTIFIED MANUFACTURING DEFECTS FOR SPECIFIC BUILD DATES ON FRONT AXLE HUB AND BEARINGS (WHEEL BEARINGS) SUPPLIED TO ARVINMERITOR.AS A RESULT, ARVINMERITOR NOTIFIED VOLVO OF AXLES SUPPLIED WITH POSSIBLE DEFECTIVE FRONT HUB ASSEMBLIES.AS A RESULT OF THAT NOTIFICATION, 433 TRUCKS ARE BEING RECALLED BY VOLVO FOR DEFECTIVE FRONT AXLE WHEEL BEARINGS WHICH MAY FAIL IN SUCH A WAY THAT A WHEEL SEPARATION OR WHEEL BEARING FIRE OCCURS.SEE ATTACHED SUMMARY REPORT FOR ADDITIONAL DETAILS.

SUSPENSION:FRONT:HUBLed to recall 03V199000

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .