2011 Volvo Vnl Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2011 Volvo Vnl, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical125.0%
- Engine125.0%
- Steering125.0%
- Suspension125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
WHILE DRIVING, VEHICLE ENGINE SUDDENLY STARTED RUNNING INTERMITTENT WHEN HITTING A BUMP OR ACCELLERATING, THEN ABRUPTLY SHUT COMPLETELY DOWN WHILE DRIVING. LUCKELY THE SPEED WAS LOW AND WE WERE ABLE TO STOP, BUT ENDED UP IN THE MIDDLE OF THE ROAD. UPON INSPECTION ON THE ROAD, SPARKS CAME OFF FROM UNDER THE CAB WITH ELECTRICAL BURNING SMELL. SHUT DOWN BATTERY SYSTEM. FOUND POSITIVE BATTERY CABLE BEHIND THE ENGINE RUBBED AGAINST CHASSIS SUPPORT BRACKET AND WELDED ITSELF TO THE BRACKET. 40A FUSE IN ENGINE FUSE COMPARTMENT BURNED THROUGH.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2011 VOLVO VNL. THE CONTACT STATED THAT WHILE DRIVING 40 MPH, THE CHECK ENGINE AND ENGINE FAULT WARNING LAMPS ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER. THE TECHNICIAN DIAGNOSED THAT THE NOX SENSOR WAS DEFECTIVE AND NEEDED TO BE REPLACED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 247,000 AND CURRENT MILEAGE WAS 247,430.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2011 VOLVO VNL TRUCK. THE CONTACT STATED THE STEERING WHEEL LOCKED UP ABNORMALLY WHENEVER THE WHEEL WAS TURNED WHILE THE BRAKES WERE ENGAGED. THE VEHICLE WAS TAKEN TO AN AUTHORIZED DEALER SIX TIMES WHERE THERE WERE VARIOUS REPAIRS PERFORMED. THE REPAIRS DID NOT REMEDY THE FAILURE. THE CONTACT WAS ALSO INFORMED THE FAILURE WAS A COMMON FAILURE. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 45 AND THE CURRENT MILEAGE WAS 98,000. THE CONSUMER STATED THE STEERING PUMP SEEMED TO BE SMALLER THAN WHAT VOLVO USED PREVIOUSLY IN THEIR TRUCKS AND IT WAS LOOSING PRESSURE AND OVERHEATING. UPDATED 08/10/11
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2011 VOLVO VNL. THE CONTACT STATED THAT THE TRUCK CABIN JERKED OUT OF CONTROL WHEN A BUMP WAS HIT OR WHEN DRIVING ON ROUGH TERRAIN. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO REPLACED THE REAR SHOCKS; HOWEVER, THE FAILURE RECURRED. THE MECHANIC REPLACED ALL THE SHOCKS, BUT THE FAILURE WAS STILL NOT REMEDIED. THE MANUFACTURER WAS NOT NOTIFIED. THE FAILURE MILEAGE WAS 621,232.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .