2001 Volvo VNL64T Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2001 Volvo VNL64T, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine233.3%
- Body & structure116.7%
- Fuel system116.7%
- Steering116.7%
- Suspension116.7%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
VEHICLE HAS A PROBLEM WITH OIL LEAKS, EVEN THOUGH VEHICLE IS STILL UNDER WARRANTY THE DEALER WILL NOT TAKE ANY RESPONSIBILITY, NOW THE HEAD IS LEAKING OIL. *SLC
CONSUMER WAS IN HIS HOME WHEN THE SMOKE DECTECTOR WENT OFF, CONSUMER WENT OUTSIDE AND SAW THAT VEHICLE WAS ON FIRE, POSSIBLY ENGINE RELATED, FIRE ORIGINATED FROM VEHICLE AND SPREAD THROUGH CONSUMER'S HOME, BOTH THE VEHICLE AND HOME WERE DESTROYED. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
VEHICLE HAS A PROBLEM WITH OIL LEAKS, EVEN THOUGH VEHICLE IS STILL UNDER WARRANTY THE DEALER WILL NOT TAKE ANY RESPONSIBILITY, NOW THE HEAD IS LEAKING OIL. *SLC
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
VEHICLE HAS A PROBLEM WITH OIL LEAKS, EVEN THOUGH VEHICLE IS STILL UNDER WARRANTY THE DEALER WILL NOT TAKE ANY RESPONSIBILITY, NOW THE HEAD IS LEAKING OIL. *SLC
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
DT*: THE CONTACT STATED WHILE DRIVING 68 MPH ON A DRY 4 LANE HIGHWAY, THE DRIVER ATTEMPTED TO CHANGE LANES TO THE LEFT, AND THERE WAS NO REACTION FROM THE STEERING. THE STEERING WHEEL WAS ABLE TO BE TURNED, BUT THE VEHICLE DID NOT RESPOND AT ALL. THE BRAKES WERE APPLIED, HOWEVER THE VEHICLE COLLIDED WITH ANOTHER TRUCK, AND CROSSED INTO A GRASS MEDIAN WHICH STOPPED THE VEHICLE. A POLICE REPORT WAS TAKEN AT THE SCENE. THE VEHICLE WAS TOWED TO A SERVICE DEALER, WHO DETERMINED THAT THE TIE ROD DRAG LINKS HAD DETACHED FROM THE BALL JOINT. THE BOLT REMAINED INTACT, BUT THE PRESSURE BUSHING SEPARATED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
VEHICLE HAS A PROBLEM WITH OIL LEAKS, EVEN THOUGH VEHICLE IS STILL UNDER WARRANTY THE DEALER WILL NOT TAKE ANY RESPONSIBILITY, NOW THE HEAD IS LEAKING OIL. *SLC
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .