RoadVitals

1997 Volvo Wia Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
8
Latest Feb 11, 2003
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
5
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 1997 Volvo Wia, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Suspension545.5%
  • Body & structure327.3%
  • Interior & seats19.1%
  • Transmission19.1%
  • Visibility19.1%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Suspension

Reports naming suspension components — springs, struts, shocks, control arms and related hardware.

5
reports

From owner reports, verbatim

VEHICLE EXPERIENCED PREMATURE STEER TIRE WEAR.*AK *JB

NHTSA ID 565176 · filed Feb 11, 2003

CONSUMER STATED WHILE DRIVING, THE TRUCK STARTED TO PULL VERY HARD TO THE LEFT AND CONSUMER HAD A VERY DIFFICULT TIME STOPPING THE TRUCK, ONCE THE TRUCK WAS UNDER CONTROL, CONSUMER GOT OUT AND NOTICED THAT THE RIGHT STEER TIRE WAS WORN DOWN TO THE VERY OUTSIDE EDGE TO THE THREAD, ON A SEPARATE OCCASION THE FRONT END OF THE TRUCK WAS VIBRATING SO BAD THAT THE CONSUMER HAD TO PULL OVER, CONSUMER STATED THAT IN FEBUARY 1998 THE REAR SUSPENSION WAS REBUILT.*JB

NHTSA ID 565912 · filed May 30, 2002

Too few reports in this category for a page of its own — they appear in the full complaint list.

Body & structure

Reports naming the vehicle structure, frame, body panels, doors, hood and trim.

3
reports

From owner reports, verbatim

CONSUMER STATES SLEEPER WALL SIDE SEAMS LEAK WATER.(VOLVO TRUCK 64TWIA) *YH

NHTSA ID 565031 · filed Aug 15, 2001

WHEN DRIVING AT ANY SPEED, THERE IS VIBRATION WITHIN THE FRAME, TIRE IS WORN OUT. VECHICLE ISN'T STAYING ON TRACK, IT KEEPS GOING INTO OTHER LANES. ALSO, FRAME IS BENT. *AK THE CONSUMER POINTS OUT THAT THE APPEAL FORUM IS HELPFUL BUT THERE SHOULD BE A METHOD FOR CONSUMERS TO REACH THE MANUFACTURERS EASILY. *YH CONSUMER STATES THE PROBLEM IS PROXIMATE TO THE CROSS MEMBERS WITHIN THE FRAME RAILS, THEY ARE OF INSUFFICIENT STRENGTH TO KEEP THE FRAME RAILS WITHIN ACCEPTABLE FLEXIBILITY PARAMETERS, THIS CAUSES A TEMPORARY BREECH IN THE CONTACT POINTS BETWEEN THE FRAME AND THE FORWARD DRIVE AXLE, THIS RESULTS IN THE FORWARD DRIVE AXLE BECOMING MISALIGNED WHEN CLOSED AND CAUSES A THRUST PROBLEM TO THE STEER AXLE AS THE FORWARD DRIVE IS NOW PUSHING IT AT AN ANGLE TO A FORWARD STRAIGHT LINE, THERE IS STRESS ON REAR SUSPENSION ASSEMBLY, THE NET RESULT IS COMPONENT BREAKAGE, PREMATURE WEAR, AND A TRUCK THAT DRIFTS AND WANDERS, VOLVO REPLACED THE REAR SUSPENSION, FRONT BUSHINGS, STRAIGHTEN FRAME, AND THEY ALSO BENT THE STEER AXLE AND ATTEMPTED TO PUSH IT FURTHER BACK THUS NECESSATING THAT THEY BENT THE STEERING ROD. *SLC

NHTSA ID 845406 · filed Aug 19, 1999

Too few reports in this category for a page of its own — they appear in the full complaint list.

Interior & seats

Reports naming seats, latches, locks, linkages and interior fittings.

1
report

From owner reports, verbatim

CONSUMER STATES SLEEPER WALL SIDE SEAMS LEAK WATER.(VOLVO TRUCK 64TWIA) *YH

NHTSA ID 565031 · filed Aug 15, 2001

Too few reports in this category for a page of its own — they appear in the full complaint list.

Transmission

Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.

1
report

From owner reports, verbatim

TRANSMISSION JUMPS OUT OF GEAR UNDER A LOAD ,THIS TRANSMISSION WAS REBUILT NOV 2000 FOR THIS PROBLUM. IT STARTED AGAIN IN NOV.2001. OTHER OWNERS OF THIS TYPE TRANSMISSION TELL ME THEY HAVE THE SAME PROBLUM. THERE IS NOTHING AS DANGEROUS AS A TRUCK GEARING DOWN ON A HILL , AND HAVING THE TRANSMISSION JUMP OUT OF GEAR. THANK YOU FOR YOUR TIME.*AK

NHTSA ID 759990 · filed Mar 29, 2002

Too few reports in this category for a page of its own — they appear in the full complaint list.

Visibility

Reports naming windshields, glass, wipers, defrosters and mirrors.

1
report

From owner reports, verbatim

CONSUMER STATES SLEEPER WALL SIDE SEAMS LEAK WATER.(VOLVO TRUCK 64TWIA) *YH

NHTSA ID 565031 · filed Aug 15, 2001

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .