RoadVitals

2003 Winnebago Brave Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Data refreshed

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
6
Newest Oct 26, 2010
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

6 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

10V525000

EQUIPMENT

Oct 26, 2010
18,461 units potentially affected
The defect: WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
The risk: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
The remedy: WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.
WINNEBAGO INDUSTRIES, INC.View on NHTSA.gov
09V300000

EQUIPMENT

Jul 29, 2009
1,547 units potentially affected
The defect: WINNEBAGO IS RECALLING 1,547 MODEL YEAR 2001-2003 RECREATIONAL VEHICLES EQUIPPED WITH NORCOLD MODEL 1200LRIM REFRIGERATORS, MANUFACTURED FROM MARCH 1, 2001 TO DECEMBER 31, 2002, WITH SERIAL NUMBERS BETWEEN 1273701 AND 1536607, NON-CONSECUTIVELY. A FATIGUE FAILURE IN THE SECTION OF THE COOLING UNIT WHICH CONTAINS THE REFRIGERANT COULD ALLOW THE LIQUID SOLUTION TO SLOWLY LEAK. IF A LEAK OCCURS AND THE REFRIGERATOR CONTINUES TO BE OPERATED AFTER SOLUTION CIRCULATION HAS CEASED THE HEAT SOURCE COULD GENERATE VERY HIGH TEMPERATURES. AT SUCH HIGH TEMPERATURES, THE COOLING UNIT COULD RUPTURE.
The risk: IF A LEAK OCCURS AND THE UNIT IS CONTINUES TO OPERATE, HYDROGEN GAS MAY BE EXPELLED AND CAN BE IGNITED, RESULTING IN A FIRE, POSSIBLY CAUSING SERIOUS INJURY OR DEATH.
The remedy: WINNEBAGO IS WORKING WITH NORCOLD AND NORCOLD WILL NOTIFY OWNERS AND THE VEHICLE'S REFRIGERATOR WILL BE REPAIRED FREE OF CHARGE (PLEASE SEE 09E-027). OWNERS MAY CONTACT NORCOLD'S RECALL CENTER AT 1-800-767-9101.
WINNEBAGO INDUSTRIES, INC.View on NHTSA.gov
09V113000

FUEL SYSTEM, DIESEL:STORAGE:TANK ASSEMBLY

Apr 8, 2009
2,331 units potentially affected
The defect: WINNEBAGO IS RECALLING 2,331 MY 2002-2004 BRAVE AND ITASCA SUNRISE MY 2005 2006 WINNEBAGO VOYAGE, ADVENTURER, ITASCA SUNRISE AND SUNCRUISER MOTOR HOMES. THE PROPANE TANK MOUNTING BRACKET MAY HAVE AN INCOMPLETE OR IMPROPER WELD.
The risk: SHOULD THE WELD FAIL, THE PROPANE TANK CAN TIP OR FALL, POSSIBLY RELEASING PROPANE WHICH HAS THE POTENTIAL TO IGNITEA FIRE, RESULTING IN PERSONAL INJURY AND/OR VEHICLE AND PROPERTY DAMAGE.
The remedy: DEALERS WILL INSPECT AND PROPERLY WELD THE BRACKET FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT WINNEBAGO AT 800-537-1885.
WINNEBAGO INDUSTRIES, INC.Manufacturer number 112View on NHTSA.gov
04V609000

FUEL SYSTEM, GASOLINE:DELIVERY:HOSES, LINES/PIPING, AND FITTINGS

Dec 22, 2004
3,538 units potentially affected
The defect: ON CERTAIN MOTOR HOMES BUILT ON A 20,700 GVWR OR GREATER WORKHORSE CHASSIS, THERE MAY NOT BE SUFFICIENT CLEARANCE IN THE AREA WHERE THE FUEL LINE CROSSES THE FRAME CROSS MEMBER.
The risk: WITHOUT CLEARANCE, A CONDITION COULD DEVELOP WHERE THE CROSS MEMBER MAY WEAR INTO THE FUEL LINE AND A FUEL LEAK MAY DEVELOP. FUEL LEAKAGE, IN THE PRESENCE OF AN IGNITION SOURCE, COULD RESULT IN A FIRE.
The remedy: DEALERS WILL REPAIR THESE MOTOR HOMES BY PROVIDING CLEARANCE BETWEEN THE FUEL LINE AND FRAME CROSS MEMBER. THE FUEL LINE WILL BE INSPECTED AND, IF NECESSARY, REPLACED. THE RECALL BEGAN JANUARY 7, 2005. OWNERS SHOULD CONTACT WINNEBAGO AT 1-800-537-1885.
WINNEBAGO INDUSTRIES, INC.Manufacturer number 93View on NHTSA.gov
03V405000

EQUIPMENT:RECREATIONAL VEHICLE/TRAILER

Oct 16, 2003
15,337 units potentially affected
The defect: ON CERTAIN MOTOR HOMES EQUIPPED WITH SAMSUNG MICROWAVE OVENS, THESE UNITS WERE PRODUCED WITH A DEFECTIVE PANEL. AN ELECTRICAL SHORT CAN OCCUR BETWEEN CIRCUIT PATTERNS ON THE MEMBRANE PANEL, ESPECIALLY OVERLAPPED BY A "JUMPER" OR JUMP WIRE. THIS MAY CAUSE THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS.
The risk: AN ELECTRICAL SHORT CAN OCCUR CAUSING THE OVEN TO ACTIVATE WITHOUT PRESSING ANY KEY PADS. THIS COULD RESULT IN EXCESSIVE HEAT, SMOKE, OR POSSIBLY A FIRE.
The remedy: SAMSUNG WILL NOTIFY CUSTOMERS AND REPAIR THE PANEL FREE OF CHARGE. IN THE MEANTIME, CONSUMERS SHOULD UNPLUG THEIR MICROWAVE, IF POSSIBLE. IF THE CONSUMER IS UNABLE TO UNPLUG THE MICROWAVE, THEY SHOULD LEAVE THE DOOR AJAR UNTIL THE PANEL IS REPLACED. CONSUMERS SHOULD NEVER USE THE MICROWAVE OVEN FOR STORAGE OR LEAVE ANY TOWELS, PAPER, CLOTH OR OTHER PRODUCTS IN THE MICROWAVE AFTER USE. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT SAMSUNG AT 800-932-3837 OR WINNEBAGO AT 641-585-3535.
WINNEBAGO INDUSTRIES, INC.View on NHTSA.gov
03V060000

SERVICE BRAKES, HYDRAULIC:BRAKE FLUID LOW WARNING: LAMP

Feb 21, 2003
8,532 units potentially affected
The defect: CERTAIN MOTOR HOME CHASSIS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 105,"HYDRAULIC AND ELECTRIC BRAKE SYSTEMS." THE BRAKE SYSTEM WARNING INDICATOR MAY NOT FUNCTION AS REQUIRED BY THE STANDARD.
The risk: IN SOME OF THE AFFECTED VEHICLES, THE BRAKE SYSTEM WARNING INDICATOR WILL NOT ILLUMINATE WHEN THE IGNITION IS IN THE START POSITION OR FOR A LOW BRAKE FLUID CONDITION, IF THE BODY BUILDER RELIED SOLELY UPON FORD'S IVM COMPLIANCE STATEMENT FOR THE SYSTEM WARNING INDICATOR.
The remedy: DEALERS WILL REPAIR THESE VEHICLES. OWNER NOTIFICATION BEGAN APRIL 25, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT WINNEBAGO AT 1-641-585-3535.
WINNEBAGO INDUSTRIES, INC.Manufacturer number 88View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .