RoadVitals

2006 Workhorse W20 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
3
Latest Nov 22, 2010
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
2
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2006 Workhorse W20, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes266.7%
  • Steering133.3%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

2
reports

From owner reports, verbatim

TL*THE CONTACT OWNS A 2006 MONACO COACH MONARCH SE RV EQUIPPED WITH A WORKHORSE W20 CHASSIS. THE CONTACT REFERENCED RECALL 09V110000 (SERVICE BRAKES, HYDRAULIC) AND STATED THAT THE RECALL REPAIR WAS PERFORMED ON OCTOBER 26, 2010. THE DEALER RETURNED THE VEHICLE WITH THE LEFT FRONT ROTOR CRACKED AND THE PAD HAD 30% LEFT. THE CONTACT STATED THAT THE OTHER BRAKES WERE AT 70% WITH NO CRACKS. THE CONTACT CALLED THE MANUFACTURER WHO HAD NOT RESPONDED. THE VIN WAS UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 24,000.

NHTSA ID 10367127 · filed Nov 22, 2010

WHILE DRIVING ON THE DC BELTWAY IN TRAFFIC, THE BRAKE PEDAL WENT TO THE FLOOR WITHOUT STOPPING. PUMPING THE PEDAL GAVE ENOUGH POWER TO STOP VEHICLE. ABS WARNING LIGHT ALSO CAME ON. STOPPED VEHICLE ON SIDE OF ROAD. BRAKES WERE VERY HOT. DISCONNECTED CAR WE WERE TOWING AND ATTEMPTED TO CONTINUE. BRAKES DID COOL OFF AND RETURNED TO NORMAL OPERATION. WE HAD PREVIOUSLY TOWED THE CAR WITHOUT ANY PROBLEMS. RV WAS TAKEN TO AN AUTHORIZED SHOP ABOUT 5 MILES FROM CAMPGROUND. THEY SAID THEY KNEW ABOUT THE PROBLEM AND COULD "PATCH" IT UNTIL WORKHORSE CAME OUT WITH A FIX. *TR

NHTSA ID 10273846 · filed Jun 15, 2009

Too few reports in this category for a page of its own — they appear in the full complaint list.

Steering

Reports naming the steering system — racks, columns, power-steering assist and steering linkage.

1
report

From owner reports, verbatim

THE STEERING ON MY 2007/2006 WORKHORSE W-20 CHASSIS IS EXTREMELY/DANGEROUSLY LOOSE IN THAT IT IS VERY DIFFICULT TO DRIVE SAFELY DURING MINIMAL ENVIRONMENTAL CONDITIONS OF WINDS AND PASSING VEHICLES. I COMPARE THIS VEHICLE TO THREE OTHER MOTORHOMES WITH WORKHORSE CHASSIS AND 110,000 + MILES OF ACCIDENT FREE DRIVING. *NM

NHTSA ID 10172793 · filed Nov 6, 2006

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .