2008 Workhorse W22 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2008 Workhorse W22, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes375.0%
- Fuel system125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
2008 WINNEBAGO ON A 2008 W22 WORKHORSE CHASSIS HAS 26838 MILES, REQUIRED REPLACEMENT OF THE FRONT ROTORS AND ALL OF THE BRAKE PADS. ROTORS WERE ACTUALLY CRACKED BUT NOT BURNED REQUIRING REPLACEMENT *TGW THE CONSUMER STATED THE CALIPERS SEIZED. ALSO, SEVERAL BRAKE REPAIR TECHNICIANS STATED THE PROBLEM WAS NOT DUE TO NORMAL FAILURE, BUT MORE LIKELY DUE TO THE DEFECTIVE CALIPERS. THE CONSUMER STATED THE FRONT SEALS, ROTORS, FRONT AND REAR PADS AND SEAL OIL CAP WERE REPLACED. *JB UPDATED 03/10/11. *JB
TL* THE CONTACT OWNS A 2008 WORKHORSE W22 CHASSIS. THE CONTACT STATED WHILE EXITING A PARKING LOT AT LOW SPEEDS, THE BRAKES WERE DEPRESSED AND THE PEDAL FELL INTO THE FLOORBOARD. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER WHERE THEY ADVISED THAT THE HYDRAULIC FLUID HAD OVERHEATED AND LEAKED OUT OF THE VEHICLE. THE DEALER ALSO ADVISED THAT IT WOULD TAKE APPROXIMATELY FIVE DAYS BEFORE THE PARTS NEEDED TO REPAIR THE VEHICLE WOULD ARRIVE. INSTEAD, THE REPAIRS WERE PERFORMED WITH THE SAME DEFECTIVE PARTS THAT WERE INITIALLY ON THE VEHICLE. THE DEALER ADVISED THAT THE NEW CALIPERS WERE NOT YET AVAILABLE TO INSTALL ON THE VEHICLE. THE CONTACT STATED HE WOULD NO LONGER OPERATE THE VEHICLE UNTIL REPAIRS WERE COMPLETED DUE TO THE NATURE OF THE FAILURE. THE CONTACT DID NOT FEEL SAFE DRIVING THE VEHICLE. THE FAILURE MILEAGE WAS APPROXIMATELY 10,000. THE CURRENT MILEAGE WAS APPROXIMATELY 11,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
2008 HOLIDAY RAMBLER 34'. CONSUMER STATES PROBLEM WITH 2008 W22 WORKHORSE GAS TANK *TGW THE CONSUMER STATED THE CHASSIS HAS A 75 GALLON GAS TANK AND IT WAS DESIGNED TO BE USED AS A LEFT OR RIGHT FILL. SINCE HIS IS A LEFT FILL, THE MANUFACTURER CAPPED THE RIGHT SIDE. THE CONSUMER STATED THE CAP BEGAN TO LEAK. WORKHORSE PAID TO HAVE THE HOSE REPLACED. THE CONSUMER BELIEVED THE HOSE MATERIAL WAS NEVER MEANT TO BE USED FOR GASOLINE. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .